Tl* the contact owns a 1996 chevrolet blazer equipped with definity tires ex600, size 235-70-r15 (n/a). The contact stated that the vehicle was taken to a mechanic for a routine tire rotation when he was informed that the front driver's side tire belt became separated. In addition, the passenger's side rear and front tires were prematurely worn. The tires were not replaced. The manufacturer was made aware of the failure. The tire failure mileage was 50,000. The vehicle approximate current mileage was 153,000. Updated 12/18/13
1996 Chevrolet Blazer: rotors or pads wearing out early
12 of the 1,152 complaints about the 1996 Chevrolet Blazer describe rotors or pads wearing out early.
- owner complaints
- 12
- of this car's complaints
- 1%
- recalls
- 1
Is there a fix? There is 1 recall and 3 service bulletins for this area of the car. See below
Rotors or pads wearing out early by model year
What owners say
Consumer states ball joints are constantly failing. Consumer has had to replace them twice. A recall was initiated, but consumer's VIN was not included. Related recalls 01v200000 and 01i018000. *ak right front wheel fell off as a result of the faulty ball joints. There was squeaking noise on turns due to idler arm failure. Front pads worn out and rotors failed, both were replaced.
On july 18, 1999 I experienced a loss of power assisted brakes and a hissing noise coming from the master cylinder area. Vehicle was delivered to braeger chevrolet on july 19, 1999 and cause was reported as "internal vacuum leakage from booster assy h1220 booster assembly, vacuum power brake - replace 510 wpt4 1.90, 1 18029999 booster, fc: 2k, part#: 18029999". I contacted chevrolet and they covered 50% one time good will/ safety item. My cost $170.99. On august 17, 1999 I discovered a leak from the positive battery terminal which had been leaking small quanities of liquid for approximately a two month period of time on the garage floor, progressively becoming a worse leak based on the quanity of fluid found on floor. New battery was purchased on 08/21/99 and installed by myself, no further problems with leakage. Major concern follows: on nov 30, 1999 I observed a squeaking noise from the right front disc brakes and pads. On dec 01, 2000 I delivered my vehicle for a brake inspection and cause was reported as "premature wear to right front disc brakes and pads only". Brakes were serviced by machining rotors and installing new pads, and I was instucted to pay close attention to the right front disc brakes and pads in the future reference the same problem reoccurring and if this occures major front brake work would be necessary. In conclusion, I feel the premature brake wear to the right front only was caused by the battery leakage which also was located at the right front corner of the vehicle. Thank you.
I have had two major problems with this vehicle since it's purchase date. The transmission has experienced two major failures and the dealer said he replaced them both times. I have continued to experience shifting problems and occassional lockup of the transmission when shifting from park to drive. The transmission dip stick and filler tube have had to be replaced twice for rust which leads me to believe that engine cooolant is getting into the transmission fluid. The second problem is naturally the ABS brake system. This is the sorriest excuse for brakes on a vehicle that I have seen. I must almost stand on the brake pedal with excessive pressure to get the vehicle to stop. I also experienced premature brake pad wear out on the front which damage the rotors. Chevrolet refused to fix this under warranty even though the vehicle only had 20,000 miles on it. The ABS system locks up sometimes when I push hard on the brakes. I have experienced several near accidents because of the poor braking system on this vehicle. I would appreciate any help you could be to leverage chevrolet to correct these problems.
Premature wear of front pads, replaced pads and replaced left rotor & machined right. Dealership said there is no problem with the vehicle to cause early wear.
Front disc brake pad wear is excessive. Brakes squeal as if pads are constantly dragging.
Premature brake pad wear.
Brake pads wear out in 12,000 to 20,000 miles.
When applying the ABS brakes in a sudden stop, the pedal went to the floor and the brakes failed to stop the vehicle. *ak brake pads prematurely worn out and dealer replaced them and also resurfaced rotors, consumer states an accident resulted because of the faulty brakes. Rear passenger side door panel material came apart, dealer replaced.
Premature wear of front brake pads.
Equipped w/ABS brakes; left brake rotor and front pads wear unevenly, within a few months, the new right pad had worn out and in october. Master cylinder and brake booster replaced due to air heard when brakes were applied. *ak headlight cover had water in headlight. Vehicle also pulled to the right when braking.
Premature wear of anti-lock brakes, also replaced front brake pads and resurfaced rotors.
Service bulletins that may apply
Related recalls
Service brakes, hydraulic: antilock/traction control/electronic limited slip
- What is wrong
- Vehicle description: certain 4-wheel drive pickup trucks and sport utility vehicles equipped with ABS (antilock braking system) manufactured from september 1989 through august 1996. Under certain driving conditions the switch which signals the ABS system whether the vehicle is in 2-wheel or 4-wheel drive can malfunction causing increased stopping distances during ABS stops while in the two-wheel drive mode.
- Risk
- If this occurred at a time when minimum stopping distance was required, a vehicle crash could occur without prior warning.
- Remedy
- Dealers will replace or repair the 4-wheel/2-wheel drive switch.
Recall number 99V193000 · Recall details
Questions about the 1996 Chevrolet Blazer premature wear
Is rotors or pads wearing out early a common problem on the 1996 Chevrolet Blazer?
12 of 1,152 owner complaints about the 1996 Chevrolet Blazer (1%) mention rotors or pads wearing out early. The model year with the most reports is 1995.
Is there a recall or service bulletin for this on the 1996 Chevrolet Blazer?
There is 1 recall and 3 service bulletins for the same area of the car. Check them below with your VIN.
Other symptoms on the 1996 Chevrolet Blazer
ABS 173Wipers 140Brake failure 132Ball joint 111No deployment 43Grinding brakes 28Overheating 18Fire or smoke 17Transmission failure 15Seat belt 12Headlights 11Stalling 11Power steering loss 10Fuel pump 9Slipping 9Fuel smell 8Loss of power 8Engine failure 7Harsh shifting 7Sudden acceleration 7Spongy pedal 6Pulling 6Check engine light 5
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Chevrolet Blazer?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history