2006 Yamaha XV19 transmission problems

Filed May 1, 2016 · Transmission · 40,000 miles · TX

I am getting a loud clacking and whine from the transmission in 3rd gear. This is the only gear that is doing it and it sounds like it is coming apart! I am afraid to ride it very far because it might brake and lock up my drive train when I am at speed on the interstate and it cause me to crash! This happens when I am going through the gears, 1st to 2nd then to 3rd and all hell breaks loose. If I go on to 4th gear it stops and the same with 5th gear. I have been told that if this gear breaks while I am riding, to be prepared for the transmission to completely lock up and it most likely will put me down and make me crash. This has been going on now for about a month and there is only 40k on this bike and no reason the transmission should be going out. I have been riding motorcycles for 50yrs and have never had a transmission problem!

Filed Aug 8, 2014 · Transmission · 320,000 miles · PA

While riding at low RPM's in 3rd gear a loud "clacking" is present. I contacted my yamaha dealer and was advised that there is a "replacement" 3rd gear listed for that model and year, however, yamaha is not acknowledging the known defect which could result in catastrophic loss of power.

Filed Jun 24, 2012 · Transmission · 20,000 miles · TX

I began to notice a whining from the transmission in third gear. Minor at first but has gotten progressively louder over the last month. Looked the problem up on several yamaha roadliner / stratoliner forums and found out that many others are having the same and worse problems including loosing third gear. I have read that some have tried to get yamaha to recall these but no recall to date as of yet. I will have to stop riding my bike as I don't want to loose third out on a trip. I have also red that yamaha has come up with a replacement gear that solves the problem but as of now big money is required to repair this design flaw.

Filed Apr 13, 2012 · Transmission · 19,200 miles · CA

I was downshifting and heard a really load noise from the transmission. The noise is prevalent in 3 rd gear only when downshifting. It is worse as it can be heard when accelerating now. Only 3rd gear is effected. I cannot use 3rd gear at all at this time. The noise can be heard when riding the bike or standing near when driving by.

Filed Mar 5, 2012 · Transmission · 28,000 miles · IN

Tl* the contact owns a 2006 yamaha xv19 motorcycle. The contact was driving 30 MPH when the vehicle exhibited a load noise while in third gear. The contact stated the vehicle did not stall or have a defect but he was concerned that there could have been an issue with the transmission. The contact did not take the vehicle to the dealer or a local mechanic for diagnostic testing. The failure mileage was 28,000.

Filed Nov 4, 2011 · Transmission · 60,000 miles · NC

Loud growling sound when running through town in third gear.

Filed Sep 2, 2011 · Transmission · 42,000 miles · CT

Third gear is howling caused by defective pinion parts within the transmission. Common problem on yamaha roadliners/stratoliners xv1900's as multiple people have reported the same issue. Yamaha should be forced to recall to correct manufacturing issues. I'm worried that the transmission will lock up at speed causing a catastrophic crash. Gear, 3rd pinion, p/n 99999-03864-00 (replaces 1d7-17131-01-00) .

Filed Jul 25, 2011 · Transmission · FL

My motorcycle (2006 yamaha xv19 stratoliner) is having a problem with 3rd gear making a loud noise. The yamaha dealership I took it to be repaired said that it is a known problem with my model and year bike. The parts that I know that were replaced were the middle shaft pinion gear and 3rd gear and seals.

Filed Apr 25, 2011 · Fuel system, Transmission · 21,220 miles · FL

My 2006 yamaha stratoliner xv1900 stalls when I pull the clutch coming to a stop. This has been happening since I first got my bike. It happens regardless of whether or not the bike is hot or cold. I called yamaha to complain as it stalled while coming to a stop and causing an extremely unsafe situation for me and my passenger. I was told that they were not aware of a problem, yet when I took the bike to the dealer, there was a tech bulletin describing the problem and speculating on possible resolutions. Many other owners have complained of this issue. Many speculate that it is a defective clutch switch and the method by which the clutch switch interacts with the ecu.

Filed Sep 19, 2010 · Transmission · 23,500 miles · VA

Third gear in my 2006 stratoliner "s" is completely useless. The gear has either severely worn itself or is chipped. When in gear (from 25-35mph) the transmission produces a severe whine and grinding sound. Yamaha and the dealership claim there is no "widespread" issue however I am in contact with five other 2006 stratoliner owners who have the exact same problem!