BMW R1200 RT fuel pump problems

Filed Aug 20, 2025 · Fuel system · CA

This vehicle was subject to a recall under bulletin 16 0114. The issue was a fuel pump which cracked at flanges which leaked fuel onto the hot engine, which could cause safety issues with fire. My vehicle listed above, had the fuel pump replaced with 12,505 miles on it under the recall. The replacement fuel pump, which is apparently no better than the original that was replaced under recall, cracked again leaking fuel onto the hot motorcycle engine. This happened with 20,300 miles on the vehicle, which is less than 8000 miles later. BMW is refusing to replace under the recall or a warranty the fuel pump which means I am stuck with the bill. I believe that BMW should be replacing a defective part with a new design and better part not an old design faulty part. I would encourage you to issue another recall on the vehicles in question under bulletin 160114 in the interest of motorist safety.

Filed Mar 25, 2023 · Fuel system · IL

2005 BMW r1200rt that I have owned since 2016 with little to no issue. Leak from winter storage in the front left side of the engine. It matches a thread of a cracked fuel pump. With your site they submitted the problem under JBN1-18051. Also under a complaint number 10428629. I wish to know if it is a issue that is a recall or something I can submit for BMW to take care of, or if I will need to get fixed myself. I saw that riding with it can result in fuel landing on the ride during transit making it dangerous to ride.

Filed Dec 2, 2022 · Fuel system · AZ

The OEM plastic 90° quick discount fitting on top of the fuel pump started spraying fuel. I started smelling fuel on the interstate highway 10 and by the time I could pull over safely off the interstate I was covered with fuel. The fuel was running down on the hot exhaust pipe’s on the front left side of the motorcycle and spraying all over my face and legs. I could have been set on fire and burnt to death because of where the fuel was spraying from. This also could have cost the lives of the people on the interstate had i burst into flames and lost control of the motorcycle. When I called the BMW dealership in Tucson AZ the service tech told me that they had a medal aftermarket 90° fitting that would fix my problem. I replaced the fitting and the fuel leak was fixed. This motorcycle fuel pump was replaced 07/01/2014 at mileage 12,482 because of a fuel leak recall. I’m filling this report because this fitting fail happened without warning 15,700 miles after the fuel flange recall. This must be a common problem for the service tech to know over the phone the fox and have a aftermarket medal part that fixed the fuel leak. The location of this potential leak makes it extremely dangerous hazard.

Filed Sep 7, 2022 · Fuel system · AZ

Development of a major fuel leak after starting motorcycle, leak is coming from the high pressure fitting on the fuel pump. Very dangerous as the fuel is dripping on the hot exhaust and pooling on top of the fuel pump. Risk of fire and possibility of fuel getting on pant leg and burning riders leg. I talked to a couple dealers in the Phoenix area and it’s more common than not.

Filed Sep 28, 2021 · Fuel system · 52,000 miles · MD

The contact owns a 2005 BMW R 1200 RT. The contact stated while starting the motorcycle and it began to stall. The contact stated no warning light was illuminated. The motorcycle was not drivable. The motorcycle was towed to an independent mechanic and the contact was informed that the fuel pump needed to be replaced. The motorcycle was repaired. The contact stated that on 7/2021, he noticed fuel leaking from the fuel pump onto the engine. The contact called the local dealer and made them aware of the failure. The motorcycle was not repaired but was pending repairs. Upon investigation, the contact associated the failure with the federal safety agency Campaign Number: 13V617000 (Fuel System, Gasoline) however, the VIN was not included. The manufacturer had not been informed of the failure. The failure mileage was approximately 52,000.

Filed Jun 12, 2021 · Fuel system · MI

A fuel leak around at the fuel pump flange. Leaking around the support ring installed by the previous remedy. I contacted a dealer several times, but they have been unable to remedy due to no parts since April 2021. I also contacted [email protected] and they said "at this time the remedy for the recall: 20V‑471 is available; however, the parts are on backorder for all models. We currently don't have an eta we can provide." BMW has failed to prepare sufficient replacement parts and they are unable to remedy for 20V‑471 in a timely manner.

Filed Apr 30, 2021 · Fuel system · OK

Bmw have recall campaign no. 20v‑471: fuel pump. The dealer in my area (5th gear cycle 1200 w sw expy dr, broken arrow, ok 74012) is not able to schedule service before end of july. Bike currently is unusable as fuel drips over the exhaust.

Filed Sep 19, 2020 · Fuel system · 65,600 miles · IN

I have a 2010, r1200rt motorcycle that is spraying large amounts of atomized gas out from the top of the plastic fuel pump housing from a hairline crack near the high pressure outlet. The housing is a non wear part. In looking at the recalls I see that on december 12, 2013 there was a recall campaign (the federal safety agency # 13v617000) on fuel leaks for my motorcycle that describes my issue exactly. I requested that bmw take action and fix the problem free of charge. They have refused. I believe that their scope analysis of the vins with this problem was too narrow. I see that I will now be the 4th complaint filed this year and is a pattern that needs addressed. When this happens, there is a very dangerous situation of a fire developing while people are driving or stopped. This is not a situation where someone can separate themselves from the flash fire while driving. It's effects (burns, losing control) are instant to the motorcycle driver.

Filed Sep 14, 2020 · Fuel system, Lights · 37,000 miles · CA

Tengo problemas con el fuel pump liquea mucho y tambien con el encendido los calipers se atoran

Filed Jun 16, 2020 · Fuel system · 37,500 miles · IL

Spontaneous development of a copious fuel leak after starting bike, subsequently found to be originating from fuel pump around high pressure fitting. Very dangerous scenario, as fuel drips close to hot engine. I asked around and apparently is not an uncommon issue. Hard to believe there has not been a recall on this.