2005 Chevrolet Cobalt engine problems

Filed Feb 12, 2026 · Electrical, Engine · 90,000 miles · OH

The contact owns a 2005 Chevrolet Cobalt. The contact stated that the key was stuck in the ignition. The contact had to use the key release to remove the key manually. No warning lights were illuminated. The vehicle was taken to an independent mechanic; however, no cause for the failure was found, and the failure persisted. The contact stated that on a separate occasion, while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The contact was unable to coast to the side of the road. The steering locked up after the vehicle stalled. The vehicle was restarted; however, the failure persisted while driving a short distance. The vehicle was taken to an independent mechanic; however, no cause for the failure was found, and the failure persisted. The check engine warning light has been illuminated since the vehicle was purchased. The exhaust system, fuel lines, brake lines, and the engine had been replaced. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 90,000.

Filed Nov 6, 2023 · Acceleration, Electrical · PA

The tcm in my 5 cobalt is not working properly I've tested and replaced everything els and had the tcm reprogrammed still getting problems aiming back to the tcm it wasn't looked at by a business

Filed May 16, 2023 · Electrical, Engine · TX

Ignition switch had a previous recall, but now the ignition switch won’t turn the car on on the first 5-10 switches with any keys, or spare keys. Steering wheel shakes/wobbles when exceeding over 50mph.

Filed Nov 7, 2020 · Electrical, Engine · 89,590 miles · NC

When I got the car in june 2020 I got the key I was told to turn key to acc wait until lock icon go off my car alarms will sound anti theft system took to chevrolet dealership,and they charged $$$ said they replaced several part's and still it's stalls,and loose powder steering,it says I have no fuel in car brake light on do not chimes when I get in car it makes it like I stealing the car and it shutdown everything been doing it sense july can't drive out no where stalls when I did try driving it engine light comes on then my steering wheel locks up

Filed Apr 8, 2020 · Engine, Fuel system · 15,000 miles · MI

I got the car a few years ago only drove it for 5 months found out about the recall. I had to pay for the car to go nassau bahamas. They never ship it for me .they paid the ignition repairs never gave me a rental car. Then I called back a few months about a warranty say 60,000 miles or 5 year they tell another recall for the same thing. So I started checking come to find all kinda law suit on that type model. They want the car off the road. I asked them to pay out the car. Can't get a response. They open but the bahamas office closed from covid-19. Still have to wait on a response.*dt*jb

Filed Mar 9, 2020 · Engine, Steering · 35,000 miles · IL

Tl* the contact owns a 2005 chevrolet cobalt. The contact stated that while driving at various speeds the vehicle lost power steering assist which caused the steering wheel to become very difficult to turn in either direction. The check engine warning light was illuminated. The cause of the failure was not determined. Rodgers auto group located at (2720 s. Michigan ave chicago, il) was notified of the failure but no assistance was offered. The contact indicated that the vehicle was previously repaired under the federal safety agency campaign number 10v073000 (steering). The manufacturer was also notified of the failure. The failure mileage was 35,000.

Filed Oct 30, 2019 · Engine, Steering · 190,000 miles · OH

Tl* the contact owns a 2005 chevrolet cobalt. While operating the vehicle, the check engine indicator remained illuminated and the power steering failed. As a result, the steering wheel became very difficult to turn in either direction. The cause of the failures was not determined. The local dealer and manufacturer were not notified. The failure mileage was 190,000.

Filed Oct 22, 2019 · Engine · 80,000 miles · PA

Tl* the contact owns a 2005 chevrolet cobalt. The contact stated that the temperature gauge malfunctioned and the check engine warning indicator illuminated. The contact spoke with several dealers, including gray chevrolet (1245 n 9th st, stroudsburg, pa 18360, (866) 505-3058), ray price mt pocono chevrolet (2969 pa-940, mt pocono, pa 18344, (570) 839-0810), and abeloff buick gmc (1167 n 9th st, stroudsburg, pa 18360, (877) 816-1775) and was informed that the parts were discontinued and no longer available to repair the vehicle. The manufacturer was notified of the failure and stated that the part had been discontinued. The vehicle had not been repaired. The failure mileage was approximately 80,000.

Filed Jan 2, 2019 · Electrical, Engine · 135,000 miles · NC

Tl* the contact owns a 2005 chevrolet cobalt. The contact stated that the ignition was loose and the vehicle could roll away if the key were removed. Also, the check engine and brake indicators illuminated. The vehicle was taken to a local mechanic where it was diagnosed that the engine overheated. Another mechanic diagnosed that the ignition switch was damaged. The contact planned to take the vehicle to ricky hendricks city chevrolet (5101 e independence blvd, charlotte, nc 28212, (980) 242-5621) for additional diagnostic testing. The manufacturer was made aware of the failure and did not assist. The vehicle was included in the federal safety agency campaign number: 14v171000 (electrical system). The failure mileage was 135,000.

Filed Mar 15, 2018 · Body, Engine · 80,000 miles · WV

Tl* the contact owns a 2005 chevrolet cobalt. The contact stated that the vehicle's doors constantly locked independently. The contact had to crawl in and out of the vehicle through the window. While driving approximately 45 MPH, the vehicle lost power and the power steering and check engine indicators illuminated and remained lit. The vehicle was pulled over to the side of the road and powered off. The vehicle was later restarted and driven to the contact's residence. The contact called harry green chevrolet at 304‑624‑6304 (1858 e pike st, clarksburg, wv 26301) and was informed that there was no recall. The manufacturer was made aware of the failure and stated that there were no recalls for the failure. The manufacturer informed the contact about the federal safety agency campaign number: 07v014000 (structure). The contact had not received a recall notice. The vehicle was not repaired. The failure mileage was 80,000.