After starting the vehicle I noticed an unusual whine. After a few seconds of idling I noticed that it smelled like something was on fire. I turned off the vehicle and began looking for smoke. I did not find it. After a little research I discovered that it is a very well known failure that the Balmar alternator on Winnebago EKKOs fails catastrophically, sometimes catching on fire. I followed instructions to disable the Balmar. I let the vehicle cool completely. I restarted the vehicle and let it idle for a long while and the whine and the smell never returned. I used the Lithionics app to confirm that the batteries were not being charged while the engine was idling.
Winnebago Ekko whining noise problems
19 of the 118 owner complaints about the Winnebago Ekko describe whining or grinding noise, most of them for the 2022 model year.
- owner complaints
- 19
- worst model year
- 2022
Is there a fix? No recall or service bulletin covers this area of the car yet.
By model year
Often reported together
What owners say
We had reported on Sat, 3/21/26 to Winnebago that we noticed our Balmar alternator had stopped charging the battery the night before on Fri, 3/20/26 during a 2.5 hour trip to Sebastapol, CA. We drove to Santa Clara, recharged batteries with shore power and then drove to Santa Cruz, CA. This morning on Sun 3/22/26, our 2nd Balmar Alternator installed by NIRVC/Las Vegas in Mar-April 2024 under the 174 Recall caught on fire. Fortunately, we were idling in a parking lot before getting on the freeway, and could hear the whining noise, smell the burning alternator, and see the smoke coming out of the engine before the fire grew too large. We were able to extinguish the fire and keep the damage limited to the Balmar alternator. Had we gotten out onto Highway 17, ours and others lives could have been severely impacted, as we likely would not have noticed nor been able to deal with the fire as quickly. We have unplugged the 4-pin wire plug from the Balmar regulator. Once we restarted the engine, a piece of plastic came flying out, and then everything started spinning freely. We were able to drive home. We have reported the fire to Winnebago and are awaiting communication as to next steps. We have video footage of the fire and vehicle is available for inspection.
The second alternator, Balmer, used to charge the lithium batteries overheated and failed. It is located under the hood near the engine. It made a whining sound and failed to charge. I took it to Camping World in Marysville and they said the sound was “normal” and preformed the deregulation . A few months later, I brought it back and after insisting on inspection and calling Winnebago, they said it had failed. This is the second time it has failed. I am still waiting for a replacement as Winnebago says they are back ordered. I am now without a charging system, but at least my vehicle didn’t catch on fire like others have. This is an unacceptable problem that Winnebago refuses to remedy.
Reference the federal safety agency Safety Recall 23V‑234 Just experience failure of second Balmar alternator at about 26,000 miles. Replacement of first failure was done in conjunction of above referenced safefy recall. Work was performed in March of 2024. Subsequent to the above referenced recall Winnebago issued a Service Campaign (75-09) to derate (adjust/lower alternator output settings)in order to reduce the risk of overloading the alternator. The service campaign work was completed in June 2025. Numerous other Ekko owners have experience multiple Balmar alternator failures including some that have caught on fire. I was aware of the early warning signs of problems (high pitched whine that varies with RPM's and alternator output that drops to near zero) and proactively unplugged/disconnected the alternator before potentially serious consequences arose. My situation, and those of other Ekko owners clearly shows there is a design and/or quality issue that requires corrective action.
The Balmar alternator installed on our RV, which provides electrical power to charge the coach battery started a noticeable whine at idle, it stopped providing a charge to the coach battery, and upon further inspection, after opening the hood, we noticed a faint burning electrical smell. To confirm that the Balmar alternator was failing, I checked its electrical output to the battery, and it was not charging. I then proceeded to unplug the regulator for the alternator to see if the whine and smell were still present. They were not. Since the whine was not present with the Balmar alternator unplugged, the burning smell had dissipated, and no charge coming from the alternator when plugged in, I determined it was starting or already failed. Knowing that there have been multiple reports from other owners that their EKKO's caught fire or had severe smoke coming from the engine compartment, that was later found to be the Balmar alternator, I made the decision to leave it unplugged. I was concerned about our safety and the real possibility of a fire if we continued with it plugged in and running. This just happened to us so we have not had it looked at by a dealer or independent service center yet, but we could make it available for inspection upon request. Please note, this is the second Balmar that has failed on us in our four year ownership of this RV, and we have a friend that has had five Balmar's fail on him! Winnebago needs to be held accountable and should be required to remove and replace the Balmar alternator from all owners RV's and replace it with a more suitable and capable alternator that will provide the secondary power they advertise when they sell this model to consumers.
October 10, 2025. The vehicle is a 2022 Winnebago EKKO RV on a 2021 Ford Transit with 49,000 miles. The incident occurred after driving the vehicle for about 5 minutes with outside temperatures around 50 degrees Fahrenheit and noticed an unusual high pitch whine. When I opened the hood the Balmar MC-618 Alternator unit was extremely hot, smoking, and had a strong burning smell. Since the EKKO models have had numerous reports of secondary alternator/Balmar malfunctions I knew enough to disable the alternator by unplugging the 4 pin connector on the Balmar 618 regulator before traveling any further. The following morning I plugged the Balmar unit back in and the whining sound and burning smell immediately returned. There is a the federal safety agency Safety Recall 23V‑234, Campaign # 174 EKKO 12V Charging System, sent out by Winnebago for this very safety issue due to fires. This recall was completed during the time that the original owner had this 2022 Winnebago EKKO (prior to our purchasing this 2022 Winnebago EKKO in June 2024). There have been numerous failures on Balmar units that have had the campaign #174 recall completed, including ones performed at the factory. The Winnebago fix is obviously not working and is still an extreme fire issue.
The vehicle is a 2021 Ford Transit with a 2022 Winnebago Ekko RV. The incident occurred when I started the engine and noticed an unusual high pitch whine. When I opened the hood the Balmar unit was extremely hot with a strong burning smell. Since the Ekko models have had numerous reports of secondary alternator / Balmar malfunctions I knew enough to disable the alternator by unplugging the 4 pin connector on the Balmar 618 regulator before traveling any further. The following morning I plugged the Balmar unit back in place to see if the high pitch sound reoccurred. The sound immediately returned and I used my infrared thermometer which read 438 degrees Fahrenheit on the Balmar alternator. The Lithionics battery app indicated the batteries were 90 percent full but would no longer charge, leaving me only shore power to recharge the batteries. There is a the federal safety agency Safety Recall 23V‑234, Campaign # 174 Ekko 12V Charging System, sent out by Winnebago for this very safety issue due to fires. We had this recall completed at the Forest City Iowa Winnebago factory in April of 2024. There have been numerous failures on Balmar units that have had the campaign #174 recall completed, including ones performed at the factory. The Winnebago fix is obviously not working and is still an extreme fire issue.
Sudden loud whine varying with engine speed, coming from engine compartment, traced to secondary balmar alternator. Alternator was extremely hot, we shut engine off and electrically disconnected alternator. We knew to do this because others have posted this information, some have caught fire. This was close to combusting as well. No noise is present when electrically disconnected, but noise resumes if connected and load placed on alternator. This was the subject of winnebago prior recall 174 (which was performed in 2024). We believe it is unsafe to operate the vehicle with this alternator connected, that it will result in an engine compartment fire.
The Winnebago factory installed secondary alternator (manufactured by Balmar) responsible for charging the batteries in my motorhome started to whine and overheat. Luckily the week prior, I had read about another EKKO owner experiencing the same symptoms before it created enough smoke that caused the driver to immediately pull off the road and extinguish the engine bay with a fire extinguisher. In an effort to avoid that, I disconnected the Balmer until it was able to be replaced. This original problem was supposed to be addressed in recall 174. Over a year later the recall supposedly addressed the issues by moving the regulator out of the engine bay, replacing the Balmer and a major reworking of the electrical system. After multiple components failed during the recall repair, my EKKO took over 6 weeks to get a working solution at a Winnebago dealership. That was a year ago. 10 days ago the same symptoms of whining and overheating returned resulting in me returning to the same dealer with them diagnosing the Balmer as defective and a health risk. Had I not disconnected the Balmer it would’ve overheated and resulted in melting the primary drive belt and potentially damaging the engine and other major components as documented by numerous other EKKO owners.
Balmar whine has indicate to be the first step before fire starting in the engine compartment
Related recalls
No recalls on record for this model year.
Questions about the Winnebago Ekko whining noise
Which Winnebago Ekko years have whining or grinding noise problems?
The model years with the most reports are 2022 (7 complaints), 2023 (7 complaints) and 2024 (3 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Winnebago Ekko?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history