BMW 325I fire or smoke problems

Filed Jul 9, 2026 · Electrical · 127,000 miles · TN · fire

The complaint was filed on behalf of the contact's mother. The contact's mother owned a 2005 BMW 325i. The contact stated that while the vehicle was parked and unoccupied, the contact's brother noticed that the vehicle was on fire. The contact's brother used a nearby water hose and extinguished the fire. The Fire Department and the Police arrived. A fire report and a Police report were filed, however the Police report information was unavailable. In addition, the contact was informed that the light module was the source of the fire. The contact stated that the failure was a known failure. The vehicle remained at the residence. The vehicle was deemed a total loss. The manufacturer was made aware of the failure. The failure mileage was approximately 127,000.

Filed Apr 10, 2026 · Electrical · TX · fire

While driving the vehicle, the blower (A/C) began to cycle on and off. Then I began to smell electrical smoke. Then I began to see smoke coming from vents and where the windshield meets the dashboard, closer to the passenger side. I pulled over and shut off the car as the smoke was getting worse inside the car. I popped the hood and saw smoke coming from the passenger side. I then called 911. Smoke was beginning to billow from engine compartment. As I was talking to the 911 dispatcher, I saw flames beginning in the engine bay close to the firewall on passenger side. The car was a total loss and is in a tow yard. It can be inspected upon request. The 911 operated told me to be aware of smoke and explosions so I backed away about 30ft. Many cars were passing by, close to the car. There are 2 safety recalls on this vehicle that are related to possible fire. I have an open case with BMW USA. They have not inspected the car. I have liability only for insurance so they will not cover. There were no warning lamps or indicators before fire.

Filed Nov 17, 2025 · Engine · 168,000 miles · CA · fire

The contact owns a 2002 BMW 325i. The contact stated that upon exiting the store, he observed fire emerging from the driver's side dashboard. The vehicle spontaneously combusted and was engulfed in flames. There was no warning light illuminated prior to the failure. The fire department was able to successfully extinguish the fire. No injuries were reported. The vehicle was still in the parking lot where the incident occurred. A police officer was on the scene, but no report was filed. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the automated system confirmed there was no recall coverage. The approximate failure mileage was 168,000.

Filed Jan 7, 2025 · Electrical, Engine · 140,000 miles · FL · fire

The contact owned a 2006 BMW 325i. The contact stated while driving 60-65 MPH, the A/C became inoperable and made an abnormally loud sound. The contact then noticed an abnormal burning wiring odor, and there was smoke coming out of the A/C vents. There was no warning light illuminated. The contact stated that she attempted to pull to the side of the road, but could not safely do so. The contact continued driving and came to a complete stop at the traffic light, where the cabin became engulfed in smoke. The contact then pulled into a business parking lot and immediately exited the vehicle. The contact stated upon opening the hood, the contact noticed a reflection of the flame inside the hood. The contact ran into the business and asked for assistance. The contact stated that upon returning to the vehicle, the contact noticed that the fire had started from the middle of the hood to the cabin of the vehicle. The contact and the business employee attempted to extinguish the fire with two fire extinguishers but were unable to do so. The fire was extinguished by the fire department. The contact stated that the vehicle burned to the ground from the middle of the hood to the trunk, where the gas tank was located, and the hood was fractured in half. The contact stated that there were burned particles around the parking lot, but there was no property damage. The fire department report was filed. A police report was filed, but the contact did not have the information available. There was no injury sustained. The vehicle was towed to a tow lot, where it was totaled. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 140,000.

Filed Sep 12, 2024 · Electrical, Engine · GA · fire

The contact's husband owns a 2006 BMW 325i. The contact stated moments after her son had started, parked and exited the vehicle, there was smoke coming from under the hood. The under hood caught on fire and the hood failed to open. The fire was extinguished by the fire department. The contact stated that the under hood, the front of the vehicle and the front tires burned significantly. A fire department report was filed. A police report was not filed. There was no injury sustained. The vehicle remained at the residence. The vehicle was awaiting to be destroyed. The dealer was contacted. The contact contacted the manufacturer and sent pictures of the incident to the manufacturer; however, the manufacturer informed the contact that the fire was not related to the federal safety agency Campaign Number: 22V119000(Engine and Engine Cooling). The failure mileage was unknown.

Filed Jul 1, 2024 · Electrical · OK · fire

On June 28,2024, after parking and turning off the ignition switch, the dash started smoking and within minutes the whole dash and front of car were on fire. The car almost completely burned to the ground before the fire department could get there. The car was recently serviced at a BMW for an air bag recall. Heater ducts were loose when returned. There are also recalls for the 2006 325i for similar dash fires. The cause could be either dealer work or a factory issue.

Filed Nov 22, 2023 · Engine · 132,000 miles · TX

The contact owns a 2006 BMW 325I. The contact received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated while driving 40 MPH, there was a significant amount of smoke coming out of the exhaust pipe and coming from underneath the hood of the vehicle. The check engine warning light was illuminated. The contact drove to the local dealer, where it was diagnosed that the PCV valve heater fuses had failed. The dealer charged a fee for the repair because the recall remedy was not available. The dealer installed an inline fuse and wiring that connected the PCV valve to the PCV valve heater. The contact stated that he received a second notice advising that the recall remedy was available, and the vehicle was taken back to the dealer, where the recall repair was performed. The vehicle was repaired. The contact later contacted the manufacturer for reimbursement, but the manufacturer referred the contact back to the dealer for assistance. The contact stated that he followed up with the dealer, who advised him that the failure was not related to the recall. The contact was not reimbursed. The failure mileage was approximately 132,000.

Filed Jul 7, 2023 · Body, Electrical · NC · fire

On Tuesday June 20, 2023 at 7:20am I was awakened by my neighbor who informed me that my car was on fire. A report was done by the fire department and they did not believe it was done on purpose but something with my car. My car was totally consumed with fire nothing but ashes.

Filed Aug 31, 2022 · Engine · 188,000 miles · NC · fire

The contact owns a 2001 BMW 325i. The contact stated that while the vehicle was parked overnight and off, the vehicle caught on fire. The contact was alerted by her father that the vehicle was on fire. There were no occupants at the time of the fire. The entire front end of the vehicle was engulfed in flames. The fire department was called to the scene. It was unknown if there was a fire report was filed. There were no injuries sustained. The father of the contact had a truck parked in front and due to the flames of the vehicle fire, it melted the front of the parked vehicle causing damage. The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was not driveable after the fire. The manufacturer was not made aware of the failure. The failure mileage was 188,000.

Filed May 18, 2022 · 178,000 miles · TX · fire

The contact's husband owned a 2006 BMW 325i. The contact stated that while her niece was driving at an undisclosed speed, there was smoke coming from underneath the hood. The contact's niece pulled over, and she and her boyfriend safely exited the vehicle before it caught fire. No injuries were sustained and no medical attention was received. The fire department was able to extinguish the fire. A fire department report was filed. The vehicle was towed to a tow yard; however, it was not yet deemed totaled by the insurance company. The manufacturer was not made aware of the failure. Upon investigation, the contact was made aware that there were 3 unrepaired recalls associated with the VIN with the federal safety agency Campaign Numbers: 17V676000 (Electrical System), 19V273000 (Engine and Engine Cooling), and 22V119000 (Engine and Engine Cooling). However, the contact had not received the recall notifications. The failure mileage was approximately 178,000.