1996 Chevrolet Cavalier body problems

Filed Dec 2, 2008 · Body, Suspension · 112,000 miles · NY

I have a 1996 chevy cavalier that was driving down the road when the steering went haywire. When it was checked by a shop it was found to be caused by a rusted out subframe. This car has 112k on it with very minimal rusting ie around the gas cap.

Filed Jul 30, 2008 · Body, Suspension · 100,000 miles · MA

I have a 1996 chevrolet cavalier. The sub frame on the front has rotted and the lower control arm ripped out and the front wheel was ripped off at highway speeds. Gm needs to recall all of these cars to evaluate the condition of these subframes. Repair or buy back if necessary.

Filed Oct 17, 2001 · Body, Visibility · NY

There are 2 known service bullitins out on these problems and chevrolet nor the dealer wants to take responsibility to repair these defects. No safety defect listed.

Filed Aug 27, 2001 · Body, Engine · TX

Consumer states while driving was unable to stop, there were no brakes, also vehicle would make loud sounds and then stall, consumer was always being told by delaership that it was a sensor and the fuel filter which was always being replaced, but never resolved the problem, however it was finally determined by a manager at the chevrolet shop that the manufacturer programmed the air conditioner to be on at all times, which caused these malfunctions as well as burning out the carburetor, the manager fixed the dial so the A/C would not be on, but still informed consumer that it needed to be properly reprogrammed, consumer has not experienced the failures since the dial was readjusted, consumer has obtained legal represenation and feels she should not be held financially responsible for something that the manufacuter created.

Filed Apr 13, 2000 · Body · GA

I have had the top replaced once and the same problem came back again , in the same place 11 months later. The same hole same side same place , I need help.

Filed Aug 26, 1999 · Body, Engine · NY

The sun gear and carrier cracked and bearing exploded causing transmission failure.

Filed Apr 7, 1999 · Body · OH

Driver's and passenger's door cracked in same spot along with door sills on all doors.

Filed Nov 3, 1998 · Body, Electrical · TX

Battery light comes on, and looks as if it is on. When driving in rain the battery warning light comes on, there is no shield under the car to protect the brakes, engine, battery, etc. Dealer contacted, and cannot duplicate the problem, no repairs can be made.

Filed Aug 5, 1998 · Body · WI

Rear passenger's side door will not close. Vehicle was taken to the delaer and had door repaired. Afterwards when vehicle would turn a corner the door would fly open. The dealer has been notified.

Filed Oct 27, 1997 · Body · CA

Child safety locks failed.