2005 Volvo VT technical service bulletins
73 technical service bulletins and manufacturer communications cover the 2005 Volvo VT.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Engine Control Module (EMS) Software (MSW) Information – August 2022; Improvement List (Change Log)
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Volvo Chassis
- Volvo Chassis Ghost Codes Due To Poor Grounding
- The Diagnostic Process
- Volvo Chassis
- Volvo Chassis
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Volvo Chassis
- Instrument Cluster Programming
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Flywheel Resurfacing Guidelines, I-Shift
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine...
- Hill Start Assist Solenoid, Replacement
- Twin Mass Flywheel Conversion
- Timing Plate Leak Repair
- Range Synchronizer, Repair
- Twin Mass Flywheel Conversion, Transmission Removed
- Transmission ECU Compatibility
- Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
- Single Fuel Tank Ventilation Filter Kit
- Dual Fuel Tanks Ventilation Filter Kit
- Service Door Rust Prevention
- AMT High Range Cone Replacement
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes...
- Oil Level Sensor Harness Wire Splice
- Engine Data Label
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of...
- Engine Coolant Thermostat Software Update
- Floor Cracks Repair (Front Panel)
- Floor Cracks Repair (Rear Panel)
- Volvo trucks: during operation of driver side swivel seat and i shift transmission, the harness rubbing or...
- Volvo trucks: connector pin, replacement
- Volvo: light control module (LCM), reprogramming
- Volvo truck: fuel tank mounting
- Volvo: there may be leaks at the lower sleeper window
- Mack trucks: there is revised mounting hardware for the exhaust manifold and turbocharger
- Volvo truck: i shift transmission with mixed components
- Volvo truck: door seal, outer, replacement
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering
- Volvo truck; clutch switch clip; it has been found that vn, vhd and vt vehicles use a spring clip to...
- Volvo truck: on some vehicles, coolant overflow out of the overflow tube occurs during the diesel...
- Volvo: leakage detection diagnostics improvements to remedy dtc's
- Volvo truck: reports prompted the release of a replacement connector for the cab HVAC motor resistor
- Volvo trucks: mega fuse corrosion
- Volvo trucks: mega fuse breaking
- Service program trucks
- Sp 255-008, turbocharger, replacement, us vehicles only
- Volvo trucks north america - sp 366-002, active pressure coolant system module failure / built with a D16D...
- New technical courses available
- Enable idle shutdown icon
- Instrument cluster reprogramming
- Cooling system update, us vehicles only
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Volvo VT?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history