2023 Volvo VN technical service bulletins
224 technical service bulletins and manufacturer communications cover the 2023 Volvo VN.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- TSB
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- This CBR solution addresses the issue of binding between the outer air filter housing and inner HVAC box...
- Cbr
- Cbr - z
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr - 3
- Cbr
- Cbr
- Cbr - 13
- The purpose of the 48V EATS heater system is to provide additional heat to the exhaust stream allowing the...
- Cbr
- Cbr
- Cbr
- Inactive Code P25AE00 Being Generated After A Hard Pull And A Momentary Drop In Engine Oil Pressure (Low...
- It has been found that the hood may not properly deflect water away from the "bird-beak" openings around...
- Remote Control Central Door Lock, Programming; Key Fob Cannot Be Programmed Or Does Not Work After Programming
- Volvo Chassis equipped with Volvo Active Driver Assist may display DTC / Fault code SPN 516103 FMI 19 on...
- Volvo Chassis
- TSB
- Fleet Campaign
- Cbr
- Cbr
- Cbr - 11L, 13L
- Cbr
- TSB
- Cbr
- Cbr
- Cbr
- Sc
- Sc
- Sc
- This Service Campaign is the solution for vehicles affected by the Hub cover Insufficient Retention Recall...
- These repair instructions are intended to address the following fault(s): P009B-13 (Electric Pressure...
- Frame lean can be caused by several seemingly isolated possibilities
- Volvo Trucks has identified that some VN model vehicles equipped with auxiliary power unit batteries may...
- Vehicles may present with oil leak coming from the clutch/flywheel housing and observation of burned...
- 11L Engine Block Compatibility and Backward Conversion Parts Requirements
- Cbr
- Cbr
- Cbr
- Cbr
- Service Campaign: TGW3 Non-Communication
- Cbr - US17 ghg
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr
- Electrical system
- CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been...
- Engine
- Engine
- CBR: Overhead Wear Overview
- Cbr: 11L, 13L
- CBR: Volvo Chassis
- CBR: Diagnostic Trouble Code (DTC) U010187- Lost Communication With TECU
- CBR: Turbo Compound 2nd Generation
- CBR: Diagnostic Trouble Code (DTC) P107471
- CBR: Drivers Information Display (DID)Inoperative After Cluster Replacement And Programming
- CBR: Telematics Gateway (TGW) Connect Ability Issues
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr - 11
- CBR: Turbo Compound 2nd Generation
- CBR: Diagnostic Trouble Code (DTC) P107471 -AMT-F
- CBR: Turbo Compound (TC) Hot Side Noise, Diagnostic Information.
- CBR: Chassis Equipped With VECU5 Active Datalink/Communication Faults For Multiple Modules; ABS And SRS...
- Fleet Improvement Campaign: Certain Volvo VN model trucks have seat cushions that are thinner and wear...
- Fleet Improvement Campaign: Certain Volvo VN model trucks could experience deep rock chips in the hood...
- CBR: On a Volvo Chassis
- CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil
- CBR: After cluster replacement and programming, the Driver Information Display (DID) may not function as...
- Engine and engine cooling
- Cbr
- Cbr
- Cbr
- Cbr
- Fleet Improvement Campaign: (ABS) Software Update and Brake Inspection
- Cbr: tgw
- Fleet Campaign: Certain Wegman Volvo trucks could have an issue with the Rear Air Suspension not being set...
- Cbr: 11L
- Service Campaign: For certain Volvo Trucks configurations an updated adaptive cruise software has been...
- Service Campaign: Certain Volvo VN model trucks built with a D3 Dual PTO, have the incorrect length PTO...
- Parts Sales and Marketing Bulletin: Volvo Trucks is excited to announce an additional year warranty...
- Service Campaign: On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a...
- Fleet Improvement Campaign: Certain Volvo trucks could experience leakage from the Charge Air Cooler Pipe...
- Service Campaign: This Service Campaign is the solution for the Proprietary Hubcap Recall SC0425 that...
- Service Campaign: This Service Campaign is the solution for the Ship Shortage of Proprietary Hubcap Recall...
- Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver...
- CBR: Vehicle Speed Factor (K-Factor) Programming
- Fleet Campaign: TPMS Module Bracket Relocation
- CBR: Volvo Chassis
- Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement
- Service Campaign: Upper Radiator Hose Replacement (2.25 Crank Angle)
- Service Campaign: Upper Radiator Hose Replacement (4.00 Degree Crank Angle)
- CBR: Volvo VHD & VN Models
- Fleet Campaign: CAC Crimped Clamp Replacement
- Barksdale Leveling Valve, Leak Test
- CBR: Intermittent Diagnostic Trouble Codes U02A3,U029D, U029E
- CBR: Valve Stem Extension Contacting Outer Wheel
- CBR: Programming Failure
- CBR: Volvo Chassis
- Hood Cable Breaking or Binding
- CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00
- Volvo Chassis
- Cbr
- Infotainment System
- Cbr
- Campaign
- Cbr
- Cbr
- Cbr
- Cbr
- Cbr
- Service Literature Published and Released in May, 2023
- CBR: Diagnostic Trouble Code (DTC) P225C00 : NOx1 Sensor Stuck High
- CBR: Model Year 2017 to Current
- CBR: Automated Manual Transmission ( AMT )
- CBR: Automated Manual Transmission (AMT) Transmission Kickdown Mode
- CBR: Diagnostic Trouble Code (DTC) U1FFF68
- CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19
- On certain Volvo VN, VHD, VAH chassis, with a Meritor rear carrier, there is a possibility of the rear...
- Certain Volvo trucks could experience leakage from the Charge Air Cooler Pipe Crimp Clamps
- CBR: Volvo
- CBR: Volvo
- CBR: Diagnostic Trouble Code (DTC) P008A
- Adaptive Cruise Control, Deactivation
- Hub Cap, Leaking
- CBR: Volvo NOx Sensor Troubleshooting Guide
- Cbr: 11L
- SC: Anti-lock Braking System (ABS) software update and inspection
- CBR: Volvo On-Highway Vehicles
- CBR: Volvo Chassis
- Campaign for checking steering gear hardware torque
- Diagnostic Trouble Code (DTC) P107471
- Campaign
- New TSB for oil galley plug leaking oil.
- Sales Bulletin News
- 13L Oil Pickup Replacement
- Flywheel Housing Thread Repair
- Anti-lock Braking System (ABS) Software Update And Inspection
- Google Built In Premium Customer Experience Program
- Diagnostic Trouble Code ( DTC ) P10AE Logged In TECU With ACTIVE Or INACTIVE Status, Fault Code Cannot Be...
- Volvo Emission Label
- Timing Gear Plate Inspection
- TBS- Jumper Harness, Wiper Motor, Replacement
- Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver...
- Diagnostic Trouble Codes (DTC) P208064, P208464, P242B64 and P246F64 Lighting The Malfunction Indicator...
- Engine Control Module (EMS) Software (MSW) Information – October 2022; Improvement List (Change Log)
- Volvo DEF Pump Troubleshooting Guide
- (Back Office Only) Volvo Chassis
- Turbo Compound 2nd Generation
- Diagnostic Trouble Code (DTC) U1FFF68
- Battery Electric Vehicle (BEV)
- Volvo Chassis
- TSB Washer Reservoir Leak
- Volvo Battery Electric Vehicle (BEV)
- Diagnostic Trouble Codes (DTC) P24F600 Or P24F700
- Drive Axle Oil
- Volvo Chassis
- Part information for AMT input shaft repair kits and the shim kit that is required for repair.
- VADA, Front Radar Fulfillment
- 11L, 13L
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- Aftertreatment Hydrocarbon Injector (AHI) Troubleshooting Guide
- Particulate Matter (PM) Sensor Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Selective Catalytic Reduction (SCR) Muffler Troubleshooting Guide
- Oil Pickup Replacement
- Volvo Chassis
- (Back Office Only) Volvo Chassis Loss Of Cruise Control After Disabling Electronic Stability Program (ESP)
- Volvo Chassis Ghost Codes Due To Poor Grounding
- The Diagnostic Process
- B/O Volvo Park Brake warning POPup displays in DID when Park Brake is released and driver door is open...
- Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
- V-mac III
- Volvo Chassis
- Proprietary Fixed Axle Hubcap Replacement
- Proprietary Steerable Axle Hubcap Replacement
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- (Back Office Only) Volvo Chassis
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Volvo Chassis
VIN decoder
See the problems and recalls for an exact car
Buying a used 2023 Volvo VN?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history