Tl* the contact owns a 2004 volvo xc90. While driving 60 MPH, the engine stalled with the illumination of the brake and air bag warning lights. The contact was able to restart the vehicle within five minutes after several attempts. The vehicle was taken to an authorized dealer where the contact was awaiting the results of the diagnostic test. The manufacturer was not contacted. The VIN was not available. The failure mileage was 115,000.
2004 Volvo XC90 engine complaints
Page 3 of 3: complaints 41 to 52 of 52, newest first, as owners wrote them.
We just purchased a 2004 volvo xc90 t6 on june 2, 2010 from a private seller who originally purchased the vehicle and have it maintained fully at rickenbaugh volvo in denver. We are first time owners of a volvo vehicle. The car currently has 76,783 miles on it. After just owning the vehicle for 4 weeks and adding just 400 miles on the vehicle, the check engine light went on and while driving to the rickenbaugh volvo service station, a message came up with 'urgent transmission service required'. We were told by the service manager that the car needs new transmission with radiator, oil cooler and oil cooler lines in the amount of $7,800.00. My wife and I were shocked and decided to take the vehicle home because we cannot afford this expense after just saving money for a year to purchase the vehicle 4 weeks ago. The vehicle was fully serviced at rickenbaugh and a 75,000 mile service was done on may, 2010. We went and searched the internet for problems with 2004 volvo xc90 and found that there are a lot of reports of transmission issues/problems. Please call me at [xxx] . [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
Purchased an '04 volvo xc90 t6 on may 1st from a private seller. Did research on the vehicle through msn reliability, volvo, etc. Only issue highlighted was engine concerns, not transmission. It wasn't until the transmission went out on june 6th that I found numerous consumer complaints about the transmission going out at around 60k miles. Mine went out at approx. 57k miles. I've contacted volvo and asked about recalls, etc. And was told I should've driven my car, or had it towed 40+ miles to the dealership to have it diagnosed to then have it repaired at the dealership so that I might get a reimbursed. About two weeks prior to the "transmission service urgent" message on the dash I received a "coolant low stop engine." I've taken my volvo to a certified volvo repair service where the cost is going to be $5,335. The transmission went out after getting off the interstate and coming to a stop at a red light. When I tried to accelerate the car just wound.
1. I was driving my vehicle when the transmission did not shift from 2nd gear up on the highway. The check engine light came on, coolant low and urgent service of transmission. 2. The transmission issue was constant. 3. We took our vehicle to the volvo dealership garage. It was determined that we needed a transmission replacement as well as coolant and other engine parts replaced. We were told that the faulty transmission damaged these other parts. We spoke to volvo customer service and they originally acknowledged a problem with the t6 transmissions and said that volvo would pay for the parts but not labor. We found out the labor would be $2000 or more. We called volvo back and spoke to a debbie that threatened us if we pushed for volvo to pay for labor, she might take back the original offer of paying for parts and told us she might have been willing to pay for labor if we had used a volvo dealership for all of the inspection or other service saying "money in and money out of volvo".
Transmission failure twice and fuel pump replaced and still leaking in our volvo xc90 2004 t6 truck. Volvo replaced the transmission twice, but we still had repair costs both times. Fuel pump replaced and still leaking causing large amounts of gas fumes in vehicle. Taking into volvo to fix fuel pump again today that is covered under the recall but just got it back from 2nd transmission repair where I had to pay for the internal engine leaks that could not be detected that in turn contaminated the 2nd transmission. I do not believe I should have paid $1600 in repairs when it has been serviced and cannot detect these internal oil leaks from the engine. This make and model year has been costly and dangerous. Truck has stopped in the middle of left turn, almost resulting in head on collision. This truck seems to fall under lemon law. We have had problems with this truck since 2007.it has had 2 transmission replacements and now 2 fuel pumps,both volvo pumps. I should incur zero costs other than oil changes and general maintenance. These are major equipment failures in this volvo xc90 t6 2004 and the entire vehicle should be recalled. I will be submitting my repair costs to volvo north america. Thank you for your review of this in advance.
Failed transmission; sudden/unanticipated loss of acceleration; at dealership for complete transmission replacement including required replacement of radiator and fuel lines.
Engine failure. Symptoms started with starting difficulty. Replacement of RPM and cam sensors followed. Symptoms continued with trouble shooting leading to discovery of damage to flywheel and bell housing. Crankshaft out of spec for front to back movement. Dealer recommendation to replace engine. Dealer believes most likely cause related to thrust bearing failure. Engine and car always maintained to manufacturer's recommended schedules. Car is out of warranty. Although no claim of owner failure, volvo refuses to stand behind product or assist in any way with major product failure.
Tl*the contact owns a 2004 volvo xc90. The contact noticed transmission and radiator fluid near her vehicle. She experienced hard shifting when changing gears. While driving approximately 55 MPH, the transmission light illuminated on the instrument panel. The contact pulled over and turned off the vehicle. The vehicle would no longer "pull" and was towed to the dealer. She was informed that a new transmission and radiator were needed. She also found out that the radiator coolant contaminated the transmission. The repair would cost approximately $5,900. The contact wrote a letter to the president of the manufacturing company, but did not receive a response. She also spoke with the manufacturer's customer service line and was informed that they could not assist because the vehicle was outside of the warranty. The current mileage was approximately 122,000 and failure mileage was approximately 100,000.
Transmission replacement on 2004 volvo xc90 with 41,000 miles.
Transmission replaced june 08 front control arms and bushings and coolant reservoir replaced sept. 08 thermostat & housing & temp sensor replaced jan. 08 brake vacuum pump replaced for 2nd time jan. 08 brake vacuum pump replaced sept. 07 gasket, o-ring, hose clamp recall sept. 07 power steering pump and brake vacuum pump installed july 07 steering rack solenoid replaced july 07 - (recall may 3, 08?) new bridgestone tires may 07 upper engine torques mount replaced march 07 recall wiper arm 156, ball joint 157 oct. 06 brake pad & rotors replaced oct 06 upgrade software a & c july 05 ABS brakes warranty fix may 06 front pads & rear pads & rotors replaced dec. 05 exhaust rubbing on driveline, install kit to hold exhaust off driveline dec. 05 left rear wheel bearing & hub, rear pads & rotors replaced june 05 4 new tires june 05 turbo control valve replaced march 05 front pads and rotors replaced oct. 04.
Transmission failure on our 2004 volvo xc-90 t6 awd at approximately 56,000k miles. Fortunately it was a warranty repair; however my research on automotive discussion boards like edumds indicates a very large pattern of failure of the transmission on this model.
Thank you letter regarding volvo's response to consumer problem.***no answer required***. *mr the vehicle's engine failed at only 10500 miles due to sludge in the engine. The manufacturer claimed that the vehicle was improperly maintained although the consumer provided them with service receipts.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Volvo XC90?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history