2018 BMW X5 electrical problems

Filed Sep 18, 2026 · Electrical · CA · fire

Two incidents accured with 24hrs. My wife called me informing that the 2018 x5 was smoking from the front and making a weird noise, she stopped the vehicle and the vehicle started again. When she got home, I checked the under the hood, but could not see anything. But, can smell like burned wiring, but not visible. I connected EV wire to the vehicle and next morning disconnected the cable and when I started the vehicle, I saw smoke coming out of the inside bottom of the rear where the batteries are located. I opened the rear door and raised the cover to see smoke coming from melted wiring. I immediatelly disconnected one of the battery wires.

Filed Apr 30, 2026 · Electrical, Engine · VA

On March 9, 2026, I brought the vehicle to BMW of Fairfax for a scheduled appointment. In the week leading up to the visit, the vehicle intermittently failed to start and required jump-starting using a portable battery starter. Despite this issue, the car drove normally, showed no warning lights or error messages, and had approximately 69,000 miles on the odometer at the time. After jump-starting the vehicle, I personally drove it to the dealership. I paid for a diagnostic evaluation and also authorized completion of a minor recall. Two days later, I was informed that the vehicle was no longer able to shift into gear and was now completely inoperable. I was told I would be responsible for towing the vehicle off their premises. According to the service department, the vehicle now requires replacement of the EME module, at an estimated cost of $12,000. This assessment was particularly troubling because the vehicle was fully drivable when it arrived at the dealership. At no point prior to service did the car have difficulty shifting into gear. It is deeply concerning that the vehicle became a “brick” while under the care of an authorized BMW service center, with no accountability taken for what occurred during their diagnostic process.

Filed Feb 17, 2026 · Electrical, Engine · TX

Vehicle: 2018 BMW X5 xDrive40e Recall: the federal safety agency Safety Recall 24V‑608 Complaint Description: My 2018 BMW X5 xDrive40e experienced a sudden Electric Motor Electronics (EME) failure that rendered the vehicle inoperable. This occurred before the recall remedy for the federal safety agency Safety Recall 24V‑608 was completed. It is available for inspection upon request. Recall 24V‑608 addresses fluid intrusion into the electric coolant water pump electrical connector, which can cause electrical shorts, overcurrent conditions, and power instability. The EME is directly dependent on stable electrical conditions. After the vehicle failed, the recall repair was performed; however, completion of the recall does not reverse electrical damage that may have occurred prior to the repair. Prior to the EME failure, I made multiple attempts to have the recall addressed by contact BMW authorized dealers, but the recall condition remained unresolved. Following the failure, BMW of North America denied responsibility in writing, closed my case, and did not identify any alternative root cause or provide technical findings explaining the EME failure. The vehicle is not drivable and requires approximately $12,000 in repairs. I also incurred rental vehicle expenses as a result of BMW’s refusal to repair. This appears to be recall-related electrical damage affecting a critical control module, creating a safety concern due to sudden loss of vehicle function putting safety of myself and others at risk. I am submitting this complaint to document a safety-related electrical failure associated with Recall 24V‑608 and BMW of North America’s refusal to remedy the resulting damage.

Filed Oct 16, 2025 · Electrical · GA

I replaced an Electric Auxillary Heater on my vehicle in 2024 part that was subsequently offered an warranty extension on 8/1/2025 by BMW in Service bulletin SIB 01 10 25. The bulletin had a provision for customer reimbursement of repairs and they are refusing to honor my claim. I think they should be forced to place this part into a recall by the federal safety agency. These vehicles are lemons. A High Voltage AC compressor, Electric Auxillary Heater Issues, High Voltage power supply cables, Turbocharger, Electric Suspension compressor, Air suspesion Springs, Evaporative Emissions Purge Valve all had to be replaced before the vehicle hit 90,000 miles.

Filed Jun 9, 2025 · Electrical, Engine · VA

The contact owns a 2018 BMW X5. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed May 7, 2025 · Electrical, Engine · CA

The contact owns a 2018 BMW X5. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed Apr 17, 2025 · Electrical, Engine · NJ

The contact owns a 2018 BMW X5. The contact received notification of the federal safety agency Campaign Number: 24V608000 (ENGINE AND ENGINE COOLING, ELECTRICAL SYSTEM); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed Apr 14, 2025 · Electrical, Engine · CA

The contact owns a 2018 BMW X5. The contact received notification of the federal safety agency Campaign Number: 24V608000 (Engine and Engine Cooling, Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

Filed Mar 24, 2025 · Electrical, Engine · NJ

BMW issued a recall in October 2024 regarding the engine coolant pump electrical connector on my 2018 BMW X5 xDrive40e, warning of electrical shorts and fire risks. It's now late March 2025—approximately six later—and BMW dealerships still state explicitly they have no available remedy and no timeline for repair. Recently, my vehicle showed a drivetrain warning message, which I suspect is recall-related. I called BMW corporate recall hotline and my local BMW dealership (BMW of Tenafly) today (March 24, 2025). The dealership explicitly stated that they can only perform diagnostics, and even if their diagnostics confirm my drivetrain issue is recall-related, they 'cannot do anything' due to BMW's lack of available recall remedy. When I expressed concern to BMW of Tenafly representative that this recall involves serious safety risks (electrical shorts and potential fire), the dealership representative dismissed my concern by simply saying, 'every recall is urgent.' This response underscores my concern that BMW and its dealerships are not treating this recall issue with adequate seriousness or urgency, leaving consumers like myself at ongoing safety risk. They also mentioned charging $150/day storage if I leave my vehicle at their facility beyond diagnostics, which discourages vehicle owners from having their recall-related safety issues adequately addressed. I’m escalating to the federal safety agency now because BMW has not provided a recall remedy within a reasonable period, and I'm concerned about ongoing safety issue.

Filed Sep 3, 2024 · Electrical · PR

EME (ELECTRONIC MOTOR ELECT.) The vehicle is already at the service department of BMW in Puerto Rico. According to them, there was an EME failure. The warranty says the electrical system is covered under a warranty of 8 years or 60,000 miles. Neither of them has passed. The service department says the warranty is on the main battery, but the EME is part of the electrical system. They want to charge almost 20,000 for the replacement and adjustment of the system. This statement is unacceptable. It would put this vehicle which has been jealously taken care of in a total loss condition. It still owed 25000 dollars and the repair cost 20,000. It does not make sense and is not the only one with this situation. The problem is that it died in the middle of the road, Luckily there was not much traffic. It is very dangerous if it happened on the freeway, it could have caused a very bad accident. BMW should be liable for this damage and a recall should be performed.