2003 BMW 325I: fuel pump failure

Filed Nov 21, 2019 · Fuel system · NY

I own a 2003 sulev bmw and it needs a fuel pump. This only can be repaired by a dealership due to the fact it has a sealed fuel tank. The cost can be 6 to 8000.00 dollars. I was told there is an extended warranty for a sulev car. 150000 mi or 15 years. I called bmw and they never heard of that warranty. Can you please help. Thank you

Filed Mar 7, 2016 · Fuel system · 192,177 miles · CA

The fuel pumps of the super low emission vehicles (sulev) (pzev) 325i models (in ca, me, ma, ny and vt) are enclosed in the stainless steel fuel tank and there is a known 100% failure. Bmw has a 15 year/150k warranty but I am contacting you because my car has 192k and is out of warranty. For known defective material and workmanship of the fuel pump, there should have been a recall or at least notification to the owners of such vehicles. In most cases, even when under warranty the bmw dealerships gave owners difficulties and resistance when the fuel pump failed, particularly because the part alone is $6000, not including labor. As many of these sulev models are still on the road and potentially would stop running at any point when the fuel pump clogs or gets blocked, the drivers are potentially placed in danger. My 2003 325i died on the freeway going 70mph but fortunately I was able to safely maneuver to the shoulder. This could have easily caused a multi-car accident but fortunately there weren't many other cars on the freeway at the time. There was nothing I could do but coast to the side of the road. It would not start again and is basically dead in the water now. The local bmw dealership refuses to do anything since it is out of warranty. Again, although this affects later model sulev cars, I ask you to please open an investigation, as bmw should stand by their product and reputation by repairing a known defective part that affected or will affect all sulev models. Typically the fuel pump fails prior to the 150k mileage, but apparently since I rarely allow my fuel tank to go below a quarter tank, I was able to get an additional 40k. Regardless, I think a recall for this major defect is much more important than the rear lamp which did initiate a recall. Bmw should be ashamed of themselves and I will never even think of buying another bmw ever again.

Filed Feb 22, 2012 · Fuel system · 79,000 miles · FL

The fuel pump went bad ,and left me stranded on a busy street,it suppose to have a manufacturer warranty for 15years or 150,000 miles from bmw, but they don't honor it at the dealer,I feel this should be a recall due to the fact that the fuel pump is sealed inside the tank,which leaves no access to change the pump,and the dealer is stating that we have to pay 6500.00 for the whole tank.. This should be a recall..

Filed Jul 24, 2009 · Fuel system · 68,172 miles · VA

Tl*the contact owns a 2003 bmw 325i. The contact noticed a crack in the fuel tank that caused gasoline to leak out. Each time the gasoline tank is filled, he smells fumes. Recently, after filling the vehicle with gasoline, the contact parked his vehicle and observed approximately a quarter tank of fuel on the ground. He took the vehicle to his mechanic and was informed about the crack in the fuel tank. The bmw manufacturer advised him to take the vehicle to the dealer to determine if the fuel tank was cracked. Once this has been determined, the contact may be eligible for reimbursement or bmw will repair the vehicle. The failure mileage was 68,172. Updated 8/18/09 *cn the dealer determined the gas tank was not cracked, but the leak was caused by a seal that was installed incorrectly at the fuel pump. Updated 08/21/09.

Filed Jul 3, 2003 · Brakes, Engine · 1,600 miles · CA

1. Transmission: after transmission repair, constant hard downshifting of automatic transmission when coming to a stop in d and s d modes. Vehicle jerks forward when decelerating between speeds of 42 to 35 MPH (usually when driven before with speeds in excess of 50 miles an hour). Also, after transmission repair, constant loud thumping noise when coming to a stop 2. Engine:intermittent loud engine revving and immediate torque loss occurring when taking off from a stop.intermittent delayed engine start of up to 3 seconds after turning key in ignition .intermittent prm idle fluctuation resulting in vehicle shuddering 3. Brakes:loud break squeaking when coming to a stop 4. Fuel tank / fuel pump:after defective fuel tank/pump replacement, recurrence of loud whining noise ( confirmed with bmw of north america) 5. Cd player: intermittent built-in business cd player skipping 6.steering wheel: steering wheel creaking when turning.