2009 Volvo VT technical service bulletins
102 technical service bulletins and manufacturer communications cover the 2009 Volvo VT.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Overheating has been observed at the alternator power cable and ground cable connection, resulting in...
- Cbr - z
- Cbr
- CBR: On Volvo chassis with an I-Shift and Mack chassis with an mDRIVE transmission, there have been...
- Cbr
- Cbr
- Volvo Chassis
- TSB-Charge Air Cooler t-clamp install.
- Part information for AMT input shaft repair kits and the shim kit that is required for repair.
- Engine Control Module (EMS) Software (MSW) Information – August 2022; Improvement List (Change Log)
- Warranty Automated Manual Transmission ( AMT, I-Shift, mDrive ) Control Housing Assembly; Guidelines For...
- (Back Office)
- DTC U012100
- Programming Failure
- AMT Control Housing Bench Testing
- Volvo Chassis
- Volvo Chassis
- Unable To Retrieve "On Request" Messages For PeopleNet Or Omnitracs Modules Installed On The DL5 Data...
- Diesel Particulate Filter (DPF) And Diesel Oxidation Catalyst (DOC) Pin Testing Procedure
- Temperature Sensor Troubleshooting Guide
- DEF Pump Troubleshooting Guide
- NOx Sensor Troubleshooting Guide
- DEF Level (UQLS) Sensor Troubleshooting Guide
- Fuel Level Gauge Reading Incorrect In The Instrument Cluster
- Electronic Stability Program (ESP), Electronic Stability Control (ESC): Changes And Removal Information;...
- (Back Office Only) Volvo Chassis
- Volvo Chassis
- Volvo Chassis Ghost Codes Due To Poor Grounding
- The Diagnostic Process
- Volvo I-Shift AMT Will Not Calibrate After Incorrect Flywheel Housing Is Installed
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Volvo Chassis
- Vida qr
- Shipping and Handling of Volvo Lithium-ion 48V Mild Hybrid Battery to Global Battery Solutions (GBS)
- Volvo Chassis
- Instrument Cluster Programming
- Volvo Chassis
- Cylinder Head Reuse And Replacement Guidelines
- Volvo Chassis
- Automated Manual Transmission (AMT) (Spigot Bearing) Input Shaft Repair Kit And Shim Kit, Part Number...
- Diesel Fuel Information
- Automated Manual Transmission Gearbox Will Not Shift To High Range After Gearbox Repair; MID 130 PSID 24...
- Volvo Chassis 2008 And Up LED Headlight Conversion Programming Procedure
- Volvo Chassis
- Volvo Chassis
- Automated Manual Transmission (AMT) Faults
- Volvo Chassis
- Flywheel Resurfacing Guidelines, I-Shift
- In some instances the exhaust rocker piston cap screw may become loose and back out causing loss of engine...
- On Volvo Trucks built between October 6, 2008 and August 18, 2014, with a factory installed programmable...
- Drag link replacement recall.
- Drag Link Replacement recall
- The draglink rod boot may be compromised and enable dirt/water to contaminate the draglink rod ball socket...
- The draglink rod boot may be compromised and enable dirt/water to contaminate the draglink rod ball socket...
- Hill Start Assist Solenoid, Replacement
- On some VOLVO VHD, VN, VT, and VAH truck models built between 04/31/2008 and 11/30/2015, the solenoid...
- Twin Mass Flywheel Conversion
- Timing Plate Leak Repair
- Range Synchronizer, Repair
- Twin Mass Flywheel Conversion, Transmission Removed
- Transmission ECU Compatibility
- Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
- Single Fuel Tank Ventilation Filter Kit
- Dual Fuel Tanks Ventilation Filter Kit
- Service Door Rust Prevention
- AMT High Range Cone Replacement
- Volvo truck: procedural information regarding the replacement of high range cone in the section of the...
- Volvo truck: due to internal build up contamination of grime, salt, road debris, in harsh environments,...
- Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes...
- Oil Level Sensor Harness Wire Splice
- Engine Data Label
- Volvo: on some trucks, there is an oil contamination into the engine wire harness because of a failure of...
- Engine Coolant Thermostat Software Update
- Floor Cracks Repair (Front Panel)
- Floor Cracks Repair (Rear Panel)
- Volvo: severe fretting damage of engine variable geometry turbocharger (VGT) actuator harness cause signal...
- Volvo trucks: during operation of driver side swivel seat and i shift transmission, the harness rubbing or...
- Volvo: to prevent erosion of engine fuel injector tips, fuel tank ventilation filter was added to vent...
- Volvo trucks: connector pin, replacement
- Volvo: light control module (LCM), reprogramming
- Volvo truck: fuel tank mounting
- Volvo: there may be leaks at the lower sleeper window
- Volvo: the front chassis harness may have been routed with the compressor air discharge line which CAN...
- Volvo: an exhaust pipe insulation blanket CAN deteriorate over time
- Volvo: information on fuel hose replacement
- Volvo: the LED indicator may display an incorrect cruise control set point
- Mack trucks: there is revised mounting hardware for the exhaust manifold and turbocharger
- Volvo: there are new clutch bearing lubrication tubes
- Volvo truck: i shift transmission with mixed components
- Volvo truck: door seal, outer, replacement
- Volvo trucks: the transmission has an input shaft that was threaded wrong which could cause leakage in the...
- Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 Volvo VT?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history