2018 Audi Q7: sudden loss of power

Filed Nov 18, 2025 · Engine · PA

I am reporting a progressive oil consumption defect that led to a catastrophic engine failure in my 2018 Audi Q7. The vehicle was purchased Certified Pre-Owned (CPO). I reported the excessive oil use to an Audi dealer. The dealer attempted to address the issue by performing an engine cleaning/flush, but the engine failed shortly afterwards. Over time, the vehicle required frequent top-offs between service intervals. Eventually, the engine suffered a mechanical failure, resulting in a broken exhaust valve and internal engine damage while driving on the highway. The Audi dealer provided a repair estimate of approximately $12,000. Audi of America offered 40% assistance to make the repair, but does not recognize the underlying excessive oil consumption issue. Furthermore, the proposed repair only replaces the damaged valve and related components, but does not address the underlying excessive oil consumption that caused the failure. This means the vehicle may still: •unexpectedly run low on oil, •lose power while driving, •suffer additional internal damage, or •again experience sudden engine failure while driving. These conditions can cause dangerous drivability issues, including loss of acceleration and potential stalling at highway speeds. This appears to be a serious safety-related defect involving lubrication failure, component breakage, and potential loss of power. I am requesting that the federal safety agency review this issue to determine whether similar failures are occurring in other Audi Q7 vehicles with the 3.0T engine.

Filed May 10, 2025 · Electrical, Engine · NC

To Whom It May Concern, I am writing to formally report a serious and recurring safety issue involving my 2018 Audi Q7. The vehicle has experienced repeated drive system malfunctions that result in sudden loss of power, reduced acceleration, and warning messages on the dashboard such as “Drive System: Malfunction” and “Electrical System Failure.” These incidents have occurred while the vehicle was in motion, creating a hazardous situation for both the occupants and surrounding drivers. In my case, the vehicle unexpectedly lost power while driving at highway speeds, forcing me to maneuver to the shoulder with diminished control. This sudden malfunction is unpredictable and could easily result in a collision or serious injury, especially in high-speed or high-traffic conditions. Upon researching this issue, I found that numerous other 2018 Audi Q7 owners have reported similar problems. These complaints consistently cite the same symptoms, including sudden deceleration, electrical system errors, and power steering failure. It appears to be a widespread defect that may warrant a recall or further investigation by the federal safety agency. I urge your office to investigate this matter promptly to prevent potential injuries or fatalities. I am willing to provide service records, diagnostic codes, photos, or any other documentation that may support this complaint. Thank you for your attention to this serious safety concern. I hope the federal safety agency will take appropriate action to ensure the safety of all drivers affected by this defect.

Filed May 3, 2025 · Engine · GA

The engine burns oil. At about 60k miles started to burn about a liter every 10k miles. Once the engine got to about 80K engines it started burning a leter about every 1K miles. The high amount of oil consumption fouled the spark plugs, coils, injectors and sensors. This resulted in a drive system malfunction, caused loss of power in the engine that ultimately ruined the engine with less than 100K miles.

Filed Mar 10, 2025 · Engine · OH

First time on highway since getting it back from the car repair vendor two days prior. Drive system malfunction occurred on the highway drive approx.13 miles from my house. Car lost power and would stall and would barely idle. Stopped in the middle of highway traffic 3 times. Got the car towed to vendor that had serviced my car 2 days prior which involved changing rear brake pads and rotors, 6 supercharged spark plugs and air filter. Estimate of issue was damaged exhaust valves on cylinder 2 & 4. Recommended service was remove the cylinder heads, replace all exhaust valves, clean pistons and combustion chambers $8,032.99.

Filed Jul 2, 2024 · Engine · OR

I have received two "cylinder misfire" notifications. The first occured in December 2023 on a remote stretch of freeway. The second occured in June 2024 on a remote stretch of highway. In both cases, I immediately lost power and put myself and cars around me at risk because I had to pull over onto the side of the road to re-start the car. After the second incident, I now have no confidence in taking my car, only 6 years old and with 74K miles on it, out of the city and into the countryside. The symptoms of this issue include frequent oil burn / oil top-offs. My car requires a quart of oil every 200-300 miles. There are no leaks in my driveway. The leaking all seems to be coming from the cylinders. I am taking my Q7 into a mechanic, again, next week and I am concerns the solution will be "new engine" which costs more than the car is worth.

Filed Jan 26, 2024 · Engine · MA

We have had major problems with our 2018 Audi Q7 that are consistent with allegations made in various lawsuits against Audi and Volkswagen Group of America for alleged defects with Audi piston rings and piston ring assemblies. The defects have purportedly caused excessive oil consumption, engine damage, and engine failure. As noted in one such lawsuit (that apparently settled), the engine failure caused by the defective Audi piston ring and piston assemblies could result in sudden loss of power to the engine. “It goes without saying that a sudden loss of power poses a clear-cut safety risk—it can prevent the driver from accelerating, maintaining speed, and even adequately controlling the steering wheel, engaging the brakes, all of which drastically increase the risk of collisions …” [XXX] v. Volkswagen Group of America, Inc. {XXX]) The problem with our Audi is consistent with the reports by plaintiffs in these lawsuits, as well as other Audi owners—including Q7s—who have shared their experiences online. Starting at around 60,000 miles, our vehicle increasingly consumed oil until eventually, we needed to add a quart of oil less than every 600 miles. And that’s despite our: 1) having followed all of the required oil change and other related maintenance standards published by Audi; and 2) having replaced the car’s CCV valve and PCV breather, which we were told sometimes corrects the problem. Most recently, in December 2023, I was driving with my children in the vehicle, and the engine started sputtering and laboring. Then the check engine light appeared. I was able to drive the car home but have been advised that, in order to make the car drivable, we’d have to replace the engine. Obviously, even if we have the engine replaced, the rebuilt Audi engine could have the same problems. Given the risk that the affected Audi engines will fail in vehicles traveling at high speeds on U.S. highways, the federal safety agency should investigate this matter immediately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (