2018 BMW 330I: engine overheating

Filed Mar 31, 2026 · Engine · 40,000 miles · NJ

The contact owns a 2018 BMW 330I. The contact stated that while driving at an undisclosed speed, unknown warning lights were suddenly illuminated, indicating that the engine was overheating. The message instructed the driver to shut off the vehicle immediately. The contact pulled over and turned off the vehicle, and it was discovered that the coolant reservoir was empty. The vehicle was towed to a local dealer, where it was determined that there was a plastic part from the oil cooler housing that needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 40,000.

Filed Mar 31, 2026 · Engine · KY

The engine overheated and suddenly lost power/ acceleration while driving in rush hour traffic at highway speed. I had to move across 3 lanes of traffic to get on to shoulder of highway safely while car and engine sputtered and slowed to a stop with no power or acceleration. After having vehicle towed I was told by certified technicians that the oil filter housing was made of plastic with coolant lines inside and failed causing rapid coolant loss with no low coolant warning and ultimately loss of engine and power.

Filed Sep 18, 2025 · Engine · 80,000 miles · GA

The contact owns a 2018 BMW 330I. The contact stated that while driving 35-40 MPH, the vehicle shut off unintendedly. The contact stated that there was an oil intake leak and a coolant leak. There were several warning lights illuminated after the failure. The vehicle was towed to an independent mechanic, who determined that there was an engine malfunction with the vehicle. The local dealer was contacted and confirmed there was no recall or warranty coverage on the VIN for the failure. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 80,000.

Filed Aug 13, 2025 · Engine · NY

Car keeps overheating. Water pump, water hose and expansion tank have been replaced several times and the car still overheats.

Filed Apr 21, 2025 · Engine · CA

My 330i 2018 bmw has a cracked in the oil housing unit. This is due to bmw putting plastic parts instead of aluminum. After researching this I found thousand of people complaining about the sane thing. The car overheats and sometimes the oil gets mixed into the coolsnt system b causes more damage. This seems to happen on cars with mileage between 60-70 on engines B46, B48 n B58z

Filed Mar 3, 2025 · Engine · NY

Oil Filter Housing failed and coolant gushes all out which makes the car undrivable and risk of engine overheating and failure.

Filed Feb 10, 2025 · Fuel system · 60,150 miles · PA

The contact owns a 2018 BMW 330I. The contact stated that while driving at various speeds, the engine overheating message was displayed on the instrument panel with the temperature gauge rising to hot(H). The vehicle was taken to an independent mechanic where the coolant reservoir was topped off however, the failure persisted. The contact then received notification of the federal safety agency Campaign Number: 21V907000 (Fuel System, Diesel) which was linked to the failure. The vehicle was taken to the dealer where the recall repair was performed. The contact stated that recently the vehicle began to leak coolant. The vehicle was taken back to the dealer and the contact was informed that the manifold needed to be taken off to perform a diagnostic test. The contact was informed that the oil filter housing unit and the water pump both needed to be replaced. The manufacturer was notified of the failure and transferred the contact to the federal safety agency Hotline to report the failure. The vehicle remained in the possession of the dealer unrepaired. The failure mileage was approximately 60,150.

Filed Jan 16, 2025 · Engine · NY

The vehicle gave a warning that the engine coolant was low and to power down before it overheated. Upon taking it to the dealer, it was discovered that the oil housing unit was defective. After doing online research, this is a very common issue with this part. I had a previous vehicle with a similar issue that caused the vehicle to shut down in traffic from overheating.

Filed Dec 4, 2024 · Engine · OH

On 12/03/2024, while traveling at approximately 35mph, the "top off coolant" light came on. After traveling for approximately 10 more minutes, in route to get coolant, a warning message came on the screen advising to drive cautiously to prevent engine scorching. The vehicle then began to slightly lose power while traveling on a busy road. The vehicle was then shut down and towed to BMW dealership. During the tow, it was discovered that coolant was leaking from the center area of the engine block. The manufacturers dealership service rep advised that the technicians discovered that the oil filter housing needed to be replaced. They also found that the coolant pump also needed to be replaced. The rep advised that the coolant seal on the oil filter housing had worn down and caused the coolant leak. He also advised that the coolant pump needed to be replaced, as it was also leaking. It was later discovered because the valve that the pressure propelled, hot coolant flows through in the oil filter housing is made of plastic, it often wears down and coolant leaks out heavily. The water pump is also effected by the part manufacturing issue. In addition to receiving a $4,270.42 invoice for repairs today, we just recently purchased the $199.00 BMW Vehicle Check Service from the dealership on 9/23/2024. At that time, we were advised there were no issues with the vehicle. We have sense learned that there have been multiple recalls on various BMW models for this exact same issue. However, the VIN on my vehicle has not yet been identified for recall. Had this issue gone on for mere moments more, the engine could have caught fire, and or, a catastrophic crash could have ensued, effecting any driver on the road.

Filed Feb 2, 2024 · Engine, Transmission · FL

Multiple codes came on right after I had gotten my thermostat and my water pump fixed. However it ended up being that there was more leaks throughout the rest of the car. The car has currently cost me $3400 to fix and it’s still not fixed because nobody can figure out where the actual leak is coming from. The coolant is leaking and nobody can figure out where, it’s been having jerking issues since it started leaking and I read on other Bmw’s that the coolant leaks into the head gasket, causing the engine to blow

Filed Jan 15, 2024 · Engine · CT

At around 65k miles multiple plastic engine coolant connectors and hoses crack and fail. 5 locations at the same time! Coolant pump leaks. I went to an independent repair shop for a second opinion and repairs for $2,400 so far. Cheaper than the BMW service department. There was a recall done 2 years ago for 1 hose I believe. The entire cooling system should be recalled. We could be stranded somewhere in a bad situation and the engine could be destroyed if overheated. Awful and bad design.

Filed Jan 2, 2024 · Electrical · 51,086 miles · CO

The contact owned a 2018 BMW 330I. The vehicle was taken to a local dealer for a Manufacturers Recall: 0017150200 related to the Coolant Leak to be completed. The contact stated that after driving 7 miles to her home at 35 MPH, there was smoke coming from the engine compartment. All the warning lights illuminated. The vehicle was powered off and the smoke extinguished on its own. A fire report was not filed. There were no visible flames. The local dealer was called and the vehicle was towed back to the dealer where it was confirmed that the pressure test was not completed and there was no coolant in the vehicle. The dealer informed the caller that the struts needed to be replaced however the coolant failure was repaired. The vehicle was repaired for the coolant failure however the contact mentioned that the vehicle was not performing as designed. The manufacturer was not notified of the failure. The failure mileage was 51,086.