2004 Volvo XC90 suspension problems

Filed Jan 5, 2019 · Suspension · 160,000 miles · FL

I keep getting that the anti-skid needs to be serviced but when I got it checked they reported that they couldnt find anything wrong with the anti-skid and the error is constantly lit in the service window of the vehicle. I can feel the difference while driving in wet conditions. Is there anything specific they should look for other than advising me that its probably a sensor. I don't feel safe driving in rain.

Filed Jun 2, 2016 · Brakes, Suspension · 125,000 miles · NJ

Car moved to right when applying brakes. Car clunks when making turns. Car very noisy when going over bumps/ potholes.

Filed Feb 4, 2015 · Suspension · 98,000 miles · CT

Tl* the contact owns a 2004 volvo xc90. The contact stated that while driving approximately 15 MPH, the front end of the vehicle independently traveled out of lane. In addition, the anti skid warning light illuminated. The failure recurred continuously. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 98,000. Kmj

Filed Jun 20, 2010 · Airbags, Suspension · 90,000 miles · CA

2004 volvo xc 90 and transmission is failing, as well as motor mounts, wheel bearing boots, etc. Dealer knows about these recurring issues with others of same year, but claims it is only my issue. Purchase price was ~$55k and with only 90k miles I should not now have to spend ~$5k for a new tranny. Rip-off

Filed Jan 14, 2009 · Suspension, Transmission · 15,000 miles · GA

Transmission replaced two times, at approx. 38,000 and at about 48,000 miles. Units start slipping when shifting to second gear and leave you right where you are until they decide to rengage. Ball joints and all four hubs replaced by 50,000 miles. Axles (front) need replacing now at 70,000 miles. Sway bar ends replaced at 55,000 miles. This is the neediest vehicle I have ever owned. Front bearings on drive shaft replaced last month, worn since abut fifteen thousand miles, finally got so loud that we could shake the drive shaft and get a quarter of play at the bearing set.

Filed Jan 7, 2009 · Suspension · 50,000 miles · AL

Add me to the growing list of xc90 owners that have experienced the replacement of front axles and rear wheel bearings. My 2004 xc90 has less than 50k miles and both of the aforementioned items were replace at a cost of $2k......this seems a bit of excessive for vehicle that is marketed under the banner of safe and reliable..."built for life."

Filed Nov 25, 2008 · Suspension · 67,000 miles · NY

Tl*the contact owns a 2004 volvo xc90. While driving approximately 20 MPH, the passenger side tire detached from the axle. The vehicle was towed to a dealer and they stated that the axle and ball joint failed. A police report was filed. The current and failure mileages were 67,000.

Filed Oct 8, 2008 · Suspension · 80,000 miles · MA

Tl*the contact owns a 2004 volvo xc90. While the vehicle was being examined, the contact was informed that both front tie rods needed to be replaced. Prior to this information, he noticed that the tires on the vehicle were wearing faster than expected. The current and failure mileages were 80,000.

Filed Sep 15, 2008 · Engine, Steering · 76,000 miles · AR

Transmission replaced june 08 front control arms and bushings and coolant reservoir replaced sept. 08 thermostat & housing & temp sensor replaced jan. 08 brake vacuum pump replaced for 2nd time jan. 08 brake vacuum pump replaced sept. 07 gasket, o-ring, hose clamp recall sept. 07 power steering pump and brake vacuum pump installed july 07 steering rack solenoid replaced july 07 - (recall may 3, 08?) new bridgestone tires may 07 upper engine torques mount replaced march 07 recall wiper arm 156, ball joint 157 oct. 06 brake pad & rotors replaced oct 06 upgrade software a & c july 05 ABS brakes warranty fix may 06 front pads & rear pads & rotors replaced dec. 05 exhaust rubbing on driveline, install kit to hold exhaust off driveline dec. 05 left rear wheel bearing & hub, rear pads & rotors replaced june 05 4 new tires june 05 turbo control valve replaced march 05 front pads and rotors replaced oct. 04.

Filed Apr 4, 2008 · Suspension · 68,000 miles · WI

Approximately 10 months ago my 2004 volvo xc-90 awd had a complete failure of my right rear wheel bearing at 68,000 miles. The dealer recommended repairing both wheel bearings since "it is a common failure on volvo vehicles" with that in mind, I had them both replaced at a significant financial cost to me. Now, I have been told the angle gear (which drives awd and is directly tied to the rear wheels) has "burnt out" and is (according to my service advisor) "tied to the previous wheel bearing issue" I had just 19, 000 miles ago. The cost for this repair is $2900 ($1875 just for the part) all at another huge cost to me. All in all, I've spent over $4100 dollars on the rear wheel/angle gears - nothing you should ever have to do before the vehicle is even 4 years old! Upon doing research and talking to other volvo owners, it is very well documented that there is a defect in volvo's design and performance of their wheel bearings and awd system, yet no one is doing anything about it. Volvo just provides lip service and doesn't seem to want to admit there is a problem , regardless of the repetitive complaints they have received on these very concerns. I have rigorously maintained this vehicle according to volvo's recommendations and know these issues aren't caused by any neglect on my behalf. Volvo is playing with peoples lives and money by not taking prescriptive steps to correct these issues - all at a tremendous financial cost to their customers. There needs to be a recall before any serious injuries or deaths occur from failure of these critical vehicle parts, if not, it's only a matter of time before something bad happens.