There was a strong odor of gas when driving the car, and it is very hard to start the car. The autoshop said there is a severe fuel leakage, and they found fuel leaking from the fuel tank, and the source of fuel leak was the fuel pump module. This could be very dangerous, and there was indeed a recall for the car model, however, it does not cover car registered in my state. I suggest they include this state, and reimburse my repair.
2007 Chevrolet Cobalt fuel system complaints
Page 13 of 16: complaints 341 to 370 of 431, newest first, as owners wrote them.
Fuel pump and lines are leaking . Purchased car new in 2007 in mo.. Was told it is not covered under recall notices #09v419000.
My husband and I purchased the vehicle in question in april 2007, at approx. 50,000 miles my car started to miss, then began to accelerate on its own and lunge as I was coming to a stop. We brought the car back to dealer where purchased, we were then sent on "wild goose chase," first we were told it was a fuel pedal sensor, nxt they replaced the computer, followed by the wiring harness, this however, did not fix the problem, we took it back for a fourth time and the ended up rebuilding the head on the motor, car has not ran correctly ever since. We tried to file a lemon law claim but needed four receipts to prove warranty work, we had three and after the fourth when picked up car the dealer would not release fourth, that was a year ago. My car now has 88,000 miles on it, it is beginning to idle rough again and when I put fuel in it, the car does not want to start, at first it will not do anything, and then it will try to turn over but will not start I then have to slam the fuel to it in order to get it started, once it starts it will idle rough and I have to keep giving it fuel in order for the idle to smooth. This is the worst vehicle I have ever owned, I will be hard pressed to ever buy another chevy!!!!!!!
The vehicle was brought in for a recall to replace fuel module for fuel odor? Well the module was replaced with the new module kit(3.107). Before this replacement we had no problems with the car and fuel odor/fuel gauge. Now that we had the recall down there is a strong fuel odor and the gas gauge will read full at times and when the car is shut off and turned back on after driver .7 miles the gauge will say its only got a 1/4 tank of gas and we switch the car on and off a few times and it will finally go back to full but after driving it about 3 miles the gauge will go back down to a 1/4 tank and we have to stop and cycle the key on and off at least 4 times for it to give a somewhat accurate reading but after driving a couple miles the gauge will go to empty. Even when the tank is empty the gauge will say there's a half tank of gas, I have even got stuck multiple times thinking there was gas in the car. Anyway point being that this module kit 3.107 gave me all the symptoms of why it was being recalled and messed up my fuel gauge and the dealer refuses to fix it as warranty so because the fuel gauge isn't part of the recall. So I further investigated on multiple online forums and it seems everyone that gets this recall down has had major problems with the fuel gauge and a fuel odor they didn't have before the recall. So im hoping the federal safety agency will further investigate this issue, this could be a huge safety issue running out of gas in the middle of the road/highway/dark long dirt roads with no gas stations for miles. So please read this and check your cobalt by cycling the ignition and you will see after module replacement the fuel gauge is erratic/gas odor is now present. Chevys cheap recall is just not cutting it and they need to look into recalling the fuel level sensor with the module cause this problem seems like it happens to every cobalt I have seen with this recall.
Tl* the contact owns a 2007 chevrolet cobalt super sport. The contact stated the smell of fuel emitted from outside of the vehicle. The vehicle was taken to a private mechanic where it was confirmed that there was a crack in the fuel line. The manufacturer was contacted and advised that the VIN failed to qualify for repairs under the federal safety agency campaign id number: 09v419000 (fuel system, gasoline:delivery:fuel pump). The vehicle was repaired at the contact's expense. The failure mileage was 61,000 and the current mileage was 61,100. Updated 6/20/12 *cn updated 06/22/12
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that fuel fumes were emitted into the vehicle. The contact mentioned that after inspecting the vehicle he noticed that fuel was leaking out of the fuel tank. The vehicle was not taken to the dealer. The manufacturer was made aware of the failure who advised that they would contact him at a later date. The vehicle was not repaired. The VIN was not available. The failure mileage was 110,000 and the current mileage was 116,000.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that there was an overpowering odor of gasoline within the vehicle. The vehicle was taken to the dealer where the contact was told that the modular reservoir assembly to the fuel pump was fractured and would have to be replaced. The contact referenced the federal safety agency campaign id number: 09v419000 (fuel system, gasoline: delivery: but was advised by the manufacturer that the vehicle was not included in the recall. The failure mileage was unknown, but the current mileage was 100,000.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that the vehicle was parked when he smelled a strong odor of fuel. The vehicle was taken to an authorized dealer and they were unable to diagnose the failure. Approximately two months later, the vehicle was taken back to the dealer and they located a fuel leak near the fuel pump. The vehicle was in the process of being repaired. The manufacturer was made aware of the failure and stated that the VIN was not included in the recall associated with the federal safety agency campaign id number 09v419000 (fuel system, gasoline:delivery:fuel pump). The failure mileage was 38,000.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that the vehicle was parked when he smelled a strong odor of fuel and noticed a fuel leak. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was made aware of the failure and the contact was informed that the vehicle was not included in the recall associated with the federal safety agency campaign id number 09v419000 (fuel system, gasoline:delivery:fuel pump). The vehicle was not repaired. The failure mileage was 51,000.
I began smelling fuel, especially parked on an incline. I filled up my gas tank, and witnessed loosing over 1/2 a tank of gas! I am terrified to put more than 5 gallons of gas now. Anytime I put any amount of gasoline in, the fumes are very strong inside as well as outside of my vehicle. The engine light is on and I cannot even get this car inspected since I live in north texas (denton). I took it to the dealer who said there are no recalls! The estimate to repair was 1100.00 which is more than 25% of it's value. They said it does not have a recall. I bought the car and live in texas. So far I have had the steering assembly replaced (recall) as well as the windshield (not a recall but covered under warranty. I am so terrified of dying in this car and no one wants to fix it for under 1100.00!
My daughter's car (2007 chevy cobalt lt, titled in my name) developed a strong fuel odor. The waranty had recently expired in december. The dealership had recently made a warranty repair and a recall repair to the vehicle 11/2011, but was not open on a saturday. A local shop identified the problem, and I called the dealership and gm to see if they would fix based on a recall for the exact same problem & model #, the federal safety agency # 09v419000. They refused based a nc salvage title on the car that was due to a replaced bumper, 3 years ago, which had no impact on the fuel system. Remember they had just done warranty work 2 months ago, but said the warranty had expired, although the gm rep said the warranty had been extended for 10 years for this problem as a part of a settlement, but said the salvage title did not warrant repair. When pushed about the previous work they had performed, the recall on record, and why did they not fix it when they fixed a steering recall; he called the dealership, they said it was because it was working fine and did not show the symptoms of the recall at the time. My exact same point!!! The salvage title/bumper had no impact to the fuel system for 3 years; and their (gm) responsibility in meeting a the federal safety agency recall. They are trying to use a loophole to avoid their responsibility on this recall. I had to pay $593 today so my daughter's car would not catch on fire as was mentioned on several internet websites in relation to this recall. Both gentlemen I spoke to were polite, but indicated it was not their fault because it did not show on their computer as an issue, and for them to react it had to show as a VIN # they could repair, even though, here was a car with the same year model make and recall with the same defective part in the exact same defective location, they were "powerless to help". Information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
I can't find a recall for my fuel line leaking back by fuel tank.. The gas smell is really bad and im finding gas dripping slightly underneath my car have talked to chevy recall line thay said there isn't one I have seen some people talking only in some states. I purchesed brand new in kentucky not sure what to do for there part malfunction. Please help.. Thx information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
Tl* the contact owns a 2007 chevrolet cobalt lt. While parked, the contact smelled a strong odor of fuel outside of the vehicle but there was not a visible leak. The vehicle was taken to an independent mechanic who informed the contact that the fuel tank would need to be removed in order to determine the cause of failure. The contact referenced the federal safety agency campaign id number 09v419000 (fuel system, gasoline:delivery:fuel pump) however, the vehicle was not included in the recall. The vehicle had not been repaired. The manufacturer was not notified of the continuous problem. The approximate failure mileage was 49,000. The VIN was not available.
Our 2007 cobalt ls is experiencing the exact below fuel system issue, but is not included as part of the recall due to where it was sold or registered is not in the states listed. The gas smell/fumes and visible leak when parked at an incline are extreme. We are terrified to drive it for fear it will explode or catch fire. It was purchased used in mid-2010 from a dealer who will not even look at it without charging a significant fee, let alone the cost of replacing whatever it is that needs replaced. Note - this vehicle is registered and titled in my mother-in-laws name. Summary = general motors is recalling certain model year 2006 chevrolet cobalt and saturn ion vehicles originally sold in or currently registered in the states of arizona and nevada; and model year 2007 chevrolet cobalt, pontiac g5 and saturn ion vehicles originally sold in or currently registered in the states of arizona, california, florida, nevada and texas. The plastic supply or return port on the modular reservoir assembly may crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel may be observed dripping onto the ground and vehicle performance may be affected.
I have a fuel leak in the upper part of my gas tank.
I started to smell gas when the car was parked in the garage and it is getting worse. The VIN is within the range of gm's recall notice number 09226, but when I called gm customer service line it does not fall within the exact VIN, even though it is exactly the same defect impacting the other vehicles that qualify for the recall. This is a safety issue and it is costing approximately $600 to $700 to fix. That is about 20- 30 percent of the total value of the vehicle. This could cause a fire and gm knows this issue. They did provide me with a claim or complaint number. They need to include this in the recall before it is too late.
Started smelling gas. Checked fuel system. Found gas leaking from top of fuel cell where plastic lines enter tank. Googled problem....found many, many reports of same problem. Gm has issued a recall on this vehicle, but only for those sold or registered in arizona and nevada. I live in virginia. Contacted gm...was informed my vehicle was not eligible for the recall because I was not in either of those states. My vehicle has 77,740 miles on it. This is a safety issue and should be taken care of by gm no matter where the vehicle is registered.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that the vehicle would hesitate to start. Also, the vehicle would lunge forward when driving at any speed and the steering wheel would become stiff when attempting a turn. A local mechanic diagnosed that the fuel injector was defective. Neither the dealer nor the manufacturer was notified of the failure. The vehicle was not repaired. The failure mileage was 81,000 and the current mileage was 92,600.
There is a recall issued for a faulty fuel pump on 2007 chevrolet cobalts but it did not include my VIN number. I smelled gasoline both inside and outside the car. I looked online and found the following website showing many people are having the same problem. Http://www.aboutautomobile.com/complaint/2007/chevrolet/cobalt/fuel+system I saw that people had reported fires and I did not feel safe driving the car. I had it fixed at the place I bought it because it was close to home, it was a chevrolet dealer but is no longer and is now an acdelco repair center. It cost me $615.86 to get the faulty fuel pump repaired and I was told that my problem was the exact same problem as the problem in the cars included in the recall. I have called chevrolet many times and have sent them my receipts but they do not return my calls. I do have an open case number with them but have had no success in receiving reimbursement.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that a strong odor of fuel was emitted from the exterior of the vehicle. There was no fuel leak visible. The vehicle was taken to an independent mechanic who stated that there was a crack in the fuel tank. The contact referenced the federal safety agency campaign id number: 09v419000 (fuel system, gasoline: delivery: fuel pump); and planned to notify the dealer regarding the vehicle eligibility. The manufacturer was made aware of the problem. The contact was awaiting repairs to the vehicle. The approximate failure mileage was 56,630. Updated 11/16/11 *bf the consumer stated the repairs were paid without any assistance. Updated 06/15/2012
2007 chevrolet cobalt. Consumer writes in regards to a major crack in the plastic where the fuel pump is connected to the gas tank. There was also a crack developing in the line from the fuel pump *tgw the repair required replacing the fuel tank and the fuel pump. The consumer stated he was denied assistance because, he was told repeatedly, there was no recall for his model year. However, his vehicle had the exact defect for which a recall was issued, just not his specific VIN.
It's my mother inlaws car she started smelling strong gas smell inside the car and outside the car and gas leaks on the ground while it is running I looked to see where it was coming from because I am a mechanic it's leaking from the plastic fuel lines on top the gas tank they're cracked and leaking gas the fummes are strong I aslo notice online that they had a recall on the fuel lines cracking on 2006 and 2007 cobalt but I guess it doesn't cover virginia I don't know but it seems like we are not the only ones with this problem but I would for it to get fixed its a fire hazzard if the other states covered the recall for free then they should cover the other states complaints because it did get very hot and dry this summer and that's what they say causes them to crack something should be done about this problem it's not safe for the enviroment having 2007 vehicles leaking gas due to manufactures parts it's not our fault the lines crack it's the manufactures who built or made the cheap plastic lines my kids and her other grand kids ride in this vehicle it's her only means of transportation she bought hopeing it would be reliable thanks for listening.
Experienced strong fuel odor in and around vehicle after driving. Contacted dealer service department and scheduled appt to have vehicle inspected and repaired. Owner researched the issue and found vehicle recall 09226a. When vehicle went in for service, owner was advised by service rep that recall was not for the vehicle and charges would apply. Vin indicates it was in the VIN breakpoints but vehicle was not associated with any of the states identified (arizona, california, florida, nevada, and texas). Appears the gm and/or the service departments have misinterpreted the recall to mean both the VIN breakpoints and the affected states have to be valid for the recall to apply. Repair was done under warranty. Owner never received recall notice which should have been sent to all vehicle owners with vins within the breakpoints with no consideration given to a particular state.
The odor of gasoline around the vehicle after it has been driven. The dealership says there is a fuel system problem and there is a recall on them, however my VIN is not under the recall list and I will have to pay out of pocket for it. The issues that are under the current recall for this car are what is wrong with my car, yet my car is not under the recall list.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated that the vehicle had a fuel leak that would spill fuels under the passenger compartment. The vehicle was taken to a local mechanic who verified the failure and diagnosed that the fuel pump needed to be replaced. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was not included in the federal safety agency campaign id number: 09v419000 (fuel system, gasoline:delivery:fuel pump). The vehicle was not repaired. The failure and current mileage was 112,000. Updated 10/28/11
Tl* the contact owns a 2007 chevrolet cobalt ls. The contact stated that the vehicle emitted the smell of fuel from the interior and exterior of the vehicle. The contact also mentioned that the vehicle failed to start properly at times. The vehicle was taken to a private mechanic where the mechanic suggested that the fuel pump could possibly need replacement. The manufacturer was contacted and they confirmed that the VIN did not qualify for repairs under the federal safety agency campaign id number:09v419000 (fuel system, gasoline:delivery:fuel pump). The vehicle was not repaired. The failure mileage was 94,500 and the current mileage was 94,642.
24,866 mile fuel tank defect. Crack in the tank close to the filler neck. No impact , no collision. Supplier defect.
Tl* the contact owns 2007 chevrolet cobalt. The contact stated there was a fuel leak in the fuel tank and gasoline fumes coming from the inside of the vehicle. The vehicle was taken to the dealer who stated there were no recalls and they did not see any fuel leaks. The manufacturer was notified and stated the mechanic also did not see any fuel leak and offered no other assistance. The failure mileage was 51,174.
Tl* the contact owns a 2007 chevrolet cobalt. The contact stated the front suspension caused the two front tires to be worn. The vehicle was taken to the dealer who performed an alignment but the vehicle continued to pull to the left. The manufacturer was notified and offered no assistance. The failure mileage was 15,000 and the current mileage was 26,000. Updated 03/23/12*lj the consumer stated the power steering, brakes and gas tank needed to replaced.updated 04/09/12
Fuel pump started leaking fuel.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Chevrolet Cobalt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history