2002 Workhorse P320032 brakes problems

Filed Apr 9, 2021 · Brakes · 37,000 miles · MI

Parking brake locked up on the road. 60mph on I-65 north bound south of bowling green ky. Tire blew before we stopped - as result ? -one on the rear dually, (we had planned to replace tires when we got home) had to disconnect parking brake on side of the freeway. Mileage on odometer approx 37,000. Limped on shoulder 15 miles into bowling green and left vehicle at camping world. Had all new tires installed and returned following week to drive home to michigan with auto park system disconnected. Using wheel chocks now. Trying to figure out a better parking brake system as these are a known ongoing issue.

Filed May 18, 2012 · Brakes · AL

2002 motor home workhorse chassis p30. Consumer writes in regards to safety recall notification #51101-c *tgw the consumer was informed his vehicle identification number was not included in the recall, even though the rv was built during the correct period.

Filed Jul 29, 2011 · Brakes · 32,000 miles · NY

I own a 2002 landau by georgieboy class a motor home workhorse chassis which is having the exact brake failure problems described in recall campaign 09v193000 workhorse numbers w20, w22 and w23 units. I have a p32 which is not included in your recall for workhorse. I contacted workhorse and was told that my unit is not covered in this recall. I had complete brake failure while driving on highway (boiling brake fluid). Why, if, it is not covered by recall why am I having this safety problem??? The unit is equipped with bendix brakes and not bosch as stated in recall.

Filed Feb 7, 2011 · Brakes · 14,102 miles · MA

Tl*the contact owns a 2001 damon daybreak with a workhorse p30 chassis(na). While driving approximately 4-45 MPH, the caliper froze suddenly in the open position. The rv dragged and the contact smelled a burning odor. The contact engaged the brakes but the pedal extended to the floorboard. The brake light illuminated on the instrument panel after the failure. The contact used the emergency brake to stop. The contact called the manufacturer who offered no assistance. The vehicle had not been repaired. The current and failure mileages were 14,102. Updated 04/07/11

Filed Aug 22, 2009 · Brakes · 25,250 miles · GA

Reference the federal safety agency recall 09v1100. This recall is for faulty calipers on workhorse chassis w20,w21,w22. My workhorse p32 chassis has the same problem, except my was more serious than descrice in the recall.

Filed Aug 7, 2009 · Brakes · 43,000 miles · NJ

Tl*the contact owns a 2003 winnebago sunova itasca rv (na). While driving 40 MPH, the contact smelled an odor similar to brake fluid. As he attempted to pull over, the brakes failed and the brake pedal depressed down to the floor. He touched the hubcab on the driver's side of the vehicle and noticed that it was extremely hot. He pulled out the fire extinguisher because he believed that the vehicle would catch fire. The contact called a truck center and the mechanic stated that the calipers were faulty. The mechanic stated that they have inspected several motorhomes with the identical failure. Workhorse was called and they stated that the vehicle did not qualify for the brake recall repair. The motorhome is currently at the dealer. The vehicle was repaired at the cost of $700. The failure and current mileages were 43,000. Updated 10/20/09 *cn the motor home is on a workhorse chassis. The consumer inspected the drivers side wheel and found it to be extremely hot. The rv was taken to a repair shop. An inspection revealed the front calipers had seized. The consumer was informed his VIN did not fall within the recall. Updated 10/22/09.

Filed May 22, 2007 · Brakes · MI

2003 airstream 26' motorhome customer states that he continues to have brake problems similar to those expressed in the recall**cc the consumer stated the heating of the brakes and the excessive squealing were more noticeable while driving in traffic. The consumer was informed the p chassis was not covered in the recall.

Filed Oct 25, 2004 · Brakes · AR

The parts to perform the bosch zops brake calipers recall 04v084000 repairs were not available to the dealership for a month.

Filed Aug 22, 2004 · Brakes · 24,314 miles · VA

Motorhome 2002 workhorse chassis; autobrake system, 2 pressure valves; one at the fluid tank, second is attached to the driveshaft brake housing. Both valves failed at 24k and 27k miles respectively by exploding and the other leaking fluid to the electrical out wires thus shorting out the system. This results in the m/h being totally unable to move [ locked driveshaft] without be towed. Extremely dangerous to occupants and other traffic.

Filed Sep 9, 2003 · Brakes · MO

Consumer called complaining about parking brake problems. Parking brake failed, and consumer was not able to park the vehicle without having to put something behind the wheel so that the motorhome won't move. Manufacturer was contacted, and stated that they were going to fix the problem.