2008 BMW X3 engine problems

Filed Mar 18, 2026 · Electrical, Engine · AK · fire

I am reporting a vehicle fire involving my 2008 BMW X3, which had an active safety recall for the Positive Crankcase Ventilation (PCV) valve heater (Recall Campaign No. 22V‑119). This recall identifies a risk of short circuiting, overheating, and potential fire. On February 27, 2026, I contacted BMW after discovering multiple active recalls on my vehicle. I specifically asked whether the vehicle was safe to drive. After consulting internally, I was advised that I did not need a tow and that the vehicle was safe to drive. Based on this guidance, I scheduled a repair appointment for March 24, 2026. On March 14, 2026, before starting the vehicle, I noticed a very faint smell of burning plastic, which I reasonably believed was coming from a nearby source and not from my vehicle. After starting the vehicle and driving approximately 2–3 blocks, the smell rapidly intensified and began filling the interior. Multiple dashboard warning lights illuminated, and the vehicle lost acceleration almost immediately. I safely pulled the vehicle off the road, turned it off, and opened the hood, at which point I observed smoke and active fire originating from the rear/center area of the engine compartment. I immediately called 911, and the Central Mat-Su Fire Department responded and extinguished the fire. The vehicle sustained extensive fire damage and has been deemed a total loss. I am concerned that despite a known recall involving fire risk, I was advised that the vehicle was safe to drive, which may have contributed to this incident. There were no indicators of any problems prior to driving it and the dashboard only lit up seconds before the vehicle stopped moving and caught fire. It has not been inspected by anyone but I have it covered on my property to preserve the evidence. I am waiting to receive the fire department report and can provide that once it’s available.

Filed Mar 12, 2024 · Engine · MA

The car no longer starts. When towing it to a BMW dealership, they informed me that there is a problem with the VANOS bolts and that "they snap easily"; however after some research into it I realized that these engines have a recall for this specific issue only that my vehicle isn't listed under the recall. I believe this is a mistake and that it should be.

Filed Feb 29, 2024 · Engine · 200,000 miles · RI

The contact owns a 2008 BMW X3. The contact stated that while driving at 20 MPH in cold weather, there was smoke coming from the engine compartment. There were no warning lights illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted; however, the contact received no response. The contact stated that the failure was related to the federal safety agency Campaign Number: 22V119000 (Engine and Engine); the VIN was included. The failure mileage was approximately 200,000.

Filed May 12, 2023 · Engine · 180,000 miles · PA

The contact owned a 2008 BMW X3. The contact stated while driving at an undisclosed speed, he turned on the heater and became aware of smoke coming from under the hood of the vehicle. The vehicle then started to overheat, and the coolant temperature warning light and the check engine warning illuminated. The contact stated that he veered off the road and turned the vehicle off. The contact then stated that he waited a few minutes and allowed the engine to cool down. Additionally, the contact stated that he added water to the radiator after the engine had cooled down. The contact then stated that he restarted the vehicle and while driving, he noticed smoke coming from under the hood of the vehicle before the vehicle stalled. The vehicle failed to restart. The vehicle was inspected by an independent mechanic where the contact was informed that the engine failed and needed to be replaced. The vehicle was not diagnosed nor repaired. The contact stated that after several attempts to repair the vehicle, the vehicle was then towed away and disposed. The contact then stated that six years later he received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) however, the dealer nor manufacturer was notified of the failure. The failure mileage was approximately 180,000.

Filed Feb 28, 2023 · Engine · MA

The contact owns a 2008 BMX X3. The contact received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The local dealer was notified of the issue and confirmed that parts were not yet available for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

Filed Nov 18, 2022 · Engine · NV

The contact owns a 2008 BMW X3. The contact received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was unavailable. The contact stated that the dealer was contacted and stated that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed Nov 10, 2022 · Engine · 115,000 miles · CA

The contact owns a 2008 BMW X3. The contact received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling). The contact stated that after attempting to turn on the heat, the heat failed to properly operate. The contact stated that the heat was either too low or too hot. The contact was concerned that the system would overheat. No warning lights were illuminated. The dealer was notified of the failure and the contact was informed that parts were not available for the recall repair. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer exceeded a reasonable amount time for the recall repair. The local dealer was made aware of the issue and confirmed that parts were not yet available for the recall repair. The manufacturer was not notified of the failure. The failure mileage was approximately 115,000. VIN tool confirms parts not available.

Filed Nov 3, 2022 · Engine · 78,000 miles · GA

The contact owns a 2008 BMW X3. The contact stated while driving 30 MPH, the engine was shutting off inadvertently. Several unknown warning lights were illuminated. Additionally, the contact stated while driving at an undisclosed speed, the vehicle stalled in the middle of the road. The contact was unable to veer to the side of the road. The contact was able to restart the vehicle after several attempts. The contact drove back to her residence. The contact stated that the failure had been reoccurring while driving. The contact later received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The local dealer was contacted several times and informed the contact that parts were not yet available. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The failure mileage was approximately 78,000. VIN tool confirms parts not available.

Filed Oct 26, 2022 · Engine · 169,935 miles · TX

The contact owns a 2008 BMW X3. The contact stated while driving 25-30 MPH, he smelled a burning odor and saw smoke coming out from underneath the hood. The contact veered to the side of the road and allowed the vehicle to cool down. The contact was able to continue driving. The contact stated that the failure had been reoccurring. The vehicle was taken to several independent mechanics who informed the contact that they could not duplicate the failure. The contact later received notification of the federal safety agency Campaign Number: 22V119000 (Engine and Engine Cooling) that he associated with the failure; however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and referred the contact to the dealer. The failure mileage was approximately 169,935. VIN tool confirms parts not available.

Filed Aug 10, 2022 · Engine · 170,000 miles · CA

The contact owns a 2008 BMW X3. The contact stated when she picked up her vehicle from the dealer after having the federal safety agency Campaign Number:17V683000 (Engine And Engine Cooling) completed while driving at 40 MPH, the vehicle started overheating. The contact was able to pull over and when shutting off and attempting to restart the vehicle, the vehicle would not start. The dealer was contacted, and they stated the vehicle needed to be diagnosed. The manufacturer was contacted, and they also stated the vehicle needed to be diagnosed. The failure mileage was 170,000