At 43,659 miles vehicle experienced an ongoing probelm with engine stalling due to carbon build up in egr valve. Vehicle taken in, dealer would only clean valve, and problem would continue to reoccur . Also, at 64,000 mile vehicle experienced a problem with starting. Dealer notified ,informed consumer that problem was due to a fuel line failure. Please feel free to provide any further details on this matter.
1994 Chevrolet Blazer engine complaints
Page 2 of 3: complaints 11 to 40 of 42, newest first, as owners wrote them.
The wrong size vacuum line installed on actuator which caused the cruise control to not work properly.
Egr valve cleaned at one dealer, replaced at another within 3 weeks. Cost of close to $1000 to do.
Driving along at 65 all 4 times. Go to depress gas pedal and car would not respond as if there was a dead zone. No warning lites would come on. Car would not stall until come to stop. All electrical still working. Engine would run until out of gas.then stall. Turn car off, wait a few minutes, then car would start and run fine
While driving vehicle would be missing/backfiring and blowing black smoke. Went to emission control inspection, and vehicle didn't pass. Also, fuel injection line in throttle body was a plastic line and it split. Filled up fuel injection system with gasoline. If there was a spark, vehicle would catch on fire. In addition, replaced catalytic converter/o2 sensor/ radiator cap/ brake rotors, and throttle body air valve. However, vehicle was still exhibiting the same problem. Contacted dealer .
I have replaced the egr valve 3 times on this vehicle. I am having trouble with the vehicle running rough. I was told I have alot of carbon buildup around the egr ports and this is breaking/flaking off. The dealer said they would have to take the cylinder heads and intake manifold gasket and submerge in a hot tank of acid to clean the carbon off these parts. The repair quote was $1600.00 and there was no quarantee how long this would take care of the problems I am having with this vehicle.
Egr valve reparied several times also, . Fuel pump replaced.
At highway speeds egr valve goes out, causing loss of brake power. Dealer has repaired vehicle.
Abs brakes and linear exhaust gas recirculation valve (egr valve) failed. Provide additional information.
Vehicle had rough idle, cleaned egr valve. Reoccurring problem.
While driving the egr valve is clogged with carbon deposit which causes the vehicle to cut off. When this happens consumer loses all power and control of the vehicle.
Main engine bearing spun out, that requires a new engine. Dealer was contacted, and stated that the consumer would be held liable for repairs. No explanation as to why engine failed.
Engine surges then sputters, bad odor. Engine checklight came on. Egr had been previously replaced, fix for problem is not a fix. Brakes and steering lock up when engine fails, obviously this is a known problem. A real fix needs to be had.
Fuel injection system was replaced due to a leakage. It is very hard to start vehicle. When consumer turns vehicle off it is still running; there is shaking withn vehicle, and it cuts off without prior warning. Also, there is a bad smell within vehicle due to defective exhaust system. Dealer is aware of the problems.
Ea94038; braking system malfunctioned due to a defective egr valve. Vehicle had no braking ability at all. This could have resulted in a crash. Also egr valve caused engine problems. Common problem. Please provide further information and VIN#.
Engine failed. Yh
Engine developed cracks which caused fluid to leak. Please give any further details.
While on vacation engine stalled getting off exit. Ran through intersection due to no breaks and sluggish steering. Had egr valve replaced at local garage. Same thing happend about 50 miles later. Car was towed to chevrolet dealership, connected to computer system. We were told that chevrolet's fix for this was a new computer chip (prom). The valve has not failed since. This should be a recall item. If there had been anything at the intersection we drove though, someone could have been injured. Not to mention this cost over $600.00 to diagnose and repair.
While driving the vehicle would stall without indications and lost brakes and power steering. Please provided further information.
Abs brake failure; also, left front brake caliper was hanging up, causing premature brake pad failure. In addition, vehicle caught on fire, cause undetermined.
Consumer had to replace the front braking system. Also, replaced thermostat twice.
Driving the truck onto the interstate the engine just shut down for no apparent reason, and the truck had to be towed to a dealer. *ak consumer states engine stalls at traffic lights and sometimes vehicle will not start at parking lots. Dealer can not find problem.
Eger valve became clogged, causing vehicle to lose control.
Driving 55mph when the vehicle would stall out completely, panel lights would come on before vehicle stalls or shuts down, had problem previously and delaer replaced egr valves but stalling still exists, vehicle runs rough, took back to dealer but nothing was found.*ak
When traveling at any speed the vehicle will cut of without prior warning. The vehicle has a diesel engine. Consumer has contacted the dealer, dealer has replaced the fuel injection pump with a rebuilt pump. *ak the dealer replaced the fuel injection pump with used part and the problem reoccured. The consumer had requested for new pump but the dealer did not accept it also, sevice the engine light does not appear when the vehicle stalls.
While driving vehicle the engine service light comes on. When applying the brakes it is very difficult to stop. The egr valve was cleared on 6/11/97, egr prompt on the 6/25/ and the valve replaced 8/4/97.
Engine: when driving along the engine surges into a high speed , and at times it sputters like it is going to stall. Took in for repair, and they put an egr valve, because gm says there was a problem with the egr valve. Consumer stated that gm extended warranty due this problem, also vehicle continues to exhibit engine sputter, consumer is concerned that this condition could result in injury especially in bad weather. *ak
On a 4-lane hwy and the check engine light came on , came off the hwy onto a ramp, applied ABS brakes to make a stop, the brakes did not work because egr valves failed , but there was no warning. Please give more details.
The engine light goes on and the egr valve gets clogged with carbon and when stopping the car loses power. The valve has been replaced (4) times and cleaned once.
The egr valve malfunctioned, causing the vehicle to stall and cut off, the egr has been replaced on several occasions. *ak.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Chevrolet Blazer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history