The contact's son owns a 2008 Chevrolet Cobalt. The contact's son stated while driving at approximately 30 MPH, he could smell gasoline inside the cabin of the vehicle. The contact’s son stated that once he had parked the vehicle, he saw fuel leaking from underneath the rear driver’s side wheel well. The contact stated no warning light was illuminated. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the fuel line was corroded and needed to be replaced. The contact researched online and related the failure to the federal safety agency Action Number: PE20011 (Fuel System, Other). The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 70,000.
2008 Chevrolet Cobalt fuel system complaints
Page 2 of 9: complaints 11 to 40 of 243, newest first, as owners wrote them.
The contact owns a 2008 Chevrolet Cobalt. The contact stated that the vehicle was leaking fuel on the passenger’s side in front of the rear tire. The contact stated that the fuel odor was also inside the cabin of the vehicle while driving. The check engine warning light was illuminated. The contact had taken the vehicle to an independent mechanic and was informed that the fuel line had failed and needed to be replaced. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 170,000.
On July 17,2018 I saw my 2008 Chevy Cobalt was leaking fuel in my driveway around the driver's side rear tire. I had it towed to my in-town mechanic, as I have Triple A. Paid $613.37 to replace the fuel line. On August 15th, 2022 same exact problem on my 2010 Cobalt. Another $553 to replace the fuel line. Chevrolet sent out a very confusing POSSIBLE recall letter in March 2013. But never officially told owners they would fix the problem with a recall letter. There have been many complaints on this problem on 2005-2010 Cobalts.
The fuel lines on this 2008 cobalt have rusted out and leaving a visible fuel leak puddle after parking. The leak occurs in front of the driver side rear wheel. This area has a heat shield over the fuel line underneath which traps moisture and road salt. This leak has caused me to park my vehicle outside as a safety precaution and not drive it. The leak is near the exhaust which is a large safety risk in my opinion. I am taking to the dealer to have them confirm and quote out repair cost.
I have to replace my fuel lines due to them rusting out over the left rear wheel well. I noticed a distinct smell of gas for a couple of rides to or from work. After a couple of rides, the smell was very strong and I happened to notice the gas dripping down under the car upon inspection. It was taken to a auto repair shop where I was told that this was a serious hazard and the gas lines would have to be replaced costing me $650. The mechanic said that the lines has rusted causing the leak. He also mentioned that this was a common problem with the 2008 chevy cobalt.
The contact's sister owns a 2008 Chevrolet Cobalt. The contact stated that while the vehicle was parked or being driven, there was a fuel odor detected. The vehicle was taken to an independent mechanic and diagnosed with Code: P2270. Additionally, there was a leak in the fuel pump. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 187,000.
I can smell a gas leak inside and outside of car just bought car for girlfriend don't want it to catch fire and kill her and daughter baby in car
The fuel line rusted through and were leaking gas right next to the exhaust pipe! This should not happen!!! I’ve never had to replace fuel lines due to rust on any vehicle I’ve ever owned!!! Inferior metal and or poor design had to contribute to this! Thank God the car didn’t start on fire or blow up. My friend has a 2009 Cobalt and had the same problem!!! It cost me $1478.79 to repair this defect!! No warning other than the terrible gasoline odor!!! Please do something about this before someone is killed!!!
The contact owns a 2008 Chevrolet Cobalt. The contact stated while the vehicle was parked, he noticed gasoline was leaking from underneath the vehicle. There were no warning lights illuminated. The contact was able to drive the vehicle to his residence. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The dealer and the manufacturer were not notified of the failure. The approximate failure mileage was 200,000. The VIN was not available.
There is a fuel leak with dripping towards the back of the car. I noticed that there is a current the federal safety agency investigation into such leaks so wanted to let you know of another example.
Fuel line leaking in front of REAR LEFT tire. Looks to be due to rust causing the leak
Fuel leaking from body near left-rear wheel well.
The contact owns a 2008 Chevrolet Cobalt. The contact stated while driving 30 MPH, she smelled a fuel odor. There were no warning lights illuminated. The contact stated she veered to the side of the road and exited the vehicle to determine the origin of the odor. The contact stated the odor was coming from outside of the vehicle. The vehicle was taken to the independent mechanic who diagnosed that the fuel pump needed to be replaced. The contact stated the failure had been reoccurring and the fuel was leaking underneath the vehicle while the vehicle was running. The contact referenced the federal safety agency Campaign Number: 12V459000 (Fuel System, Gasoline). The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The approximate failure mileage was 150,000.
The fuel system has developed a small leak, for now near the left rear tire. I cannot pinpoint the exact location of the leak due to the heat shielding around the lines. My concern is the proximity of the fuel leak to the exhaust system and potential fire hazard. A dealer has not looked at my car, however I have performed maintenance on enough vehicles and aircraft to know when there is a fuel leak. There are no warning lights associated for the leak thus far, there is a tendency for the the vehicle to need to prime itself by cranking in the morning or in cold temperatures.
Began smelling gas while i was driving, took to mechanic to get checked. fuel line was cracked at the fuel pump. had to replace whole assembly.
gas pump repaired in recall again leaking
This is additional information in regards to my first reported complaint of my fuel lines leaking. Mechanic stated my car was definitely unsafe and surprisingly my car didn't catch fire. Used a full tank of gas just driving 15 miles. Lost thar much fuel due to leak.
My 08 Chevy Cobalt has major fuel leak leaving puddles by left rear wheel. Very strong smell odor, losing more gas than putting in. I lost 5 gallons of gas in a 3 mile radius. Took to a repair shop and mechanic said the fuel lines are rusted from one end to the other and Chevy(GM) does not make fuel lines for a repair. At risk for car blowing up.
Fuel line near rear left (driver side) is leaking where held to vehicle. Noticed smell of fuel 8/16/21 then saw fresh fuel puddle 8/17. This can be inspected if need be It is a fuel leak which is very dangerous to anyone in or near the car. No one has inspected the vehicle No warning lights indicating there a problem
Gas leaking from under left side of vehicle near left rear tire. Gas line is rusted out.
Fuel line rusted through above the exhaust system in front of left rear tire. Noticed a puddle of fuel on the ground and dripping. Replacing the lines myself. Seems like a safety issue to me, and should be recalled.
The fuel Line is spraying gas out of it. These issues were up for recall in 2012 but not now..
Puddles of fuel leaking from car. Pungent fuel smell on back seats and coming through vents. Clothes are smelling like gasoline when I step out of the car. Doesn't crank right away. 100s maybe even thousands of people have had the same problem with this car
I noticed a fuel leak near the left side rear wheel well after parking the vehicle. I've read that this is an open investigation due to the fuel lines leaking where the block that holds the fuel lines to the body of the car near the left rear wheel well. I just want to report it so I can add my car to the open investigation going on currently. I will be taking it to a gm dealer to have repaired as it's a safety hazard and could start a fire.
Fuel line has rusted causing fuel to leak. Need to replace total lines.
Fuel line leak driver side rear of vehicle. Caused by heat sleeves put over the line by the manufacturer causing water to get trapped inside rotting out the fuel line. I was lucky this did not happen when car was at 210 operating temperature or I would have been burned up at 1200 degrees.
Tl* the contact owns a 2008 chevrolet cobalt. The contact stated while driving at various speeds, the fuel line leaked onto the exhaust system. There was no warning light illuminated. The vehicle was not taken to the local dealer to be diagnosed. The vehicle was not repaired. The manufacturer was informed of the failure and a case was filed. The failure mileage was approximately 103,004.
A fuel leak.corroded fuel line.03
I have a fuel leak on the drivers side middle of the vehicle, in front of the rear tire. This leak is from the fuel lines around the heat shield. It appears the fuel lines are corroded. I tried to get a price quote on parts from the dealership, but they required me to take in in for diagnostics, because they said it was a common problem and should be covered under a recall. After $100 they told me it wasn't covered and finally quoted me on the repair, over $1,000. Not only do I feel the parts were faulty, I feel like I was scammed out of an additional $100 to confirm what I already knew. The vehicle leaks when stationary, if you turn the key off the fuel lines will drain onto the ground until the lines empty. Starting the vehicle takes about 5 seconds for the pump to get new fuel to the engine. When the engine is on the fuel will continually drizzle out. The leak was not noticed until a mechanic pointed it out in september of 2018, but has now grown to a big issue. Given the proximity of the leak to the exhaust I am concerned this could be a major issue for someone driving in the south, in the summer.
I have had the power steering pump recall fixed twice now on my car. Last time was october of 2020, and finally in january of 2021 it started acting up again. Normally I can drive it to wherever without too much issue, but that was not the case yesterday. I started my car before leaving for work, got in to leave and the power steering light was on. I attempted to drive it, as it is my only form of transportation, and did not get far. It jerked around violently, would not accelerate and then became hard to steer. After I let it sit all day and tried again, it still was acting up and the steering wheel would not move without excessive pressure, eventually would not even start after that try. I am at a loss and am furious as this is still an issue after being fixed twice.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Chevrolet Cobalt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history