2018 Alfa Romeo Giulia problems

Filed Oct 13, 2026 · Electrical · NJ

On October 13, 2026, while driving my 2018 Alfa Romeo Giulia Ti home from work at night in dry weather, the vehicle’s lights began flickering and then the headlights went out while the vehicle was moving. I suddenly could not see the road and nearly had an accident. The problem is intermittent, and the lights later resumed operating, but the vehicle is unsafe to drive at night. This vehicle has a history of electrical problems involving flickering lights and loss of power. Alfa Romeo and FIAT of Maple Shade previously replaced the Body Control Module (BCM) for the same original problem, but the problem continued. The dealership later kept the vehicle for more than one month. Repair Order 032539 states that the vehicle had been towed in with “no power” and “electrical issues” and that multiple communication codes between modules were found for low voltage. The dealership replaced an aftermarket battery with an OEM Alfa Romeo battery and performed a proxy alignment, but the electrical and lighting problem has returned. The dealership also advised me that water had been entering around the windshield and affecting the vehicle’s electrical system. The windshield was subsequently replaced, but the lights continue to flicker and have now gone out while driving in dry conditions. I am concerned that moisture exposure, wiring, connectors, the replacement BCM, the charging system or another unresolved electrical defect may cause the headlights or other electrical systems to fail again while the vehicle is moving. No collision or injury occurred, but the sudden loss of headlights created an immediate risk of a crash. I am reporting this defect because the same safety-related electrical problem has continued despite replacement of the BCM, battery and windshield.

Filed Oct 8, 2026 · Fuel system · 137,000 miles · CA

The contact owns a 2018 Alfa Romero Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000(FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The local dealer was contacted, and it was confirmed that the part was not available for the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that while driving, the vehicle lost power and stalled. The vehicle was later towed to the residence. The failure mileage was 137,000.

Filed Oct 5, 2026 · Fuel system · CA

Vehicle: 2018 Alfa Romeo Giulia, VIN [XXX] Recall: the federal safety agency 25V‑586 (FCA/Stellantis Recall 93C): Fuel Delivery Module / fuel pump I received FCA's safety recall notice for recall 93C. It states the fuel pump can fail and cause a loss of drive power, which can cause a crash without warning. The notice tells me to schedule the free repair with an authorized Alfa Romeo dealer, but the remedy is not available to me in practice. I contacted every authorized dealer in my area, all 1.5 to 2+ hours from my home: •Livermore Alfa Romeo, Livermore, CA: 21 customers ahead of me, no date given. •Alfa Romeo of San Jose, San Jose, CA: 12 customers ahead, about a 4-month wait. •Alfa Romeo of Marin, San Rafael, CA: no parts available. I contacted Alfa Romeo Premium Care (case number [XXX]), and they referred me back to the dealers. FCA has offered no interim fix, no loaner or rental, and no firm repair date. I have to keep driving a vehicle with an acknowledged loss-of-power defect for up to 4 months. I am asking the federal safety agency to review whether FCA is supplying enough remedy parts and dealer capacity for recall 25V‑586, and whether owners facing long delays should be given alternate transportation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 2, 2026 · TX

My Alfa Romeo with VIN [XXX] has an active recall 93C (the federal safety agency Recall 25V586) related to the Fuel Delivery Module. The recall specifically states that this issue can lead to a sudden loss of drive power while driving and possibly result in a crash. Due to the closure of the dealership in San Antonio where I live and purchased the car, the nearest Alfa Romeo authorized service center is in Austin, Texas. This is a distance of 125 miles from my home and involves primarily driving on highways with 70 mph speed limits. Because this is a critical safety recall, I have already scheduled an appointment with this dealer for the repair; however, when I contacted Alfa Romeo to inquire about arranging a tow from my home to the authorized repair center.,they would only cover the cost of towing the vehicle up to 15 miles. They quoted that I would need to pay an out of pocket cost of more than $1000 to have the vehicle towed for the recall repair. Forcing me to pay over $1000 or drive my vehicle 120 miles at highway speeds while there is an open stall/loss-of-power recall creates an unreasonable safety risk and illegal financial barrier. The vehicle currently has 128,000 miles on it which significantly increases the risk of the FDM issue occurring. Under 49 U.S.C. § 30120(a), manufacturers are required to remedy safety defects without charge. By closing local dealerships and requiring an out-of-pocket payment of $1,000 for towing overage to reach the nearest operational Alfa Romeo dealer, the manufacturer is violating the 'without charge' requirement and failing to provide a reasonable safety remedy. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 24, 2026 · Engine, Fuel system · 100,100 miles · FL

The contact owns a 2018 Alfa Romeo Giulia. The contact received notification of the federal safety agency Campaign Number: 25V586000 (Fuel System, Gasoline). The contact stated that while driving at various speeds on approximately five occasions, the vehicle went into LIMP Mode, lost motive power, and stalled on some occasions. The check engine warning light and the Electronic Throttle Control (ETC) warning light were illuminated twice. The contact stated that while attempting to accelerate, the vehicle failed to accelerate above 30 MPH. The vehicle was taken to an independent mechanic, where it was diagnosed and determined to have a Co pump module failure because the pressure was too high and the Co pump module needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,100.

Filed Jun 26, 2026 · Fuel system · 15,000 miles · AL

The contact owns a 2018 Alfa Romeo Giulia. The contact stated that after driving the vehicle and parking the vehicle, upon returning to the vehicle a short time later, the vehicle hesitated while restarting. On another occasion, the vehicle was started and stalled while driving. Approximately 10 minutes later, the vehicle was able to be restarted. A diagnostic scan of the vehicle indicated a failure with the fuel delivery system. The vehicle was taken to a dealer, where a temporary workaround was performed; however, the vehicle became inoperable shortly after being started and driven. No further repairs were completed. The manufacturer was notified of the failure. The contact associated the failure with the federal safety agency Campaign Number 25V586000 (Fuel System, Gasoline). The approximate failure mileage was 15,000.

Filed Jun 15, 2026 · Fuel system · GA

Vehicle is affected by FCA recall 93C / the federal safety agency recall 25V‑586 for Fuel Delivery Module / fuel pump failure that can cause fuel starvation and unexpected loss of motive power. the federal safety agency recall lookup shows the recall is incomplete and the remedy is not yet available. The vehicle is already symptomatic. It has active DTC P008A / low-pressure fuel system pressure too low, check engine light, and Start/Stop unavailable. It also has drivability symptoms: inconsistent acceleration, hesitation/poor response, and sometimes failing to restart after stopping in traffic, such as at traffic lights. This creates a risk of the vehicle being disabled in traffic or losing motive power without adequate warning. The dealer stated final recall parts are not available. Dealer offered only a no-charge interim fuel pump control module replacement, but quoted approximately $1,117 to replace the low-pressure fuel pump assembly / Fuel Delivery Module and O-ring. FCA/dealer has not provided written authorization for no-charge interim FDM replacement, has not guaranteed reimbursement if the owner pays now, has not provided alternate transportation, and has not provided a written safety determination that the vehicle is safe to operate while symptomatic. This issue appears long-known. FCA issued a P008A low-pressure fuel system service bulletin in 2018, the federal safety agency opened investigation PE24003 in January 2024, and recall 25V‑586 was not filed until September 2025. Despite that history, a symptomatic vehicle remains without an available final remedy.

Filed Jun 14, 2026 · Fuel system · MA

Active recall: the federal safety agency Recall Number 25V‑586. My car has now failed twice in traffic and is not safe to drive.

Filed May 26, 2026 · Fuel system · PA

the federal safety agency RECALL #25V‑586 Around September of 2025, I notified Alfa Romeo Customer service that my vehicle was experiencing symptoms of this recall. Symptoms include but are not limited to severe fuel pump whine that fluctuates with RPM, as well as intermittent LOMP. The whine is audible 100% of the time. The LOMP occurs intermittently, primarily shortly after starting the vehicle. On multiple occasions, I have to pull my vehicle to the side of the road because it is unable to effectively move under it's own power. Along with this LOMP, symptoms experienced are a heavy misfire along with a few service messages such as "Auto start unavailable, service electronic throttle, and service engine" along with a flashing check engine light. The fix appears to be power cycling the battery so that the fuel pump primes multiple times. I have called Alfa Romeo multiple times about this issue over the last few months, but all they tell me is that they cannot do anything until a remedy is available. Unfortunately, given the wait, symptoms have progressively gotten worse.

Filed Apr 28, 2026 · Acceleration, Brakes · 26,000 miles · IL · crash

The contact owns a 2018 Alfa Romeo Giulia. The contact stated that while at a complete stop on several occasions, the engine abnormally revved to 1,100-1,400 RPMs. The contact stated that while driving at an undisclosed low speed on a ramp, the vehicle accelerated unintendedly and failed to decelerate while the brake pedal was depressed. Additionally, the contact stated that while at a complete stop at the red light, the engine revved, and the vehicle accelerated unintendedly while the brake pedal was depressed and struck another stopped vehicle. The air bags did not deploy. No police report was filed. The contact's vehicle sustained minor damage, while the other vehicle did not sustain damage. There was no warning light illuminated. There were no reported injuries. Both vehicles were drivable after the incident. The vehicle was taken to the dealer, where it was test-driven, but the failure could not be duplicated. A third-party contractor, sent by the manufacturer, performed an evaluation of the vehicle and sent the raw data report to the contact. The contact noticed that the crash incident date listed on the report was March 4, 2026, while the incident occurred on April 4, 2026. The contact informed the third-party contractor of the error, and the contact was concerned that the contractor had pulled the wrong data because the incident date listed was incorrect. The manufacturer later sent a summary of the evaluation report to the contact, stating that the reported incident was not due to the manufacturer's responsibility. The vehicle was not repaired. The failure mileage was approximately 26,000.