This vehicle was subject to a recall under bulletin 16 0114. The issue was a fuel pump which cracked at flanges which leaked fuel onto the hot engine, which could cause safety issues with fire. My vehicle listed above, had the fuel pump replaced with 12,505 miles on it under the recall. The replacement fuel pump, which is apparently no better than the original that was replaced under recall, cracked again leaking fuel onto the hot motorcycle engine. This happened with 20,300 miles on the vehicle, which is less than 8000 miles later. BMW is refusing to replace under the recall or a warranty the fuel pump which means I am stuck with the bill. I believe that BMW should be replacing a defective part with a new design and better part not an old design faulty part. I would encourage you to issue another recall on the vehicles in question under bulletin 160114 in the interest of motorist safety.
2011 BMW R1200 RT fuel system problems
16 complaints (80% of all complaints for this car). Typical mileage when it fails: 31,588.
- owner complaints
- 16
- of this car's complaints
- 80%
- typical mileage
- 31,588
- crashes
- 0
- recalls
- 3
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
BMW R1200 RT fuel system problems in other years
Specific symptoms reported on the 2011 BMW R1200 RT fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2011-2014 S 1000 RR/R/ HP4, R 1200 GS/GS Adventure/R/RT, K 1300 S, K 1600 GT/GTL/GTL Exclusive and 2014 R nine T motorcycles. The fuel pump, and auxiliary fuel pump in certain models, may crack and leak fuel during vehicle operation.
- Risk
- A fuel leak, in the presence of an ignition source, may result in a fire.
- Remedy
- BMW will notify owners, and dealers will replace the fuel pump, free of charge. The recall began March 17, 2021. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 21V060000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain 2009-2011 K1300 (S, GT), 2010-2011 S1000 RR, 2005-2011 R1200 (GS, GS Adventure, R, RT, S, ST), 2006-2010 HP2 (Enduro, Megamoto, Sport), 2005-2008 K1200 (R, R Sport, S, GT), and 2012 K1600 (GT, GTL) motorcycles that were repaired under recall 13V‑617 with the support ring remedy and where the fuel pump was not replaced at a later date. This recall involves the fuel pump, and also the auxiliary fuel pump as applicable. The affected motorcycles have a fuel pump flange that may crack, possibly resulting in a fuel leak while the engine is running.
- Risk
- A fuel leak in the presence of an ignition source can increase the risk of a fire.
- Remedy
- BMW will notify owners, and dealers will replace the fuel pump(s) with an improved version, free of charge. The recall began January 18, 2021. Owners may contact BMW customer service at 1‑800‑525‑7417.
Recall number 20V471000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- BMW of North America, LLC (BMW) is recalling certain model year 2005-2011 model year R-model motorcycles, model year 2005-2012 K-model motorcycles, model year 2010-2011 S 1000 model motorcycles, and model year 2006-2010 HP2 motorcycles. In the affected motorcycles, the fuel pump flange (and the auxiliary fuel pump flange if equipped) could develop cracks and leak fuel.
- Risk
- A fuel leak in the presence of an ignition source may result in a fire.
- Remedy
- BMW will notify owners, and dealers will either reinforce the fuel pump flange or replace the pump, as necessary, free of charge. The recall began on April 16, 2014. Owners may contact BMW customer relations at 1‑800‑525‑7417 or email BMW at [email protected].
Recall number 13V617000 · Recall details
What 2011 BMW R1200 RT owners say
Most recent owner complaints, unedited.
The contact owns a 2011 BMW R1200 RT Motorcycle. The contact stated that while starting the motorcycle, fuel was spraying from the fuel line. There were no warning lights illuminated. The contact called the local dealer but the motorcycle was not diagnosed or repaired. The contact related the failure to the federal safety agency Campaign Number: 20V471000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer was contacted but no additional assistance was provided. The approximate failure mileage was 37,528.
Development of a major fuel leak after starting motorcycle, leak is coming from the high pressure fitting on the fuel pump. Very dangerous as the fuel is dripping on the hot exhaust and pooling on top of the fuel pump. Risk of fire and possibility of fuel getting on pant leg and burning riders leg. I talked to a couple dealers in the Phoenix area and it’s more common than not.
The contact owns a 2011 BMW R 1200 RT. The contact received notification of the federal safety agency Campaign Number: 20V471000 (Fuel System, Gasoline). The dealer was contacted and informed that the parts were not available. The contact called back the same dealer on two separate occasions and was informed that parts were still unavailable. The manufacturer was notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.
The contact owns a 2011 BMW R 1200 RT Motorcycle. The contact stated that fuel was leaking from motorcycle. There were no warning lights illuminated. The contact received notification of the federal safety agency campaign number: 20V471000 (Fuel System. Gasoline) however, the part to do the recall repair was unavailable. The contact called the local dealer who stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified however, no further assistance was provided. The failure mileage was approximately 17,000. Parts distribution disconnect.
The contact owns a 2011 BMW R 1200 RT. The contact received notification of the federal safety agency campaign number: 20V471000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
Throttle cable bell cranks/cams crack due to poor quality plastic material. This causes motorcycle to suddenly lose power as the hand throttle no longer works and engine returns to idle RPM. This is a serious safety hazard as failure can occur while entering traffic, turning thru traffic, or traveling on a high speed roadway with no area to pull off. These cracks, (and impending failure of the parts), were discovered by service personnel during service work.
Tengo problemas con el fuel pump liquea mucho y tambien con el encendido los calipers se atoran
Spontaneous development of a copious fuel leak after starting bike, subsequently found to be originating from fuel pump around high pressure fitting. Very dangerous scenario, as fuel drips close to hot engine. I asked around and apparently is not an uncommon issue. Hard to believe there has not been a recall on this.
Fuel pump leaks at high pressure fuel line. This fuel leaks over exhaust pipe and is a potential fire hazard.
Questions about the 2011 BMW R1200 RT fuel system
Does the 2011 BMW R1200 RT have fuel system problems?
Owners have filed 16 complaints about the fuel system of the 2011 BMW R1200 RT, 80% of all its complaints, more than any other problem.
At what mileage do 2011 BMW R1200 RT fuel system problems start?
The typical (median) mileage in owner complaints is 31,588 miles.
Was there a recall on the 2011 BMW R1200 RT fuel system?
Yes, 3 recalls: 21V060000, 20V471000, 13V617000. Check your VIN to see if your car still needs the free repair.
What year does the BMW R1200 RT have the most fuel system problems?
The BMW R1200 RT model years with the most fuel system complaints are 2007 (37 complaints), 2006 (30 complaints) and 2005 (22 complaints).
Other 2011 BMW R1200 RT problems
Acceleration 2Electrical 2Engine 2Lights 2Suspension 1Transmission 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2011 BMW R1200 RT?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history