BMW 328D stalling problems

Filed May 11, 2026 · Fuel system · CA

1.) The Bosch CP4 High-Pressure Fuel Pump (HPFP), OEM part number 13517824477 / 0445010517, failed catastrophically. This is the factory-installed pump on the 2014 BMW 328d equipped with the N47 diesel engine. Upon failure, the pump's internal cam and roller assembly disintegrated, releasing metal shavings throughout the entire fuel system — contaminating the fuel lines, injectors, fuel rail, and fuel tank. The vehicle will not start. The failed pump and contaminated fuel system components are available for inspection upon request. 2.) The vehicle experienced a sudden, complete loss of motive power with no prior warning, rendering it unable to start or operate. This type of failure — as documented in the federal safety agency Engineering Analysis EA23-001 — is known to also occur while the vehicle is in motion, causing unexpected engine stall at highway speeds with no ability to restart. This creates an immediate risk of rear-end collision, loss of vehicle control, and danger to other motorists. The failure provides no warning to the driver and cannot be prevented through normal maintenance practices. 3.) Yes. The high-pressure fuel pump failure and presence of metal shavings throughout the fuel system have been confirmed by a BMW authorized dealership. The dealer has documented the failure and provided a repair estimate for full fuel system replacement — including the HPFP, injectors, fuel lines, and tank cleaning — at an estimated cost of $10,000–$15,000. BMW of North America has declined warranty coverage citing that the vehicle has exceeded the 120,000-mile threshold under Recall 21V‑586, despite this being the identical defect covered by that recall. 4.) Yes. The vehicle has been inspected by a independent BMW Specialist 5.) Check engine light was present

Filed Oct 21, 2025 · Fuel system · 150,000 miles · CA

The contact owns a 2015 BMW 328D. The contact stated that while driving 15-25 MPH, there was an abnormal sound coming from the engine, and the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle stalled. The contact was able to coast to the side of the road. The vehicle failed to restart. The contact was unsure if any warning lights were illuminated. The vehicle was towed to a BMW-Authorized mechanic, who diagnosed that the fuel pump had failed, and there were metal shavings found in the fuel. The vehicle was not repaired due to the cost. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The contact related the failure to the federal safety agency Campaign Number: 21V586000 (FUEL SYSTEM, DIESEL); however, the VIN was not included. The failure mileage was 150,000.

Filed Jun 24, 2025 · Fuel system · WA

I was driving to work when my engine started sputtering acting like it was about to turn off. I quickly pulled off to the side of the road and as soon as I did, the engine stalled and turned off. I'm lucky that I pulled off the road because if it turned off while on the road I could have caused an accident. The car is no longer able to turn on. I had to get it towed to my work where I had a mechanic look at it. They said they believe the high-pressure fuel pump failed. I researched this online and saw that there is an open the federal safety agency campaign for it (#21V586000). My car is a 2014 BMW 328D with the N47 engine. It seems that my car would fall under this recall but when I put in my VIN it says it does not have a match for it. How is it possible for my vehicle to be accepted into this recall.

Filed Nov 18, 2024 · Fuel system · NV

While driving our 2014 BMW 328d the engine misfired then stalled on the highway. This was a very dangerous and frightening scenario trying to push it off of the roadway while my wife and children were inside the car while highway traffic on the I-15 interstate rushes by. I was not able to restart, so we had it towed to our local BMW shop. Diagnosed as High Pressure Fuel Pump complete failure. Metallic debris throughout the entire fuel system, lines, tank filter, injectors, pumps. No check engine light or any prior warning. Many of the components have already been disassembled to determine the extent of damage, and all the components are currently with the vehicle, and available for inspection. The vehicle has been at the shop since the end of June. Some parts were initially ordered then all repairs put on hold while awaiting direction/ recall approval from BMW of North America. 5 months later we are being told this vin does not qualify for the safety recall. We can not afford the cost of the repairs and they will likely exceed the value of the car. We also need to remove it from storage at the shop it was towed to, and take it somewhere else while this is sorted out.

Filed Mar 8, 2024 · Fuel system · UT

High pressure fuel pump failed while underway causing vehicle to immediately stall in traffic and lock in "Park" making it unable to move. Mechanic (Werner's European Auto) confirmed diagnosis of catastrophic failure of the pump. Part is available for inspection. This part for the gasoline version of the 2014 328 series car is subject to a recall notice but for some reason the notice does not apply to the diesel version of this model. Repair cost is estimated at $11,000 to replace entire fuel system due to metal particles released when the pump broke

Filed Nov 8, 2023 · Engine, Fuel system · CA

stall/loss of power while entering highway on ramp. Engine died and would not restart. After inspecting car found the gas tank to be filled with metal shavings which is indicative of a failed high pressure fuel pump. My year make and model vehicle has a recall on the HPFP for the same reason but my VIN was supposedly not affected.

Filed May 8, 2023 · Fuel system · 92,000 miles · CA

The contact owns a 2014 BMW 328D. The contact stated that on several occasions while driving at various speeds, the vehicle stalled and lost motive power. The vehicle failed to restart. The vehicle was towed to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken to a local dealer, where it was diagnosed that the high-pressure fuel pump needed to be replaced again. The vehicle was repaired; however, the failure recurred. The vehicle was taken back to the dealer to be serviced under the federal safety agency Campaign Number: 21V907000 (Fuel System, Diesel). The vehicle was repaired; however, the contact stated that the failure reoccurred while driving at an undisclosed speed, and the check engine warning light was illuminated. The vehicle was taken back to the dealer, where it was diagnosed that further inspection of the high-pressure fuel pump was required. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 92,000.

Filed Dec 24, 2022 · Engine, Fuel system · CA

I was in a busy Freeway driving & Now my 2014 Bmw 328 D high pressure fuel failed which caused me to stall and be stuck in the middle of the freeway which also almost made me cause like 10 car crashes it was sorry scary but lucky police helped out and other driver where also caution

Filed Feb 22, 2022 · Engine, Fuel system · WV

On February 5, 2022 while driving on 70 mph on I64 my vehicle shut down due to the recall causing the the high-pressure fuel pump to shut down causing the engine to stall and a message that there was a powertrain malfunction and the vehicle would not start back or go into gear. The interstate was very busy and I could have been hit by a tractor trailer or another vehicle at high speed. I received a recall notice that stated there was a remedy available November 2021, but when I called the dealership I was told there were no parts available and they would call me when parts became available. A month went by and the issue with the recall happened leaving me in a very dangerous situation. The car was towed to Moses BMW on 2/6/22 and over 30 parts have been ordered. I have been told that there is no estimate on when the parts would arrive. There is a second safety recall with no remedy that has been present October 2018 and Moses BMW sold me the vehicle in June 2020. I received a notice January 2022. This recall is for the EGR Cooler developing an internal leak possibly causing the vehicle to catch fire. I have asked BMW to buy the vehicle back due to safety reasons and the long wait time to fix the one recall and no fix for the other, and they refuse. In addition, they sold me a vehicle that was under recall and according to S.1634 - Used Car Safety Recall Repair Act that was against the law.

Filed Feb 3, 2022 · Fuel system · 115,000 miles · IA

The contact owns a 2014 BMW 328D. The contact stated that after parking the vehicle for approximately 10 minutes after driving, the vehicle was then restarted, made an abnormal noise, and stalled. The contact stated that no warning lights had been illuminated at the time. The contact stated that he stepped out of his vehicle to inspect the surroundings and noticed a large puddle of fuel under his vehicle. The vehicle was unable to be restarted. The contact stated that he then had his vehicle towed to the dealer, where it remained. The dealer and manufacturer were notified of the failure, however, they were not able to assist. The mileage failure was 115,000