1. Vanos Bolts recall. the federal safety agency Recall 23V‑707. Cause the car the have a rough idle, check engine light, car to stall, and cut off in traffic all with seconds. Dealership says it was not the Vanos Bolts that cause the shutdown, but it is the DME and ICM. 2. The safety of myself and my 15 year old daughter was at risk, along with the drivers on the highway. The car stopped in traffic, and would not release out of park to go in neutral. 3. State Trooper came to call a tow truck, the car was inspected by BMW of Irondale. 4. No warning lamps, messages or other symptoms prior to the failure. The car was driving as normal, a sudden rough idle, light came on, and the car cut off in ongoing traffic, with not warning before.
2011 BMW 528I engine problems
66 complaints (56% of all complaints for this car). Typical mileage when it fails: 94,000.
- owner complaints
- 66
- of this car's complaints
- 56%
- typical mileage
- 94,000
- crashes
- 0
- recalls
- 2
Which part fails
- Exhaust system: emission control: crankcase (PCV)1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
BMW 528I engine problems in other years
Specific symptoms reported on the 2011 BMW 528I engine
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Engine and engine cooling: exhaust system: emission control: crankcase (PCV)
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2008-2011 128i and 2007-2011 328i, 328xi, 328i xDrive, 525i, 525xi, 528i, 528xi, 530i, 530xi, X3 3.0si, X3 xDrive30i, X5 xDrive30i, Z4 3.0i, Z4 3.0si and Z4 sDrive30i vehicles. The heater for the positive crankcase ventilation (PCV) valve may short circuit.
- Risk
- An electrical short can cause the parts within the PCV valve to melt, increasing the risk of a fire, even when the vehicle is not in use.
- Remedy
- BMW will notify owners, and dealers will replace the PCV valve heater, free of charge. Interim letters were mailed on November 27, 2017. Owners will receive a second notification by the end of October 2018. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 17V683000 · Recall details
Engine and engine cooling: engine
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2010-2011 128i Coupe, 128i Convertible, 328i Sedan, 328i xDrive Sedan, 328i Coupe, 328i Convertible, 328i Sports Wagon and Z4 sDrive 30i, 2011-2012 135i Coupe, 135i Convertible, 335i Sedan, X5 xDrive 35i, and X6 xDrive 35i, 2011 335i xDrive Sedan, 335i Coupe, 335i Convertible, 528i Sedan, 535i Sedan, 535i xDrive Sedan, X3 xDrive 28i, and X3 xDrive 35i, 2010 X3 xDrive 30i, and X5 xDrive 30i, 2012 640i Coupe, and 640i Convertible and 2010-2012 535i Gran Turismo vehicles. In the affected vehicles, the bolts that secure the housing for the variable camshaft timing adjustment (VANOS) unit can loosen over time and may possibly break.
- Risk
- If the bolts loosen or break the engine may have reduced power or stall. An engine stall increases the risk of a crash.
- Remedy
- BMW will notify owners, and dealers will replace the four VANOS housing bolts for both VANOS units (intake and exhaust), free of charge. In addition, owners of approximately 170,172 model year 2010-2012 BMW vehicles equipped with inline 6 cylinder engines not covered by this recall, will receive an extended warranty to address this condition. The recall began on September 24, 2014. Owners may contact BMW at 1‑800‑525‑7417.
Recall number 14V176000 · Recall details
What 2011 BMW 528I owners say
Most recent owner complaints, unedited.
I am filing a complaint regarding the recall work performed on my 2011 BMW 528i for the VANOS bolt safety recall. The recall notice stated the vehicle was unsafe to drive until repaired. I arranged towing to Jackie Cooper BMW in Edmond, Oklahoma because of this safety warning. The dealership performed the recall repair and released the vehicle back to me. Immediately after picking it up, the vehicle experienced a failure and became inoperable. The vehicle had to be towed again. This time, the dealership covered the towing cost and had the vehicle returned to my residence. Staff present at the time included a technician named Luke and the Service Drive Manager, Tayler Hawkins. Staff statements indicated that diagnostic charges would have applied if issues outside the recall were found, but no diagnostics were ultimately billed. There were also inconsistencies regarding the availability of the service manager. I am filing this complaint because the vehicle failed immediately after recall service and required towing. I am concerned that the recall work may not have been performed correctly or that the vehicle was released in a condition that was not suitable for operation. I am requesting that this incident be documented as part of the recall and safety record for this vehicle.
The contact owns a 2011 BMW 528I. The contact received notification of the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.
The contact owns a 2011 BMW 528I. The contact stated while driving approximately 35 MPH, the check engine warning light illuminated, and the vehicle stalled. The contact pulled over, and after several attempts, the vehicle restarted. The contact was able to restart the vehicle, and the message "Drivetrain Malfunction" was displayed. The contact stated that the failure started recently and had occurred several times. Additionally, the vehicle was vibrating intermittently and lost motive power. The contact stated that occasionally the vehicle failed to accelerate above 15 MPH. The contact smelled the odor of gasoline inside the vehicle. The contact stated that the check engine warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 80,000.
The contact owns a 2011 BMW 528I. The contact received notification of the federal safety agency Recall Campaign Number: 23V707000 (ENGINE AND ENGINE COOLING), and the vehicle was taken to a local dealer for the recall repair. The contact stated that while driving 40 MPH, the message "Drive Train Malfunction - Drive Moderately" was displayed. The vehicle was towed to the same dealer to be diagnosed. The contact was informed that faulty spark plugs had caused damage to a cylinder, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 123,568.
The contact owns a 2011 BMW 528i. The contact stated that the vehicle was repaired under the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling); however, following the recall repair, the vehicle was stalling with the check engine warning light illuminated. The contact stated that the vehicle was towed back to the same dealer. The contact stated that the dealer had diagnosed the vehicle and determined that the VANOS solenoids had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure of the VANOS solenoids to the recall repair of the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling). The manufacturer was informed of the failure. The failure mileage was approximately 112,000.
The contact owns a 2011 BMW 528I. The contact stated that while her husband was driving at or above 50 MPH on several occasions, the vehicle began shaking and running rough. The check engine warning light flashed on and off during one occasion and then remained illuminated. Additionally, on two occasions while stopped at a red light and a stop sign, the accelerator pedal was depressed, and the vehicle stalled. After two failed attempts to restart the vehicle, the vehicle was restarted several hours later. The vehicle was taken to the dealer and repaired under the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling). The contact was then advised by the dealer that the vehicle would not start. The manufacturer was notified of the failure but provided no assistance. The failure mileage was unknown.
The contact owns a 2011 BMW 528I. The contact received notification of the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the local dealer, where the contact was made aware of an oil leak. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the failure. The failure mileage was approximately 101,147. Parts distribution disconnect.
See attached document for complaint.
The contact owns a 2011 BMW 528I. The contact stated while driving approximately 35 MPH, the vehicle made an abnormal sound and stalled. The check engine warning light and brake warning light repeatedly illuminated on and off. The vehicle was difficult to control, causing the contact to drive over a pothole, causing the rear window glass to shatter. The contact's two children were in the rear seats, and one was cut in the back of the neck with the shattered glass. No medical attention was sought. The contact received notification of the federal safety agency Campaign Number: 23V707000 (Engine and Engine Cooling) prior to the failure; however, the part to do the recall repair was unavailable. The contact believed that the failure was caused by the recall. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The vehicle was drivable and was driven back to the residence. The vehicle was not repaired. A dealer was not contacted. The manufacturer was not notified of the failure. The failure mileage was 170,000. VIN tool confirms parts not available.
Questions about the 2011 BMW 528I engine
Does the 2011 BMW 528I have engine problems?
Owners have filed 66 complaints about the engine of the 2011 BMW 528I, 56% of all its complaints, more than any other problem.
At what mileage do 2011 BMW 528I engine problems start?
The typical (median) mileage in owner complaints is 94,000 miles.
Is there a recall for the 2011 BMW 528I engine?
Yes, 2 recalls: 17V683000, 14V176000. Check your VIN to see if your car still needs the free repair.
Other 2011 BMW 528I problems
Transmission 25Fuel system 23Electrical 9Acceleration 6Steering 6Airbags 4Suspension 4Lights 3Body 2Visibility 2Locks 1Seat belts 1Seats 1Tires 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 BMW 528I?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history