I am filing a complaint about the handling of a recall repair on my 2015 Audi A3 (VIN: [XXX] ) for the suction jet pump. The service experience has been frustrating and raises concerns about the repair’s quality. 1.First Visit - Inadequate Information: During my first visit to the service center, over an hour away, I was turned away because my fuel level was too high. I was never informed that my gas tank needed to be below a certain level for the repair, resulting in wasted time and travel. 2.Second Visit - Check Engine Light Still On: On my second visit, the suction jet pump was supposedly repaired, but my check engine light remained on. I had informed the service advisor that the light was related to an EVAP system malfunction, which I was told could be caused by a faulty suction jet pump. After speaking with multiple mechanics, I learned that a malfunctioning suction jet pump could cause fuel to enter the EVAP system, damaging parts like the purge valve or charcoal canister. 3.Unreasonable Charges: The service advisor insisted that the remaining EVAP issues were unrelated to the recall and wanted to charge $220 for another diagnostic and repairs, without even inspecting the car after the recall service. This seems unfair, as there’s no way to confirm without a proper check. 4.Missing Seat Belt Buckle: After the recall service, I discovered that the rear driver’s side seat belt buckle was missing. This is a major safety concern and needs to be addressed. I request the federal safety agency’s help in investigating the repair quality and ensuring these issues are resolved fairly. Thank you for your attention. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2015 Audi A3 fuel system complaints
Page 2 of 2: complaints 11 to 22 of 22, newest first, as owners wrote them.
The contact owns a 2015 Audi A3. The contact stated that while driving at an undisclosed speed, there was an abnormal fuel odor inside the vehicle. In addition, the contact stated that while refueling the vehicle, all the fuel was not entering the fuel tank, with some fuel dripping out onto the ground. The vehicle was taken to the dealer and the recall repair for the federal safety agency Campaign Number: 24V110000 (Fuel system, Gasoline) was completed. The contact was informed that the recall repair did not fix the vehicle. The failure reoccurred. The contact was informed that the filter canister or the fuel tank might need to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 83,500.
The contact owns a 2015 Audi A3. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted, and it was confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2015 Audi A3. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while refueling, the fuel tank overflowed. There was no warning light illuminated. The contact inspected the vehicle and became aware that there was fuel leaking underneath the vehicle. The contact called the Local Fire Department, and the vehicle was inspected. The contact stated that a Fire report was not filed. The vehicle was towed to the dealer but was not diagnosed nor repaired. The manufacturer was not made of the failure. The failure mileage was approximately 78,891. VIN tool confirms parts not available.
The contact owns a 2015 Audi A3. The contact stated that while her husband was attempting to park the vehicle in the driveway, he noticed a strong fuel odor. The contact’s husband inspected the vehicle and noticed a fuel leak from the fuel tank pump. The contact husband refilled the fuel tank, however, the failure persisted. The vehicle was taken to a local dealer where it was diagnosed that the charcoal canister and a filter needed to be replaced. The contact stated that the dealer confirmed an unknown recall was not related to the failure. The vehicle was not repaired. The manufacturer was made aware of the failure; however, the contact was referred to the federal safety agency Hotline for assistance. The approximate failure mileage was 150,000.
The contact owns a 2015 Audi A3. The contact received notification of the federal safety agency Campaign Number: 24V110000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated while driving 35-38 MPH, the vehicle shuddered, and there was a strong gasoline odor coming from the A/C vents. There was no warning light illuminated. The contact pulled to the side of the road, turned off and exited the vehicle. The contact's father arrived at the scene and inspected the vehicle. The contact then drove to the residence. Additionally, the contact stated that while attempting to refuel the vehicle at the gas station, the gas pump stopped pumping gas in the vehicle even though the gas tank was not full. The contact stated that the vehicle had been leaking fuel while parked in the driveway. The contact's father pushed the vehicle to the side of the road. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 83,000. VIN tool confirms parts not available.
This is in regards to your investigation into a recall for Audi 2015 A3 fuel system issues. My car was repaired as part of that initial recall, however, i am experiencing a bunch of fuel related issues as of now. My fuel tank will no longer fill with gas. The dealership said i need a need fuel tank. Then at the exact same time, my low side fuel pump failed. I mentioned to the dealership about the recall and the fuel problems, they told me they were not related. I paid to replace the lower said fuel pump. Now a few months later my high side fuel pump has failed. I then found the article about the investigation about fuel issues, they told me again it was not related. So now they are asking me to replace the high side fuel pump. I told them it was not a coincidence that both fuel pumps and my gas tank all fail at the same time along with the investigation. They again told me its not related. I opened up a case with Audi of America and they are investigating. Having issues with the fuel delivery system will cause the car to sudden stop and stall at high rates of speed, and has caused me to break down in the middle of the road with no warning.
Fuel pump issue. Car will stall when driving.
Vehicle is not taking fuel, there is early stopping of the fuel nozzle and there is significant fuel spillback. Fuel would go in for 2 seconds and the fuel nozzle shuts off. I was trying to refill and then there was spillback of fuel that propelled all over my body and all over the floor of the gas station. I had taken my vehicle to a licensed repair shop who thought it might be a carbon canister which I got replaced. I tried to refuel after the maintenance and the problem persisted. My vehicle once again could not refuel, after sitting at a gas station for 10 minutes I was calling my Husband, all of the sudden what little fuel was left in the tank shot back out and spilled all over the gas station floor and side of my car. I took my car to the licensed repair facility who then called my warranty company and they had adjuster come out as the repair facility tried to refuel my car, and it would not refuel and adjuster took videos of the fuel spilling back out. The warranty would not cover my vehicle because they say it is EVAP and they found a safety recall that matches the symptoms the federal safety agency: 16V647 for 2015 Audi A3 Sedans. Mine is a 2015 Audi A3 Sedan but for some reason this is not covered according to my VIN #
I experienced issues putting fuel in my vehicle. The pump would shut off as if the tank were full after putting only a few dollars in the tank. At one point gas backed up and spalshed onto my hand and cloths, down the side of my vehicle onto the ground. Prior to this I noticed my vehicle hesitating when accelerating at times. I took it to the Audi dealership explaining something was preventing fuel from going into the gas tank. The Audi dealership’s initial diagnosis recommendation was to replace charcoal cannister as it had gas in it. Once replaced, the technician still had issues fueling the vehicle. After a second diagnostic test they determined the Evap Cannister as well as the actual fuel tank needed to be replaced. I did take my vehicle to another establishment for a second opinion as I felt the Audi dealership did not appear to know what the exact problem was. Prior to and during the issue with my vehicle, there were no warning lamps on messages indicating any problems. There was only the slight hesitation when accelerating periodically. This occurred approximately 1 week prior to the fueling issues.
When pumping gas, it only allows for less than 5 consecutive seconds until the nozzle clicks off. It is soon followed by gas spilling out of the filler neck. Also accompanied by a rough running vehicle plus misfires. The vapor canister, along with the leak detection pump have already been replaced. Therefore the only issue that warrants these outcomes is suction pump failure. This is in recall 20Y5. Thought it does not state my car needs it. Ive been stopped by multiple drivers on the roadway for gas spilling from the fuel door. The climate in which this car operates exceeds 100⁰ especially in the summer time. One small spark could endager or cost me, my peers, and any surrounding people their lives.
Check engine light came on in october 2020 car was slow to take off for several weeks and seemed to take time to shift gears. Took to audi mechanic and had to replace water pump -w/thermostat housing & intake manifold. Now I'm april 2021 car is back in shop because it wouldn't shift out of 1st gear suddenly when I was driving with my daughter in the car, I pulled over in a parking lot to turn car off and then got an error message stating transmission malfunction cannot reverse and had to have the car towed to mechanic again. I'm told it needs mechatronic unit replaced, replace timing cover due to oil leak, evap leak and wiper fluid is leaking.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Audi A3?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history