Volvo WXLL recalls
There are 11 safety recalls on record for the Volvo WXLL, covering 122,428 vehicles in total across all the models in each campaign. Newest first.
Volvo WXLL recalls by model year
2004 12003 22002 32001 32000 31999 31998 41997 41996 11995 2
All recalls
Power train: automatic transmission
- What is wrong
- On certain heavy-duty class 8 vehicles, the body builder wiring option was mis-wired in such a way that the auto neutral with service brake status option may allow the transmission to go into forward gear without the driver's foot pressing down on the brake pedal first.
- Risk
- Unintended movement of the vehicle could put persons in danger inside and outside the vehicle.
- Remedy
- Volvo trucks will notify its customers and install an additional air operated stop light switch and the necessary wiring changes. Owner notification is expected to begin during september 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact at 1‑800‑528‑6586.
Recall number 03V308000 · Recall details
Engine and engine cooling: engine: diesel
- What is wrong
- On certain transit buses equipped with cummins westport b gas plus or c gas plus 6 cylinder engines, the electronic control module calibration may not correctly detect a throttle plate actuator failure that could result in an uncommanded open throttle condition.
- Risk
- If this event occurs, the vehicle operator will not have control of the engine speed which could possibly result in a vehicle crash.
- Remedy
- Dealers will replace the electronic control module calibration free of charge. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact cummins customer assistance center at 1‑800‑343‑7357 or volvo truck at 1‑800‑528‑6586.
Recall number 03V183000 · Recall details
Suspension: multiple axle
- What is wrong
- On certain heavy duty class 8 trucks with volvo b-ride rear suspension, the forward and/or rear drive axle upper axle seat could break allowing the affected axle to shift out of alignment.
- Risk
- This condition could result in loss of axle stability, increasing the risk of a crash.
- Remedy
- Dealers will replace the upper axle seat on both rear drive axles. Owner notification began january 14, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1‑800‑528‑6586.
Recall number 02V317000 · Recall details
Power train: axle assembly
- What is wrong
- On certain heavy duty class 8 trucks, the forward and/or rear drive axle upper axle seat can break allowing the axle to shift out of alignment.
- Risk
- This could result in a loss of axle stability increasing the risk of a crash.
- Remedy
- Dealers will inspect the upper axle seat for a certain date code that is stamped on the part, and those axles will be replaced. Owner notification began march 15, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1‑800‑528‑6586.
Recall number 02V036000 · Recall details
Steering: linkages: tie rod assembly
- What is wrong
- Vehicle description: heavy duty, class 8, trucks equipped with tie rod assemblies containing 24-dl model ball sockets and manufactured by trw. Certain of the tie rod ball-socket bearings have a below-specification case depth and/or hardness, which can lead to premature wear of the socket.
- Risk
- If this condition occurs, the driver can lose partial control of the right front wheel, possibly resulting in a crash.
- Remedy
- Dealers will replace the defective ball sockets and/or drag links. Owner notification began during may 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact volvo trucks at 1‑800‑528‑6586.
Recall number 01V044013 · Recall details
Wheels: rim
- What is wrong
- Vehicle description: heavy duty trucks equipped with accuride 22.5 x 8.25 15 tubeless demountable rims, part no. 32051. Certain rims contain a non-fusion area in the butt-weld of the mounting ring. Under certain circumstances, the defect could develop into a crack on the mounting ring.
- Risk
- Over time, the crack could propagate and if not heeded, could result in mounting ring failure, potentially causing the rim to separate from the vehicle.
- Remedy
- Accuride will inspect and replace the defective or suspect wheel rims.
Recall number 00V190002 · Recall details
Service brakes, air: antilock
- What is wrong
- Vehicle description: heavy duty trucks built with bendix air ABS with an ec-17 1030r electronic control unit (ecu), there have been reports of unwanted ABS activation at low speeds caused by 1) chafed ABS wheel speed sensor wires on rotating parts or 2) a damaged component at the wheel end that generates a certain type of erratic sensor signal.
- Risk
- This condition could cause the ABS ecu to exhaust the air at the air brake modulators for one or more of the wheels. This could result in extended braking distances and a possible crash.
- Remedy
- Dealers will replace the ABS ecu.
Recall number 00V232003 · Recall details
Suspension: front: springs: air suspension: lines and fittings
- What is wrong
- Vehicle description: class 8 heavy duty trucks. The air suspension control valve supply line was not plumbed through an air pressure protection valve. In the event of a failure, there would be loss of air pressure in the 'b' system air reservoir that supplies air pressure for the front steer axle brakes.
- Risk
- This condition would result in increased stopping distances.
- Remedy
- Dealers will install the necessary air pressure protection valve.
Recall number 98V255000 · Recall details
Wheels: rim
- What is wrong
- Vehicle description: heavy duty trucks equipped with aftermarket aluminum dual wheels, 22.5x8.25, one-piece, tubeless, supplied by accuride/akw. Certain design revisions combined with process conditions caused fatigue cracks in these wheels.
- Risk
- This condition can cause failure of these wheels.
- Remedy
- Accuride/akw will replace these wheels.
Recall number 98V120001 · Recall details
Suspension: front: wheel bearing
- What is wrong
- Vehicle description: class 8 heavy duty trucks. The steer axle wheel bearing jam nut lock washer may not have been bent over the jam nut after the wheel bearings were adjusted.
- Risk
- If this condition exists, the jam nut and wheel bearing adjusting nut can back off the spindle allowing the wheel and the brake drum assembly to separate from the vehicle increasing the risk of a vehicle crash.
- Remedy
- Dealers will inspect the steering axle wheel bearing jam nut lock washer to determine if it is bent over the jam nut, and if not, repair as required.
Recall number 97V212000 · Recall details
Service brakes, hydraulic: foundation components
- What is wrong
- The rear most axle of the tandem axle set could have inoperable brakes on one or both wheels because the brake s-cam was incorrectly installed.
- Risk
- This condition could cause increased stopping distance increasing the potential for a vehicle accident.
- Remedy
- Dealers will inspect the brake system and repair the s-cam assembly if found reversed.
Recall number 96V157000 · Recall details
Questions about the Volvo WXLL recalls
How do I check if my Volvo WXLL has an open recall?
Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.
Do I have to pay for a recall repair?
No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.
How many recalls does the Volvo WXLL have?
11, covering power train, engine and engine cooling and suspension.
VIN decoder
See the problems and recalls for an exact car
Buying a used Volvo WXLL?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history