2003 Blue Bird TC2000 Problems: 8 Complaints, 6 Recalls

The worst 2003 Blue Bird TC2000 problems

Ranked by number of owner complaints. Mileage and cost come from what owners wrote.

Brakes
7
Fuel system
1

Problems by type

Tap a problem to see which part fails, at what mileage and in which other years.

Brakes
7
Fuel system
1

Recalls 6

Electrical system: 12v/24v/48v batteryReported August 31, 2005 · 5,863 vehicles affected

What is wrong: Certain 2001 through 2006 my blue bird all american, tc2000, and vision transit school buses manufactured between january 5, 2001, and july 15, 2005. These buses are equipped with a battery disconnect switch that has connections that may be loose on the battery switch studs creating the potential for the bus to shut down while in operation.
Risk: Should the bus shut down while in operation, a vehicle crash could occur.
Remedy: Blue bird will notify its owners and instruct them on how to repair the switch. The recall began on october 19 , 2005. Owners may contact blue bird at 478‑822‑2242.

Recall number 05V382000 · Recall details

Other: school bus stop arm assemblyReported May 20, 2005 · 8,894 vehicles affected

What is wrong: Certain school buses originally sold in or currently registered in the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. In extremely cold weather, the microswitches used internally to position the stop arm sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
Risk: Should the stop arm not perform properly, a child or pedestrian may be endangered by passing vehicles should the motorist not stop at the correct location.
Remedy: Blue bird will notify its customers and replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected free of charge. The recall began on august 12, 2005. Owners may contact blue bird at 478‑822‑2242.

Recall number 05V239000 · Recall details

Other: school bus stop arm assemblyReported May 20, 2005 · 3,121 vehicles affected

What is wrong: Certain blue bird 2002 through 2006 my all american, conventional, minibird, microbird, vision, and tc2000 school buses originally sold in or currently registered in states other than the following states: alaska, colorado, connecticut, delaware, idaho, illinois, indiana, iowa, kansas, kentucky, maine, maryland, massachusetts, michigan, minnesota, missouri, montana, nebraska, nevada, new hampshire, new jersey, new mexico, new york, north dakota, ohio, oregon, pennsylvania, rhode island, south dakota, tennessee, utah, vermont, virginia, washington, west virginia, wisconsin, wyoming, and the district of columbia. In extremely cold weather, the microswitches used internally to position the sign in the open and closed positions may malfunction, causing the sign to open or close in an improper position, or to not open at all.
Risk: Should the stop arm not perform properly, a child or pedestrian may be endangered by passing motorists should the motorist not stop at the correct location.
Remedy: Blue bird will notify all its customers of this campaign. For those buses operated in or near any of the states listed above, blue bird is encouraging the bus owners to obtain the replacement switch. For those buses operated in the warmer states, blue bird will replace the switch upon owner request. For those customers who request the remedy, blue bird will replace the original switch with a switch pack that is not sensitive to extreme cold weather and will inspect to ensure the microswitch heater wiring is properly connected. The safety improvement campaign began on august 12, 2005. Owners may contact blue bird at 478‑822‑2242.

Recall number 05V251000 · Recall details

Equipment adaptive/mobilityReported August 30, 2004 · 372 vehicles affected

What is wrong: Certain blue bird 1999-2005 all american, tc/2000, micro bird, vision, conventional, and commercial series school buses equipped with sure-loc wheelchair securement systems and manufactured between february 17, 1999, and august 13, 2004. Certain sure-lok wheelchair tie-down securement assemblies p/n 8625-13. The sprocket teeth of the retractor assembly may be out of alignment causing the load pawl not to fully seat in the sprocket teeth.
Risk: In the event of a vehicle crash, the wheelchair may not be adequately secured possibly resulting in injuries.
Remedy: Blue bird will notify its customers and replace the defective part free of charge. The recall began september 21, 2004. Owners who take their buses to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact at blue bird at 478‑822‑2242.

Recall number 04V426000 · Recall details

SeatsReported October 8, 2003 · 3,825 vehicles affected

What is wrong: On certain school buses equipped with optional seat belts or seat belt "ready" seats, some belts were installed with only two bolts rather than the required three (3) bolts.
Risk: These seats could detach from the wall side attachment points in the event of a vehicle crash, increasing the risk of injury to the seat occupant.
Remedy: Blue bird will furnish to distributors and owners, parts and instructions necessary to install the missing bolt free of charge. Owner notification is expected to on november 3, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact blue bird at 1‑478‑822‑2242.

Recall number 03V364000 · Recall details

Service brakes, hydraulic: foundation components: hoses, lines/piping, and fittingsReported November 13, 2002 · 485 vehicles affected

What is wrong: On certain front engine school and transit buses equipped with hydraulic brakes, the rear hydraulic brake hose could contact the frame rail and abrade, allowing brake fluid leakage.
Risk: If this occurs, vehicle braking could be affected, increasing the risk of a crash.
Remedy: Dealers will inspect the rear brake hose to frame rail clearance and reposition the brake hose clamps at the axle to ensure adequate clearance. Any chafed brake hoses will be replaced. Owner notification began december 12, 2002. Owners who take their vehicles to an authorized dealer and do not receive the free remedy within a reasonable time should contact blue bird at 1‑478‑822‑2242.

Recall number 02V302000 · Recall details

See all 6 recalls for the 2003 Blue Bird TC2000

Defect investigations

School bus stallsOpened May 25, 2005, closed September 27, 2005

This investigation was opened after odi received a complaint from a school bus fleet reporting that three separate buses had stalled unexpectedly while they were loaded with children.reportedly, each time the failure occurred the master battery shut-off switch was identified as being defective.odi opened this investigation to gather specific information and details into these allegations.as a result of odi?s investigation, blue bird has agreed to initate a safety recall to replace the standard nut on the 10/32 stud with a locking nut, check for proper wiring installation , and reposition the wires so that they do not stress the stud.a copy of the recall is attached.blue bird's action resolves the issues raised by this investigation and therefore, this investigation is closed.

PE05028

Technical service bulletins for the 2003 Blue Bird TC2000 2

Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.

Dec 8, 2016 Service bulletinNew Blue Bird Support Center
Jan 14, 2016 Service bulletinBlue Bird Troubleshooting Guides: Blue Bird announcement of the addition of troubleshooting guides for...

What 2003 Blue Bird TC2000 owners say

Most recent owner complaints, unedited.

Filed Feb 7, 2006 · Fuel system · NY

Dt*: the contact stated the school bus continued to stall out at various speeds without any prior warning. There was a recall the federal safety agency campaign id # 05e007000 concerning the fuel system however; the recall repair did not correct the problem. The manufacturer extended the warranty of the part replaced in the recall. This problem persisted on a fleet of school buses covered by the recall.