Fuel pump failed and defective....replaced...smell of raw gas still exists. Egr valve defective....this should not be failing like this...this truck has been well maintained.
The worst 1996 Am General Hummer problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Fuel system2
- Steering1
- Transmission1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system2
- Steering1
- Transmission1
Recalls 2
Seats
- What is wrong
- Vehicle description: buses equipped with isringhausen seats in the driver position. Two welds located on the back rest adjustment side of the seat frame did not meet the manufacturer's specifications.
- Risk
- If these welds were not to specification, back rest loads could cause the welds to fail. The back rest would disengage from the seat frame allowing loss of support to the driver's torso and possibly causing loss of control of the vehicle.
- Remedy
- Isringhausen is conducting the owner notification and remedy campaign for this recall. Dealers will inspect these seats and replace the seat frame assembly.
Recall number 96V178002 · Recall details
Vehicle speed control: accelerator pedal
- What is wrong
- The coating used to protect the accelerator pedal shaft is incompatible with the bronze bushing through which the shaft passes. Over time, and in the presence of a corrosive environment (water, road salt), the shaft can corrode inside the bushing increasing the amount of friction between the rotating shaft and the stationary bushing.
- Risk
- A corroded accelerator pedal shaft can cause the engine throttle to bind and not fully return to idle when the operator's foot is removed from the accelerator pedal increasing the potential for a vehicle accident.
- Remedy
- Dealers will install a revised accelerator pedal and shaft assembly.
Recall number 96V049000 · Recall details
Technical service bulletins for the 1996 Am General Hummer 15
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Winch control pack
- Subject regarding revised front door armrest
- This bulletin mentions that starting with the september general motors tis update, hummer diagnostic...
- Some VIN z vehicles with VIN 185138 and below and with transfer cases built before may 7, 1999 may exhibit...
- Information concerning injection timing stepper motor
- Information regarding the new service part fuel injection pump assembly contains internal changes from...
- Some 1996 - 1999 VIN z vehicles may exhibit a no start, stall or a diagnostic trouble code P1216 (replace...
- Subject on main HVAC unit servicing
- Exhibiting resonant frequencies causing the transfer case shift lever to vibrate or rattle
- Comments of loss of 4TH gear, slipping in 4TH gear, busy 3-4 shifting or torque converter clutch (TCC) cycling
What 1996 Am General Hummer owners say
Most recent owner complaints, unedited.
Extreme hummer has experienced 10 wheel hub separations in last 10 yrs as well as failure steering box bolts.
Aux fuel tank leaks diesel when full / parked on angle. Fire hazard - bio hazard
Compare the 1996 Am General Hummer
Other model years
Questions about the 1996 Am General Hummer
Is the 1996 Am General Hummer reliable?
Owners have filed 3 complaints about the 1996 Am General Hummer, fewer than a typical Hummer model year.
What is the most common problem with the 1996 Am General Hummer?
Fuel and propulsion system, with 2 complaints. Next is steering (1).
How many recalls does the 1996 Am General Hummer have?
2 recalls, covering seats and vehicle speed control.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Am General Hummer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history