2022 Chevrolet Bolt EV fuel system problems

Filed Jan 12, 2026 · Acceleration, Fuel system · MA

I was driving on the highway above 60 mph, and I suddenly got a "propulsion power reduced" alert, along with a yellow indicator light. I almost immediately thereafter got a message saying "speed reduced to 50 mph" and then "speed reduced to 30 mph." I got no acceleration when I depressed the accelerator pedal. In fact, it felt like the car had engaged the regenerative braking to actively slow me down. This is a life-threatening safety flaw, as it was difficult to get to the breakdown lane. The only reason there was no collision was that there was relatively light traffic. I managed to get to a breakdown lane and then, after restarting the car, to get off the highway and into a parking lot, where I called for a tow. The car was towed to the dealer I bought it from and, the next day, they inspected the car and determined that the auxiliary transmission fluid pump had failed and needed to be replaced. I've seen many reports on reddit that this part fails on chevy bolts. What makes this truly unsafe is that there was no warning whatsoever that something was wrong. Everything seemed fine (after I got a new battery under the big bolt battery recall) until the car suddenly cut power and slowed me down in the middle of the highway. This car needs to be recalled again.

Filed Aug 28, 2025 · Fuel system · OH

I am filing this complaint regarding my 2022 Chevrolet Bolt, which has been awaiting battery replacement at McCluskey Chevrolet for over 30 days, creating significant safety concerns and violating federal warranty requirements. Safety Concerns: The vehicle's safety systems detected a battery defect serious enough to automatically restrict functionality. This demonstrates GM recognized an immediate safety risk. Despite this urgency, my vehicle remains inoperable after 30 days with no completion date provided. This delay indicates systemic failures in GM's remedy program for known battery defects. GM has known about this issue for years and has yet to source replacement batteries within a reasonable timeframe for drivers awaiting a replacement. Federal Law Violations: This situation violates the Magnuson-Moss Warranty Act, which requires warranty repairs be completed within a reasonable time period. Thirty days for a safety-critical component replacement, particularly after the vehicle self-diagnosed a dangerous condition, exceeds any reasonable standard. Requested the federal safety agency Actions: Investigate GM's compliance with recall remedy requirements and parts availability Assess whether GM's battery replacement program meets federal safety standards Determine if GM is violating the Magnuson-Moss Warranty Act through excessive repair delays Consider enforcement action to ensure timely remediation of safety defects Require GM to provide loaner vehicles during extended safety-related repairs Documentation Available: I request the federal safety agency's immediate intervention to address both the individual and systematic failures of GM in handling these repairs.

Filed Oct 4, 2023 · Engine, Fuel system · CA

Vehicle stopped while driving down the road lost power threw up multiple codes and was stuck in the middle of the roadway!

Filed Oct 10, 2022 · Electrical, Fuel system · VA

Around 5 PM on 10/7/22 I was driving on Purcell Road in Manassas VA. The car has a 60% charge on it EV battery showing a range of around 170 miles. As I was driving I felt the Chevrolet Bolt stutter twice, as if it was loosing power. Then, when I stopped at the stop light at Purcell and Hoadly the car shifted into park and would not shift into any other gear, including neutral. Any attempts to shift would give an error warning "Conditions Not Correct for Shift" In addition to being unable to move the car out of the intersection, the car could not be shut down. Pressing the power button would make the screen flicker for a moment and then it would power itself back on with the same "Conditions Not Correct for Shift" error. Onstar was called about the problem and shortly after the police arrived to tow the car. The car was a traffic hazard since it could not be put into neutral to get it out of traffic. The car was taken to Lindsay Chevrolet Service Center (15605 Jefferson Davis Hwy, Woodbridge, VA 22191) for diagnostic and repairs. They have reported that the problem was a wiring harness.

Filed Sep 21, 2022 · Electrical, Fuel system · WI

I was driving the vehicle approx 35mph on a surface street when it suddenly lost propulsion. There was no warning. The display suddenly showed 0 rand and 0% high voltage battery SOC. I had to cross multiple lanes of rush hour traffic with no propulsion to coast to a stop. Once parked the vehicle would not go in gear and would not move. It was towed to a dealer where a blown manual service disconnect lever (high voltage battery fuse) was found to be blown. The dealer determined the root cause to be a faulty level 2 charging station I used earlier in the day. After contacting the charging station vender there was no fault found with the station and no other complaints filed with its operation. The fuse blew 6 miles after being charged, not while it was charging. I asked for the dealer to contact Chevrolet engineering and they declined. I contacted Chevrolet customer service and was not able to speak with anyone that is familiar with their EV products.

Filed Aug 17, 2022 · Fuel system · CA

Vehicle will not charge passed 30%, receiving a reduced propulsion reduced message. Code P0BBD. Also No air conditioning. GM is holding the car till there's a fix and they have NO ETA and NO communication about an ETA. I'm irate and need my car back yesterday.

Filed Jul 28, 2022 · Fuel system · TX

As I drove my brand new 2022 Bolt (in use 30 days) into garage, the dash check engine light came on with a notice "reduced power propulsion." The battery was at about 50%. I tried to charge it and the dash indicated "charge complete." The reduced power propulsion message is concerningly similar to the error from the previous Bolt recalls that have resulted in fires. I took the car to my dealer and they have had it for 40 days and counting and say they don't know when it will be fixed nor do they know yet how to fix it.

Filed Jul 18, 2022 · Electrical, Engine · MI

General Motors is making brand new Bolt ev/Euvs using batteries that are supposed to be used to fix cars that could potential catch fire. They stated that the old vehicles effected by the recall would be given priority. I have had a bolt EUV on reserve that has been waiting on a battery replacement for over a year. GM will not inform me or the dealership of when it might be repaired. Concurrently GM is making and selling new bolts that use the battery pack that could be used to fix the old bolts. It is criminal that they would allow dangerous vehicles to remain in public while they make brand new vehicles for profit using the part that could fix every single old vehicle. Based on GMs public response to the matter they are false advertising their response to “prioritize cars” that are already made that are faulty. Instead they are prioritizing new cars while leaving thousands of hazardous cars in dealer lots and on the street. If GM can make new batteries for new bolts and sell them then they can take care of the recall. I have had extensive conversations with several dealerships confirming that GM is shipping them new bolts while allowing defective bolts to sit for over a year. I have had conversations with GMs concierge desk where they confirm the same behavior. These actions by GM are fraudulent, dishonest, and a danger to the public.

Filed Jul 18, 2022 · Electrical, Engine · MI

General Motors is making brand new Bolt ev/Euvs using batteries that are supposed to be used to fix cars that could potential catch fire. They stated that the old vehicles effected by the recall would be given priority. I have had a bolt EUV on reserve that has been waiting on a battery replacement for over a year. GM will not inform me or the dealership of when it might be repaired. Concurrently GM is making and selling new bolts that use the battery pack that could be used to fix the old bolts. It is criminal that they would allow dangerous vehicles to remain in public while they make brand new vehicles for profit using the part that could fix every single old vehicle. Based on GMs public response to the matter they are false advertising their response to “prioritize cars” that are already made that are faulty. Instead they are prioritizing new cars while leaving thousands of hazardous cars in dealer lots and on the street. If GM can make new batteries for new bolts and sell them then they can take care of the recall. I have had extensive conversations with several dealerships confirming that GM is shipping them new bolts while allowing defective bolts to sit for over a year. I have had conversations with GMs concierge desk where they confirm the same behavior. These actions by GM are fraudulent, dishonest, and a danger to the public.

Filed Jun 12, 2022 · Acceleration, Engine · GA

Euv service soon light came on followed by a propulsion reduced message. Speed was limited and air conditioning was warm. While parked the euv made a pulsating clicking noise. Euv would not go through charging procedure. Euv gave a change complete message with only 81 miles on the display