1994 Chevrolet C2500 fuel system problems

Filed Dec 23, 2011 · Engine, Fuel system · 259,856 miles · VA

While driving on I-95 in my 1994 chevrolet c2500 with the 6.5 l naturally aspirated diesel, my truck suddenly stalled and I lost all my engine powered components (power steering, brakes, etc.) I pushed on the brake pedal very hard but was barely slowing down. I finally got the truck slowed down enough to get off on the shoulder of the freeway. I then had to sit there for 30 minutes to allow the pump mounted driver to cool down before I could turn around and garage my vehicle. It happened several (5-10) times over the course of a 30 mile trip. I have seen many instances of the same thing happening to other 6.5l diesel owners. This is unacceptable. Something needs to be done about the pump mounted drivers (pmds) on this engine. They overheat and cause the engine to fail. I will be replacing the pmd on my engine and that will take care of the problem. This could have caused a major accident if I would have needed to brake suddenly while my engine was stalled. It

Filed Nov 19, 2001 · Fuel system · IA

On several occasions, vehicle will shutdown without prior warning. Consumer took vehicle to dealership. Mechanic put in a new fuel injector. *ak consumer believes this part is under recall and is requesting reimbursement.

Filed Nov 17, 2000 · Fuel system · AL

Injector pump cuts out at 55-70mph also shuts off when turning sitting still will die this is a safty problem .every one I talk to has problems with injectors also cheverolet amitt.problem I have 4 put on still having problems.it will happen when I am turning in front of traffic.please help to stop injuries or death if not already happen.

Filed Jul 14, 2000 · Fuel system · RI

While driving or just when the engine is on fuel injection pump will stop working and vehicle will stall, causing loss of steering and brakes. Fuel injection pump has been replaced 3 times. *ak

Filed May 9, 2000 · Electrical, Fuel system · TX

Fuel system was cutting off during drive. Taken in and worked on by dealer. Real axle seals have been replaced 2/3 times (97/99). Driver's seat has separated from the frame. Battery/alternator malfunction recently. Will be taking in vehicle to dealer about seat and battery/alternator situation this week. I just have to get the batteries recharged enough to get the truck started. Just had all 8 glow plugs replaced end of nov 1999 right after the warranty completed.( dot number: ad11c98356 tire size: lt 245/75r )

Filed Nov 15, 1999 · Fuel system · AL

Due to defective fuel injector pump vehicle stalled unexpectedly which may resultin a crash. Dealer replaced fuel injector pump twice. Common problem. Please provide further information.

Filed Nov 13, 1999 · Fuel system · AL

Injector pumps failure, pump has gone out while turning and at all speeds every one I talk to has had pump problems several times could cause injury or death. Gm has a problem with them, all the mechanics at several dealers said the have problems please check this out. Ak

Filed Nov 10, 1999 · Fuel system · AL

Injector pumps are defective, the injectors have gone out without warning several times while turning in front of traffic and the engine dies.

Filed Oct 28, 1999 · Fuel system · CA

While driving down fuel injection pump malfunctioned, causing vehicle to stall/ die. This can cause the driver to lose control because driver loses power steering and and power brakes. Took to dealer 3 times for same problem. Consumers warranty has expired, and dealer will not fix it again. Consumer feels that the dealer never really corrected the problem.

Filed Sep 30, 1999 · Fuel system · RI

The vehicle stalls out and dies without warning. Engine check light illuminates just before the vehicle stalls. Dealer has replaced the fuel injection pump three times. Manufacturer has been notified.