Coolant line rubbed up against the engine block and wore a hole in it. The new line has been redesigned to avoid the contact. The windshield wipers intermittently stops and has happened at least 15 times. The fuel gauge stopped working, reads full for 20 minutes then slowly comes down, dealer replaced the tank gauge
1997 Chevrolet Astro engine complaints
Page 2 of 2: complaints 11 to 37 of 37, newest first, as owners wrote them.
Chronic engine knock that is normal.
Consumer states while driving, electrical system failed and vehicle ceased as battery ran down, replaced alternator and ignition coil and wire.
While driving battery light came on. Problem was due to 'belt tensioner breaking. Consumer was driving at approximately 10 - 15 MPH. Please provide any additional information.
Driver's side rear window will not stay open, clips that should hold it up are blocked by material, window slams shut when going over a bump. Transmission went out at 45000 miles. *ak oil leak, dealer ordered axle output shaft seal and crankshaft sensor. Electric fuel pump replaced due to vehicle cutting and would crank, but would not star. Oil pressure gauge erratic, dealer replaced oil pressure sender. Front brakes and pads were replaced, rotors were resurfaced. Consumer states there is play in the steering, dealer replaced both idler arms and reset toe in. Power door locks inoperable, dealer replaced power door lock switch. Power window inoperable, dealer replaced power window switch. Shifter was hard to move, dealer replaced shift cable. Gas pedal binds at times, dealer ordered throttle cable and replaced accelerator cable. Driver seta seems loose when braking, dealer ordered driver seat track assembly and replaced driver seat adjuster. Pcm fuse kept blowing out, dealer removed engine cover and traced wire harness, repaired shorted harness at the rear of the transmission.
While driving about 70 MPH engine was making noise. Power steering and power brakes were affected.technician said that problem was with idler pulley and tension pulley.*ak after explosion like sound under the hood, the tensioner pulley disintegrated causing loss of power steering and power brakes.
Every thousand miles, service light comes on and vehicle runs very rough, jets have been cleaned 4 times on the engine. Dealer was blaming it on chevron gas. Chevron has sent a letter stating it was the poppet valve. Delaer changed all 6 poppet valves and cleaned the fuel intake system, and it worked for 5 months. Problem has come up again.
Occurance 1) engine stopped without warning while approcahing an intersection. The resulting loss of power caused a severe control problem with the van. The reason for the failure was the fuel guage read 3/4 and the van ran out of fuel. Occurance 2) the fuel guage has totally stopped functioning, after topping off and proceeding onto highway I drove for 1/2 hour at 65, a sudden slam occured 2 or three times, appeared to be the engine cutting in and out, slowed to 55 and continued for 150 miles without further incident. Occurance 3) vehicle has no fuel guage, I am told it's out of warranty, even if full the vehicle seem to loose control momentarally, as if to loose power.
Vehicle is leaking anti freeze between the head gasket and the engine due to defective casting.*ak tires were showing heal and toe wearing. Dealer offered to prorated tires but customer declined.
Fast engine idle, intermittant, high ambient temp. No "chk eng" or "stored codes" van will intermittantly accellerate to 45 to 62 MPH with no pedal. Several near accidents. Frequently must use brakes or low gear to hold 45-55 MPH dealers make excuse over warranty while admiting it is a safety problem, but no real interest from several levels of mgmt. 3 yr problem, dealer serv has only seen malfunction once with computer tool pluged in but said "no problem indicated" while seeing the fast idle. Can I get an incident number to take to the dealer?
Was coming to a stop light & started to apply brakes, and brake pedal went to the floor. Had no brakes. Did not hit anything. Had vehicle towed to dealer. Mechanic indicated that egr valve was opened due to carbon built up. Brake problem could be repaired, but could also reappear.
As you can see, I have had numerous problems with this van. The dealer nor chevrolet have offered any assistance saying that after 36,000 miles they are not responsible. Obviously, there is something wrong with this car. I am a single mom and I cannot pay my car payment plus repairs every month. I cannot trade it in because I owe too much on it. If I turn it in, I do not have credit to buy another car. Can you assist me in any way? No safety defect listed.
Engine has been cutting off excessively, causing a loss of power steering and power brakes. Dealer can't find the problem.
Intermittently vehicle will lose power and stop in traffic. Dealer cannot determine cause. Also, consumer noticed a white pasty fungus growing which is eating through the metal and carpet.
In oct. 1997 when starting to drive transmission slips, feels like van has been hit from behind. Dealer replaced valve body,due to a known product problem.van once again had same troble in may 2000, dealer changed valve body, also statede becaused of a known product concern. But tjis time I had to pay $672.06. Their customer service was of no help. Even though their mechanic stated that gm had said to reploace the valve body the second time with a new design, since the first replacement was defective.
Vehicle would be running rough & would shake. Took vehicle to dealership & was informed by mechanic the jets on engine were plugged up. This was caused by the gasoline & could be repaired.
Trim on two rear bench seats fell off which was replaced.
4 of 6 cylinders less than 150 psi. Only check engine light came on. Dealer , chevrolet, and extended warranty service refuse to honor any discounted or warranty on this engine that was maintained through the dealership.
Fuel tank and gauge failed.
Engine valve seal failed causing valves to stick which resulted in excessive engine noise.
Consumer was driving at 35 MPH when he smelled smoke, and pulled over to exit. The doors and windows would not open. Consumer hit the glass with his shoulder and hand to get out, but then he had to break the glass to exit. Notice light coming from the tires on the driver's side, and then saw that the vehicle was on fire. Fire department came out to put out the fire. Contacted the dealer to fix the vehicle.
Vehicle has an ongoing stalling problem. Vehicle been in/out of dealer shop on nine occasions, and the problem cannot be found for repair. *ak
Wife was driving when vehicle caught on fire. Was told of this by a passing motorist- driver was traveling about 75mph.
When the vehicle dies out there is no stopping abilitiy, when driving at 30mph vehicle dies, no steering capability, no notification or warning. Dealer contacted and cannot duplicate the problem.
Accelerator pedal sticking if ignition is on or off due to failed throttle body unit.
While traveling the vehicle would shut down without indcatons. Dealer was contacted. Please provide further details.
While driving, the serpentine belt broke, causing the vehicle to lose brakes and power steering. Please describe details.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Chevrolet Astro?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history