An in-tank fuel line between the fuel pump and filter is missing hose clamps causing fuel pressure lose and erratic engine performance. Stalling and sputtering during maneuvers in traffic can be being very dangerous on a motorcycle or any two wheel vehicle. This problem effects 2007 through 2008 aprilia scarabeo 500ie and earlier year models. Thus far dealers have corrected this under warranty on a by complaint bases. Most of these failures have occurred in the first 1000 miles. An obvious design flaw. I feel the manufacture should have a recall on this problem.
The worst 2006 Aprilia Scarabeo 500 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system7
- Lights3
Specific symptoms reported on the 2006 Aprilia Scarabeo 500
Recalls 1
Fuel system, gasoline: delivery
- What is wrong
- Piaggio is recalling 850 my 2006-2008 aprilia scarabeo 500 motorcycles equipped with bitron spa fuel pump/fuel filters. The fuel hose connecting the fuel filter to the fuel pump/fuel filter mounting flange may come loose. If this connection is loose, or has become completely disconnected, there will be a drop, or loss of, fuel pressure to the engine.
- Risk
- A drop or loss of fuel pressure to the engine could cause the engine to stall increasing the risk of a crash.
- Remedy
- Dealers will install hose clamps to secure the existing fuel hose at both ends to the fuel pump and fuel filter. The recall is expected to begin during march 2009. Owners may contact piaggio/aprilia at 1‑212‑380‑4431.
Recall number 08V522000 · Recall details
See all 1 recalls for the 2006 Aprilia Scarabeo 500
Defect investigations
Motor scooter stalling - fuel
We opened this pe after becoming aware of allegations that my 2006-2008 aprilia scarabeo 500model motorscooters were stalling when the downstream hose from the fuel pump deteriorates and/or separates from the pump.this issue was also the subject of numerous web forum posts.our discussions with dealers indicated other subject vehicle owners had also experienced this problem.subsequently, piaggio decided to recall the subject vehicles to address the problem (08v‑522).with that recall, this pe is closed.
PE08050
Technical service bulletins for the 2006 Aprilia Scarabeo 500 1
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 2006 Aprilia Scarabeo 500 owners say
Most recent owner complaints, unedited.
2006 aprilia scarabeo scooter, 88 miles on odometer. Loss of fuel pressure at idle. Stall at idle. Rough starting. Dealer replaced faulty submersible fuel line, attached clamps to each end where there were none before. Immediately fixed the issue. Aprilia covered this under warranty. This could present a dangerous situation for other owners.
An in-tank fuel line between the fuel pump and filter is missing hose clamps and improper fuel line for USA fuels causing fuel pressure lose and erratic engine performance. Stalling and sputtering during maneuvers in traffic can be being very dangerous on a motorcycle or any two wheel vehicle. This problem effects 2003 to 2006 aprilia scarabeo 500gt and 500gt ABS models, also 2007 and 2008 aprilia scarabeo 500ie model .
This report pertains to a 2006 aprilia scarabeo 500 motorcycle. I bought the motorcycle new in june 2008. It is common knowledge among scarabeo owners that the manufacturer sold these bikes with clamps missing from the in-tank fuel line, between the in-tank filter and the fuel pump. My dealer assured me that this issue had been resolved on my bike before I took delivery of it. Within days of taking delivery of the bike, the engine was idling roughly, stalling at stop lights and running roughly when operated at slow speeds, below 35 MPH. On several occasions, I applied power to start off from an intersection and the bike stalled. These were all symptoms of the fuel line clamp issue, as reported by many scarabeo 500 owners. I fixed the problem myself because I do not live near an aprilia dealer. Upon removing the in-tank fuel pump, I immediately noticed that there were no clamps on either end of the fuel line. I installed the clamps, as well as replaced the fuel line with line approved for submerging in fuel (sae30r10), as it was unclear as to the suitability of the stock fuel line for submerged use. Since the fix I have not had any recurrence of the problems. This is a safety issue and the manufacturer should recall all scarabeos and have them checked.
"an in-tank fuel line between the fuel pump and filter is missing hose clamps causing fuel pressure lose and erratic engine performance. Stalling and sputtering during maneuvers in traffic can be being very dangerous on a motorcycle or any two wheel vehicle. This problem effects 2007 through 2008 aprilia scarabeo 500ie and earlier year models. Thus far dealers have corrected this under warranty on a by complaint bases. Most of these failures have occurred in the first 1000 miles. An obvious design flaw. I feel the manufacture should have a recall on this problem".
Vehicle had an irregular, low idle, stuttering, lack of power and was very difficult to start. Sometimes the vehicle's engine would die at intersections while idling. The engine stopping at intersections is dangerous and could cause an accident or death. Upon investigation, I realized that the electric fuel pump hose inside the fuel tank was leaking therefore not supplying the appropriate pressure to the injector. I purchased a new submersible fuel line and two hose clamps and replaced the leaking oem fuel hose.
Tl*the contact owns a 2006 aprilia scarabeo 500 ABS scooter. The contact stated that the engine stalled at low speeds, while idling, in stop-and-go traffic, and when making a left turn. He also stated that the high beams were dimmer than the low beams. The purchase date and number of cylinders were unknown. The current mileage was approximately 2,500 and failure mileage was approximately 1,500. Updated 02-14-08 *bf the consumer stated the dealer replaced fuel line and clamps which corrected engine stalling problem. Updated 02/14/08
Tl*the contact owns a 2006 aprilia scarabeo 500 (na). The contact stated that the high beam lights were very dim like a flashlight. Two days after purchasing the vehicle, he returned to the dealer to find out why the high beams were so dim and dense. After examining the high beams, the dealer stated that there was no way to adjust them and make them brighter. The current mileage is 7,012 and failure mileage was less than 100. Updated 01/11/08. *lj updated
Tl*the contact owns a 2006 aprilia scarabeo 500. The highbeams were activated; however, they were dimmer than the regular headlights. The dealer stated that the wires were messed up when the ABS feature was added. There was no remedy for the failure. The failure mileage was 100 and current mileage was 2,850. Updated 01/11/08.
Compare the 2006 Aprilia Scarabeo 500
Other model years
Questions about the 2006 Aprilia Scarabeo 500
Is the 2006 Aprilia Scarabeo 500 reliable?
Owners have filed 9 complaints about the 2006 Aprilia Scarabeo 500, close to a typical Scarabeo 500 model year.
What is the most common problem with the 2006 Aprilia Scarabeo 500?
Fuel and propulsion system, with 7 complaints, typically around 1,150 miles. Next is lights (3).
How many recalls does the 2006 Aprilia Scarabeo 500 have?
1 recall, covering fuel system, gasoline.
Was there a recall on the 2006 Aprilia Scarabeo 500 fuel system?
Yes, 1 recall: 08V522000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Aprilia Scarabeo 500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history