2017 Alfa Romeo Giulia fuel system problems

Filed Aug 19, 2026 · Fuel system · TX

I own a 2017 Alfa Romeo Giulia that recently received a fuel-pump-related recall repair under FCA Recall 93C / the federal safety agency Campaign 25V‑586 at an authorized Alfa Romeo dealership. Approximately three days after the recall repair was completed, I was driving the vehicle in active traffic with my daughter when the vehicle unexpectedly began decelerating and lost drive power. I had to shut the vehicle off, and afterward the vehicle would not restart. The vehicle had to be towed back to the Alfa Romeo dealership. The service advisor subsequently advised me that the current problem was related to the fuel system and that the fuel-related component was being replaced again. The vehicle remains at the dealership while the repair is being completed. This is also the second time this vehicle has completely shut down while I was driving. During a prior incident, the vehicle became disabled on a busy roadway and police responded and blocked traffic around the vehicle because of the danger posed by its location. I am concerned that the Recall 93C repair did not adequately remedy the fuel-system defect, that the replacement component failed, or that the recall repair was otherwise connected to the subsequent loss-of-drive-power event. I have repair records, towing documentation and video relating to the current repair and will retain the dealership's final diagnostic report when it becomes available.

Filed Aug 13, 2026 · Fuel system · CA

My 2017 Alfa Romeo Giulia lost motive power and was disabled multiple times the most recent on August 3, 2026 due to failure of the fuel delivery module — the same component and failure mode covered by Safety Recall 93C / the federal safety agency Campaign 25V‑586. When I contacted the dealership, they confirmed the recall applied to my vehicle but advised that replacement parts were not available. No loaner or alternate transportation was offered. I was without my vehicle for 8 days and had to rent a vehicle at my own expense. FCA US filed this recall on September 9, 2025 stating that the remedy was still under development. Owners were left without a repair path for an extended period on a defect the manufacturer's own chronology shows it had been evaluating since 2023, and which had produced 437 complaints, 5 crashes, and 3 injuries by the time the defect was determined. Stellantis has twice declined to reimburse my transportation costs, citing that the visit was "recall work only" and that my factory warranty expired in 2021. My vehicle was not brought in for preventive recall service — it failed on the road because of the recalled part. I am reporting this so the delay between recall announcement and parts availability, and its cost to owners, is on the record for this campaign.

Filed Aug 5, 2026 · Fuel system · CT

The contact owns a 2017 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

Filed Aug 3, 2026 · Fuel system · CA

The contact owns a 2017 Alfa Romeo Giulia . The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline). The dealer was contacted, and the contact was informed that parts to do the recall repair were unavailable. Additionally, the contact was informed that a limit of ten parts could be ordered at a time as per the manufacturer. The manufacturer was contacted. The contact had not experienced a failure.

Filed Jul 28, 2026 · Engine, Fuel system · FL

My car keeps going into limp mode seasonally, it also emits bad odors when given throttle, and it is definitely lacking power. Situation has also caused a misfire on my 3rd cylinder and a super rough idle and start

Filed Jul 23, 2026 · Fuel system · 64,000 miles · FL

The contact owns a 2017 Alfa Romeo Giulia. The contact stated that while driving at an undisclosed speed, the vehicle shut off suddenly. There was no warning light illuminated. The contact stated that on a separate occasion, the vehicle shut off while coming to a complete stop. The contact waited for 30 minutes before restarting the vehicle. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The vehicle was taken to a local dealer and was diagnosed with fuel pump failure. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 64,000.

Filed Jul 22, 2026 · Fuel system · WA

CRITICAL FINANCIAL NON-COMPLIANCE REPORT regarding the federal safety agency Campaign 25V586 / Alfa Romeo Recall 93C. On July 16, 2026, my vehicle suffered a catastrophic loss of motive power and stalled on the highway due to the exact fuel pump module defect described in Campaign 25V586 (Bristow's Auto Repair Invoice #33733 confirmed code P008A and low fuel pressure at 349mBar). Because the vehicle was entirely inoperable, I paid $2,207.27 out of pocket for an emergency repair. Alfa Romeo Customer Care has twice formally refused in writing to process my pre-recall reimbursement claim, explicitly stating they will not pay until a factory remedy is commercially available. This is a direct violation of the mandatory claim-processing guidelines under federal regulation 49 CFR § 573.13. Manufacturer is unlawfully withholding federally mandated consumer reimbursement.

Filed Jul 2, 2026 · Fuel system · OH

Hot weather, longish drive, car lost power and started throwing codes. I have a code reader (because this has happened before) and the code reader blamed the problem on fuel delivery system. You issued a recall on this last year (25V‑586) but there is not yet a remedy from the company. This car, and many like it may be dangerous to drive and may strand drivers -- as it would have done to me in the past had I need had the code reader and the means to re-set the computer once ambient temperature were lower. You may want to issue a reminder to them that this needs fixing and ASAP. Thanks.

Filed Jun 25, 2026 · Fuel system · 65,000 miles · FL

The contact owns a 2017 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that while driving at various speeds, the vehicle unintendedly went into LIMP Mode, and the vehicle lost automotive power. Several unknown warning lights were illuminated. In addition, the contact stated that while attempting to start the vehicle with the Push-to-Start feature, the engine hesitated while turning over. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was not yet determined. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 65,000.

Filed Jun 16, 2026 · Fuel system · NJ

My vehicle is affected by Recall 93C / (the federal safety agency 25V‑586 )for a fuel pump defect that can cause the engine to stall while driving. This safety issue has already occurred — my vehicle stalled while in motion, creating a dangerous situation. The car is currently unsafe to drive. Description of the Incident: I scheduled a recall appointment with the Englewood Cliffs Alfa Romeo dealer after reporting that the car had stalled. When I arrived, the dealer attempted to charge me a $450 diagnostic fee even though the visit was specifically for a federally regulated safety recall. I declined the fee and left because I did not feel comfortable being charged for recall‑related inspection. Manufacturer Response: I contacted Stellantis Customer Care. They stated that they “have no control over how the dealer operates” and that they would require diagnostic documentation from the dealer before providing rental assistance. This means I would still be required to pay the diagnostic fee, even though the issue is recall‑related. Reason for Filing: The dealer’s refusal to perform recall‑related inspection without charging a diagnostic fee prevents me from addressing a known safety defect. The manufacturer’s position leaves me unable to obtain recall service unless I pay out of pocket. I am concerned that this creates a barrier for consumers attempting to address a serious safety recall. Requested Action: I am requesting the federal safety agency’s review of this dealer’s handling of Recall 93C and Stellantis’ response requiring paid diagnostics before providing recall support. I would like the federal safety agency to ensure that consumers can obtain recall inspections and remedies without being charged diagnostic fees.