2016 BMW 528I: fire, smoke or burning smell

Filed Jan 27, 2026 · Body, Electrical · CA · fire

On January 29, 2020, while driving my 2016 BMW 5 Series under normal operating conditions, the engine compartment caught fire without warning. Smoke and flames originated from the engine bay while the vehicle was in motion. I was forced to pull over and exit the vehicle immediately. The fire spread rapidly, and the vehicle was declared a total loss. At the time, both my insurance carrier and BMW representatives inspected the vehicle, but no definitive cause was identified. In January 2026, I received notification that this same vehicle is subject to BMW Safety Recall Campaign No. 24V‑608, which states that liquid from the positive crankcase ventilation system can drip onto the water pump electrical connector, potentially causing a short circuit and, in rare cases, an engine fire. This recall describes the same failure event that destroyed my vehicle, which occurred before any recall remedy was available.

Filed May 19, 2025 · Electrical, Engine · 80,000 miles · NY

The contact owns a 2016 BMW 528i. The contact stated that while his partner was driving at undisclosed speeds, there was smoke coming from the engine and entering the cabin through the vents while the heater was activated. There was an abnormal burning odor entering the cabin. The contact also observed the burning odor while driving the vehicle. There were no warning lights illuminated. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 80,000. VIN tool confirms parts not available.

Filed Apr 30, 2025 · CA

Due to the nature of the car potentially catching on fire and a remedy still not being available I am concerned about my safety and of those around me since the car is used to be operated daily for commuting to work.

Filed Apr 21, 2025 · Engine, Fuel system · GA

Concern- smoke coming out of back exhaust at start up Cause - TAYLOR BMW (dealership) - possible needs updated oil line, turbo may be leaking internally Correction- dealership pulled faults to see if cat efficiency faults were present, saw none. Did verify smoke on startup. Doesn’t look like the turbo oil feed line has been changed (updated with check valve). There is some oil encrusted on the body of turbo. Would replace all lines since turbo removal is required for any of them; however once cat is off and if the chamber inside is wet with oil, at that point it would need a turbo as well as the lines. The above is the written diagnosis from dealership and I was quoted a price ranging from $2600- 4600- In 2016, the federal safety agency issued a notice for certain models/ years regarding the turbocharger feed lines (extending warranty for that part to 10 years / 120k miles). My 2016 was CPO and has only 84k (all maintenance performed by BMW) and I believe it should fall under eligible vehicles. I have reached out to BMW customer care, spoken with a case manager , all to no avail.

Filed Jan 18, 2025 · Electrical, Engine · TX

I have an Issue with my car cause Engine Coolant smells like oil burning and smoke coming inside the car through AC and also having a recall issue but no remedy available with BMW so spend my money and get repaired from outside mechanic, BMW reported me that if there is no remedy available right now so we can't do anything so I get repaired outside and spend 1500$.

Filed Dec 20, 2024 · Electrical, Engine · 80,000 miles · FL

The contact owns a 2016 BMW 528I. The contact stated while driving 50-60 MPH, there was smoke coming from underneath the hood and out of the exhaust pipes. The coolant temperature warning light and several other unknown warning lights were illuminated. The vehicle sputtered and stalled. The contact was able to pull to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the water pump had failed, causing several damages to the vehicle, including engine failure. The vehicle had not been repaired due to the cost. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 80,000. VIN tool confirms parts not available.

Filed Dec 5, 2024 · Electrical, Engine · 90,000 miles · CA

The contact's wife owns a 2016 BMW 528I. The contact stated that the vehicle was experiencing excessive coolant consumption. The low coolant warning light was illuminated. Additionally, the contact stated while his wife was driving at approximately 35 MPH, the driver noticed that there was steamy smoke coming out from underneath the hood. The driver pulled to the side of the road and noticed that fluid was leaking underneath the engine. The vehicle was taken to Sunshine Auto, where the contact's wife was informed that coolant was leaking. The mechanic informed the contact that the turbo needed to be taken out for a diagnostic test. The vehicle was not diagnosed or repaired. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 90,000. VIN tool confirms parts not available.

Filed Oct 31, 2024 · Electrical, Engine · 60,000 miles · CA

The contact owns a 2016 BMW 528I. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed, the instrument panel became inoperable. There was no warning light illuminated. The contact stated that the image on the instrument panel was blank. The contact also noticed smoke coming from the exhaust. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,000. VIN tool confirms parts not available.

Filed Oct 23, 2024 · Electrical, Engine · 120,000 miles · AL · fire

The contact owned a 2016 BMW 528I. The contact stated that while driving at 30 -35 MPH with the windows down, there was a smoke odor present. The contact pulled over into a parking lot and smoke was discovered coming from the front of the vehicle. The vehicle suddenly engulfed in flames as the contact was still seated in the vehicle. The contact was able to safely exit the vehicle. The fire department arrived on the scene and was able to extinguish the fire. The origin of the fire was unknown. It was unknown if a fire report was filed. No injuries were sustained. The vehicle was towed to an independent mechanic who determined that the vehicle was destroyed and the cause was unknown since the fire destroyed the front end of the vehicle including the dashboard and both front driver and passenger side door panels were melted. The dealer was not contacted. The manufacturer was not made aware of the failure. The VIN was included in the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System) however, the part to do the recall repair was unavailable. The failure mileage was 120,000. VIN tool confirms parts not available.

Filed Oct 22, 2024 · Engine · 150,000 miles · GA

The contact owns a 2016 BMW 528I. The contact stated while driving at various speeds, there was smoke coming through the A/C vents and coming from underneath the hood. The check engine warning light and an unknown warning light were illuminated. The contact later received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); which the contact related to the failure; however, the part to do the recall repair was not yet available. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 150,000. VIN tool confirms parts not available.

Filed Apr 11, 2021 · 50,000 miles · NY · fire

Car caught on fire when the engine was off for 2.5 hours. It happened while parked, in my apartment complex parking lot and no one was inside the car at the time.