2022 Volvo XC90 electrical problems

Filed Oct 19, 2026 · Driver assistance, Electrical · NY

My 2022 Volvo XC90 (VIN: [XXX]) has a recurring failure of the center touchscreen display, which controls the climate system. Almost daily, the display shuts off while I’m driving and does not reboot. When it fails, I cannot use the heat, the windshield defroster, or the defogger. As cold weather sets in, this is a serious visibility and safety hazard. On XXX, at approximately 35,400 miles, I took the vehicle to the authorized Volvo dealership in [XXX] (repair order #XXX). I paid approximately $366 for a software reset. The repair did not fix the problem. Since then, the system crashes right after startup. It also intermittently plays loud white noise through the speakers, at random times and without warning while I’m driving. The sudden loud noise startles and distracts the driver. The dealer’s technician said he would submit a report to Volvo engineering. I have also opened a case with Volvo Car USA Customer Care. As of XXX, the vehicle has not been repaired, and the failures continue regularly. I have heard nothing back from Customer Care or the dealership despite repeated attempts to contact them respectively. Summary of hazards: Loss of windshield defrost and defog, which reduces visibility. Loss of cabin heat in winter conditions. Sudden loud audio noise that distracts the driver. A control screen that cannot be relied on while driving. I am asking the federal safety agency to review this as a potential safety defect affecting the center display and climate control on this model. Thank you. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 25, 2026 · Electrical · MI

In the middle of a cold snowstorm the screen froze and started glitching. As I was trying to change the drive mode to all wheel drive the ESC off button triggered and ESC stayed off without AWD mode and screen was unresponsive. Had to pull over and turn car off and back on for screen to reset.

Filed Sep 22, 2025 · Electrical, Fuel system · NC

My car is a 2022 Volvo hybrid T8, 6-passenger XC90. I purchased the SUV in August of 2023 as a "certified pre-owned" vehicle with only 17,923 miles on it at the time of purchase. This SUV has been fine until within the last two to three months (July-Sept. 2025). Now, in Sept. of 2025, my SUV only has 30,795 miles and we have had it serviced regularly, as required, and taken care of it as responsible vehicle owners. Beginning around June or July of 2025, I began seeing the "check engine" light, so I called the dealership where I purchased the vehicle and took it in for servicing. After a day, they said it was fixed and that it was a blown fuse or two, and it was good to go. Not even 3 weeks to a month later, the "check engine" light came on again. I called and took it back to the dealership. Same story, after less than a day they called me back after fixing something else (don't remember off the top of my head what they said it was, but it was allegedly minor). Now, about 3 days ago, Sept. of 2025, I began seeing the "check engine" light again, so for the 3rd time in less than 3 months I arranged for it to be serviced by the dealership again on 9/30. A day later, another "Propulsion System/maintenance required!!!" light came on as well, so I called to get servicing sooner because obviously the message is scary. I was told to bring it in, they would "work me in" but had no loaners I could use to get to and from work. So, at that point, I got my husband involved and now no one from the dealership is returning either of our calls, AND I'm being told there is no recall on my car, even though a simple google search reveals there is a recall on my same make/model/year SUV. I'm getting the same messages people got about the recall, so no clue why my vehicle isn't considered as part of the recall when I am having the SAME issues as the recalled vehicles are having. I am beyond frustrated and ready to dump this SUV if they are unable to properly repair it!!!!!

Filed Jun 20, 2025 · Electrical · CA

The contact owns a 2022 Volvo XC90. The contact received notification of the federal safety agency Campaign Number: 25V179000 (ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Jun 6, 2024 · Electrical · MI

There have been three incidents where the following happens: While driving in regular suburban driving, the entire infotainment system and cluster panel (all digital--odometer, tachometer, everything) shut off entirely (go black) and the climate system also shuts off. It goes through some reset cycle and then eventually restarts after several seconds. Both times it has been right after pressing some button on the steering wheel that controls the infotainment or doing some operation with the infotainment system such as skipping a track or making a call. Apple Car Play has not been in use. The first time it was 4-5 months ago (2024). The second time was about 2 months ago. The third time was on June 6, 2024. This third time, while at a red light, everything went black and even the car shut off. Luckily, the car was not moving and within a couple of seconds, without touching anything or changing anything, it restarted itself and the infotainment system and cluster rebooted. I am concerned that this may eventually happen while the car is moving. Will be taken to the dealer for review/repair immediately.

Filed Mar 22, 2024 · Electrical, Engine · NY

I was going 60 mph when the check engine light came on , the car started to jerk and reduce speed. I pulled onto the shoulder until the car stopped. I than proceeded to drive slowly and the turtle appeared on the dash. I drove about another mile until I reached my home doing 30 miles per hour or less.

Filed Nov 23, 2023 · Electrical · CA

The vehicle is equipped with wireless phone charger. I was charging my phone and could not lift it off the charger with my bare hand. According to the dealership test, their test started at 80 degrees Fahrenheit and tested after 10 minutes at 102 degrees Fahrenheit. The dealership stated that the charger is operating as designed. The phone was too hut to handle and could have caused an accident.

Filed Nov 23, 2023 · Driver assistance, Electrical · CA

Front sensor not detecting objects when parking. First time the dealership checked it, they said it was operating as designed. The second time, while driving on the freeway, I got a blind spot sensor service required warring error on dashboard. The dealership said that there was a bug residue on the outside sensor.

Filed Nov 23, 2023 · Electrical · CA

The vehicle is equipped with Park Assist Camera. It automatically activated when reverse gear is engaged. The camera is angled is a way where display screen on front dash shows about half inch of the license plate. According to the dealership, the camera could not be adjusted and it is operation according to factory specs. This is safety issue as it distract the driver.

Filed Sep 8, 2023 · Electrical, Locks · FL

The vehicle locking system malfunctioned, locking itself with the keys inside the vehicle. The vehicle was in park, the engine was off, I was only out of the vehicle for 30 seconds to 1 minute in time while filling my gas tank. My dog was inside the vehicle, in the back with no access to door locks or keys, it was 90* outside, he was locked in the car for 30minutes until the fire department arrived and broke the rear passenger a window. The vehicle will go in for diagnostic testing 9/12/23 at a Volvo dealership. Volvo USA refused to note the safety concern, they believe the vehicle operated as designed to self-lock if you forget. My vehicle has never self locked in the 1.5 years of owning it, rather it sends you an alert to your phone to inform you that it is unlocked- it does not lock itself. There have been no lights to alert of any possible concerns.