My fuel pump has been failing multiple times over the last 4 months. It has left me stranded in the middle of intersections, freeways, and highways on multiple occasions that has cause back up traffic and areas of the road completely closed until I can move my car. I have had this car diagnosed twice with a certified mechanic shop and a master tech with these issues and it is confirmed both times that I need a new fuel pump. When contacted Alfa Romeo/ Mike Ward dealership for review, diagnostic scans, and part replacement they told me it could be a couple of weeks until my car can even be looked at. Both my shop and the dealership have told me that this part is on back order with no ETA and no possible way of getting that part so my car can be functional. These issues first appeared when I would accelerate from a complete stop and it would take a few seconds for my car to begin moving. This slowly progressed into my check engine light, auto start/ stop error light, electric throttle error light, and front crash detection light have all turned on and remained on for about 2 months until the car began dying in the middle of the street. This had come to be so servers that the car is now no longer drivable and each time it is driven it dies within a few minutes of driving.Again since there is no ETA there is no way for me to fix my car, this is my only mode of transportation and it has left me ain multiple dangerous situations and now with no transportation now that Alfa Romeo is refusing to make the parts needed for repair.
2018 Alfa Romeo Giulia engine complaints
Page 2 of 2: complaints 11 to 22 of 22, newest first, as owners wrote them.
Service Engine" and "Service Electronic Throttle" lights came on. The car/engine started shaking/stuttering pretty violently, so I quickly turned off the car. I waited about 2 minutes and started the car again, and same thing. I waited another 10-15 minutes to start the car again. This time, the car started fine without "Service Electronic Throttle" light, but "Service Engine" light was still on and the drive mode was stuck on N
While driving on highway the Check Engine light illuminated along with a Service Electronic Throttle warning. Soon after engine died and the vehicle coasted to the side of the road. I was unable to restart. After tow to dealer vehicle would not start, awaiting dealer diagnosis. No safety issues were encountered with this incident.
When driving on a road, with speeds around 30mph, the car was failing to accelerate. The car had a warning "service electric throttle control". The car proceeded to have engine failure and stall at lower speeds when coming to a stop sign & when coming to a red light. This was a safety hazard, car turned off and was put in neutral when it should have stayed in drive. Other cars present on the road around, car could not accelerate in a busy intersection and was stalling in traffic.
The Electronic Throttle control and check engine lights came on suddenly, and then the car lost power. It would not turn off or turn on. The gear shifter did not work. It just stalled. Could not engage or disengage emergency brake. Steering wheel locked. I got it towed to Alfa Romeo of Glendale and they told me the fault was with a faulty fuel pressure sensor, which they replaced, telling me if the error recurred they would need to replace the fuel tank. The safety of everyone was put at risk because the car abruptly lost power and could not be moved off the road.
Fuel pump seems to go out intermittently. I get the electronic throttle control warning light and auto start not available warning light and then the car cannot be turned back on. After towing it home and letting it sit for a couple of days it will start again. It shut down once on a highway entrance ramp and I had to quickly pull over to avoid getting hit. Has occured 3 times since I bought it three years ago. A dealer did read the code for fuel pump. Could not reproduce at the service center. Car has not been inspected by manufacturer or police. Warning lights and messages do appear and the car does not accelerate properly and sometimes turns off.
Head Gasket blew/failed well before it should have. This caused oil to leak under the car and in the entire engine, creating a safety hazard and environmental hazards. Engine is subject to overheating. (Engine needs full replacement due to this faulty equipment).
While driving on the interstate, the car triggered a check engine light, reported that start/stop was unavailable, and ETC throttle needed servicing. Error codes report a turbocharger underboost. This is a known issue experienced by Alfa Romeo Giulia owners involving the turbo wastegate actuator. The actuator arm gets worn at the linkage to the wastegate, introducing play and reducing turbo pressure. There was no prior warning that this would happen, dealer did not confirm this issue until the second time the car was serviced for this issue, and the only stated solution is to pay for and replace the entire turbocharger.
My son was driving the vehicle on I75 at 68-70 MPH yesterday around 5:45 pM. The car started stalling.I was driving my other vehicle Volvo XC 90 right behind. I noticed his vehicle slowed downs drastically and within 4 seconds he was on left shoulder and stalled completely and would not stop. The vehicle went from 70-40-20-0 all in 4 seconds. Something very similar happened back in May of 2022. The Alfa Romeo dealer replaced the fuel pump in September/October of 2022. Stalling happened again yesterday. This is a very dangerous and known issue and Alfa Romeo manufacturer is not doing any recall or addressing this issue. Yesterday’s incident would have custard an accident which would have lead to injuries or even worse fatality When I called Alfa Romeo manufacturer’s customer service all they had to say was that the vehicle is not under warranty and they won’t cover the repairs. Please do a major recall on Alfa Romeo vehicles and make the manufacturers be responsible for the issue and make them to do a recall & repair. This is a very serious issue with Alfa Romeo cars. Stalls in the middle of the road.
When driving on the I-10 the ATV light came on the christmas tree lights cycled and the car rapidly came to a stop and shut off.
Vehicle presenting significant life-threatening system-wide failures while driving. These catastrophic system failures result in the vehicle becoming immediately undrivable without warning placing passengers at significant risk, particularly when traveling at high speeds (e.g., interstates). The following summarizes system-wide failures in the 2018 Giulia and failed attempts to correct this defect by Alfa Romeo and dealer: •11/30/20: One (1) day of service after complete multi-system failure while driving locally. Returned same day by service department but failed to repair (see following service report). •11/30/20 – 12/4/20: Five (5) days of service. Vehicle presented to dealer service department immediately after pick-up from aforementioned service to correct 2nd systemic failure which subsequently occurred promptly after departing the dealership. Resulting system failure produced highly dangerous operating conditions in which vehicle became immediately and unexpectedly incapacitated while attempting to merge into interstate traffic at accelerating speed. •1/25/21 – 2/5/21: Twelve (12) days of service following 3rd system failure. As per dealer service reps, an Alfa Romeo service agent stated there was a defect in in the molds used for creating engine / engine blocks in the Giulia and the resulting defects can cause an oil leak while in operation which, based on its location, can result in entire operating system collapsing unexpectedly when said leak occurs. As documented in the service record, metal shavings were found in the oil and oil pump of vehicle and per the guidance of the Alfa Romeo service agent, dealer replaced the entire engine •12/10/21: On 12/10/21, the 4th catastrophic system failure occurred during interstate travel in the rain while attempting to accelerate and pass a slow moving vehicle. Vehicle became unexpectedly incapacitated causing seriously life-threatening conditions. Vehicle available for inspection currently.
Service electronic throttle control and check engine warning lights came on. Car died in the middle of the road and took severally attempt to restart car.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Alfa Romeo Giulia?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history