A major fuel leak was discovered on the car during refueling. The car was loaned to a family member, john wilfong, when the issue occurred. The car was taken to the nearest dealership. The fuel supply line had multiple leaks due to rust/corrosion through the line. This may have LED to a fire and potentially loss of life to vehicle occupants. The car has been properly maintained and washed on a monthly basis with an underbody spray. The car is currently 8 years old, rust leading to a fuel leak in this time frame is unacceptable. Manufacturers need to be made aware of this hazard, I fixed the problem by paying out of pocket for the repair.
2009 Chevrolet Cobalt fuel system complaints
Page 7 of 10: complaints 161 to 190 of 261, newest first, as owners wrote them.
Car is leaking gas. I noticed a faint gas smell the last few weeks and now you can smell it even in my house. It's that bad. There was a recall, but for some reason, my VIN does not fall under the recall. My daughter and I have had headaches the last few weeks and I believe it is from this gas leak. This is my only way to work and I pray that my daughter and I stay safe while I work to get this repaired. Gas leaking is very dangerous. The web has thousands of complaints on these cobalts having gas leak. I believe this is a standard problem across the board.
While driving, anytime that need to accelerate, car will take off at max acceleration and does not responds to full braking, gear down shifting, neutral engagement, it gets fully out control, like if throtle stays in high, or full acceleration, even without pedal response , it is the most scaring experience I ever had. It happened while there was nobody in front of me. Otherwise I could hit any car in front or side of me. I feel lucky that the road in front of me was clear. I can not imaging what could happen to an inexperience driver. I was in kendall drive s.w. Approaching 127 ave intersection wich is a very bussy intersection and road, before this many other time vehicle acted with erratic acceleration, but assume it was gas station bas gasoline, always use 87 octane grade, or water in the gasoline. Please make sure that this problem is taking care of. Possibly has been the cause of accidents involving this car, and since it will hit any car in front of it, by law it will be your fault when hitting some other or others vehicle, your insurance will count against you and god knows if somebody gets kill,or impaired including myself, please contact me as soon as possible, going to stop this car, wich I use to go work driving 44 miles each way. And rent something until this problem gets resolved. It happen at 6:20 am still dark outside.
Rusted through and leaking fuel supply and vapor lines. Noticed gasoline smell while driving and puddle under car when parked in hospital parking lot where I work. Gm is fully aware of this rust problem as they coated the brake lines to prevent corrosion. This VIN# is not covered under the existing recall for the 2009 cobalt and as a result the local dealership where car was purchase wanted over $800 to repair. Picture attached and still have most of the rusted lines if you want them.
Chevy cobalt is leaking bad in rear driver side in front of my tire. I have seen this issue in many cobalt. Chevy did a recall but for southern state. They need to add it for all the cars. Other northern state have had extreme heat too. Smell like gas in car. When stop driving sees it leaking.
Takata recall got into my 2009 cobalt and when I turned the key, it didn't start. When I tried to start it again, it chugged a bit before it started and instantly had a strong gas smell. I looked underneath on the driver's side in front of the back wheel and there was a gas puddle about 8" in diameter and gas was still leaking from a rupture in the gas line. I looked online and this seems to be a very common problem with the chevy cobalt with no existing recalls.
While driving the car shutdown. I pulled over and smelt gas. I looked underneath and I noticed the fuel lines leaking gas onto the exhaust. After looking the closely the fuel sending line has a hole inside the clip, behind the gas tank, holding the brake lines.
I started smelling gasoline while driving. I parked the car. I came out of my office hours later and there was a puddle of gasoline under the driver's side rear tire. I drove home and watched as the fuel gauge went down from a half tank to empty in the time it took me to drive 4 miles from work to home (1 mile in the city and 3 on the highway). This seems to be a problem but my car is not under the recall service because it is in the wrong state. There is a recall on the 2009 chevrolet cobalts for this issue but mine is not a part of it and should be obviously.
The fuel and vapor lines are rusted completely out. I took it to the dealership and they explained to me that this is a safety hazard. The cost to repair is well over $1200.00 and it is not recommended that the car is driven until the repairs are fixed for the safety of myself, other drivers and the environment.
Both my my car and my daughters 2009 cobalts have gas leaks. I saw a recall but my car is not on the list. How can both cars have gas leaks.
On 7/27/17 my daughters car would not start. Upon diagnosis found there was no fuel pressure. Fuses and fuel pump relay tested ok. Diagnosed problem to be the fuel pump. Removed fuel tank and pump assembly and found arcing on the outside of the pump. When trying to disconnect fuel pump from wiring harness it had fused together. I replaced the fuel pump, wiring harness, and hose assembly. This arcing inside the fuel tank could have cause a catastrophic failure, fire, and even death from explosion. I am attaching pictures and have retained the components for further examination.
Metal gas lines running from tank to engine rusted & rotted away at every clamp literally dumping fuel on the ground
Tl* the contact owns a 2009 chevrolet cobalt. While driving 35 MPH, there was an abnormal odor of fuel inside the vehicle. Additionally, while the vehicle was parked, the contact noticed fuel leaking. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The VIN was unknown. The failure mileage was 70,000.
Tl* the contact owns a 2009 chevrolet cobalt. The contact stated that the vehicle stalled while in reverse. The contact was unable to restart the vehicle. The vehicle was towed to an independent mechanic who diagnosed that the fuel pump wiring harness melted, which caused the fuel pump to become inoperable. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 118,000. Updated 08/04/17*lj
Tl* the contact owns a 2009 chevrolet cobalt. While standing outside the vehicle, the contact noticed a fuel odor. The contact, who was once an independent mechanic, checked the vehicle but did not find a leak. The failure recurred. The vehicle was taken to jim trenary chevrolet in union, missouri where it was diagnosed that the fuel pump gasket was cracked and needed to be replaced. The manufacturer was made aware of the failure and contacted the dealer. The dealer stated that there was no recall available. The contact stated that the repair cost was not affordable, so the vehicle was not repaired. The failure mileage was approximately 139,000. The VIN was not provided.
There is a fuel leak around the fuel pump. Possibly from faulty manufacturing of the fuel pump. This occurs when the motor is running.
Overheat back in 2014 took in to dealer in richmond ca. Again car overheating told fine by dealer. Summer had to run heater for car to cool down when driving. Even after I put antifreeze in& fluids fine. Would not pass smog for 2016 tags, has 85,000 miles.p03000 random multiple cylinders misfired detected. Was then told need a new engine for 2009 car! Just about paid off! Replaced gear shift 2years ago! Car died while driving all fluids good and battery good! Also when driving car seat belt passenger light would lite up w/no one in the seat! Called chevy told my VIN does not match to any of the recalls on chevy vehicles deal with it!
Tl* the contact owns a 2009 chevrolet cobalt. While driving 60 MPH, the vehicle stalled and the low fuel sensor indicator illuminated. The contact stated that she had 50 miles to go until the fuel tank was empty. The contact had someone come to her location to replace the ECM/trans fuse, which allowed the vehicle to restart; however, the failure recurred. The vehicle was towed to the dealer, but was not diagnosed or repaired. The manufacturer was made aware of the failure and stated that the vehicle was not included in any open recalls per case number: 8-2926645326. The failure mileage was approximately 119,000.
Fuel lines are rusted and could be a fire hazard. Common in these vehicles. Should be a recall on these parts.
Fuel pump cracked and fried. I saw this was a recall on 2009 cobalt's in several states but chevy said that my car didn't fall under this recall even though it was the same problem.
Tl* the contact owns a 2009 chevrolet cobalt. While stationary, the fuel tank leaked fuel onto the ground. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 127,000.
Began to smell strong fuel smell outside car. Can sometimes smell it inside car. Car is a little slow to start. This is apparently a problem with this model, and although there is a recall for some vins, my car is not included.
When the vehicle sat for a period of time a strong smell of gas was smelt near the driver side back door. A small puddle of gasoline is visible while the car is running and after it is shut off. After doing some research and contacting multiple chevrolet dealership it's was evident that the vehicle was not under the fuel recall administered by chevrolet. However the leak is consistent with that of the vehicles under the recall.
Tl* the contact owns a 2009 chevrolet cobalt. While the vehicle was parked, there was a strong fuel odor coming from the vehicle. In addition, there was fuel leaking from the rear of the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed with a fractured fuel line that needed replacement. The vehicle was not repaired. The manufacturer was not notified of the issue. The failure mileage was approximately 120,000.
You can smell gas after driving the car. It is hard to start with indications of a weak fuel pump. While there is a recall for southwestern states gm does not apply the recall to other states with the same problem. The dealer charges 110$ just to look at the car. The consumer stated the fuel pump was replaced. The consumer was advised that the vehicle was not included in the recall. Updated 08/07/2017*js
While stopped at a red light on a city street, the engine of my 2009 chevrolet cobalt stalled and despite several attempts, would not restart. There was no warning, no check engine light, and the car had been fully functioning the entire week leading up to the problem. It was towed to a mechanic, I was informed that not only had the fuel pump gone out, but it had also burned almost all the electrical wires surrounding the pump. The estimated costs for this repair are a real burden considering how much of the fuel system has to be replaced. I understand that at one point, prior to my ownership of the vehicle, this equipment was recalled and I am still researching whether or not the issue was addressed for this specific vehicle.
Both fuel lines is rusted and corroded, location of the rusted lines is directly in front of the divers side rear tire, right before the lines run up to the fuel pump.
Tl* the contact owns a 2009 chevrolet cobalt. The contact received an extended warranty letter from chevrolet regarding a leakage in the fuel module. The contact took the vehicle to the dealer for repairs according to the extended warranty notice. After the repairs, a strong fuel odor was noticed from the rear of the vehicle. The vehicle was taken back to the dealer were it was diagnosed that the leakage originated from the fuel line rather than the module. The vehicle was not repaired. The vehicle was then taken to an independent mechanic where it was diagnosed that the issues on the fuel module were related to the warranty repairs. The manufacturer was made aware of the issue. The failure mileage was 89,000. The VIN was not provided.
Tl* the contact owns a 2009 chevrolet cobalt. The contact received recall information regarding a potential crack in the fuel pump module. The contact wanted to schedule an appointment for the repair; however, the VIN was not included. The federal safety agency campaign number was unknown. The contact had not experienced a failure.
Tl* the contact owns a 2009 chevrolet cobalt. While driving and accelerating, the vehicle would jerk. The vehicle was taken to the dealer twice where it was diagnosed that sensors failed and would need to be replaced. The failure recurred. The vehicle was taken back to the dealer where the fuel pump was changed, but the failure persisted. The VIN was not included in the federal safety agency campaign number: 12v459000 (fuel system, gasoline). The manufacturer was not made aware of the failure. The failure mileage was unknown.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2009 Chevrolet Cobalt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history