2008 Chevrolet Corvette fuel system problems

Filed Jul 9, 2026 · Fuel system · 65,000 miles · UT

The contact owns a 2008 Chevrolet Corvette. The contact stated that a strong fuel vapor odor was noticed inside and outside the garage where the vehicle was stored. Based on research, the contact suspected a fuel pump failure. The vehicle was taken to a dealer, where it was diagnosed with a damaged fuel pump. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 65,000.

Filed Jun 16, 2026 · Fuel system · MO

Fuel system leak. Strong odor of gasoline fuel both around and inside the vehicle. No noticeable fuel product on the ground or underneath the vehicle. I am greatly concerned that this is a very significant fire and vehicle operator/occupant safety hazard. I have also found many other C6 generation Corvette owners online that are experiencing the same thing to their C6 Corvette.

Filed May 8, 2026 · Acceleration, Engine · PA

I am a long time Corvette owner and have purchased many through the years. I recently purchased a 2008 Corvette Coupe with only 30k miles, one owner vehicle. Unbelievable to me, I have had to spend over $4,000 the past month replacing the ECM and most notably the Fuel Pump, to relieve the constant Fuel Smell, not to mention the rack and pinion steering gear needs to be replaced, with again, only 30k miles on the vehicle, and that part is discontinued. The failure of the ECM almost cost my wife and I our life when we were coming home to [XXX] from [XXX] . The car completely lost all power on the highway and we almost got railed by traffic. Not a good situation to say the least. I almost had a heart attack. So we had to have it towed and finally made it home, only to find out the next day after a nice ride, my entire garage was overwhelmed with a gas smell that evening which permeated through the whole house. I took notice that GM covered this exact situation with GM Bulletin # xxx back in 2017, so they KNEW there was a problem! My question is, how can GM not cover this NOW. Many 2008 Corvettes are still being bought and sold. I spent over $2800 for this last week! I am asking you and GM to at least cover 50% of this charge. I don't think that is too much to ask. It's much cheaper than having been sued by our family, should me wife and I have not survived that situation on the road, a case I know they would have won. We should definitely be compensated to say the least! Thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 5, 2026 · Fuel system · FL

My recently purchased 2008 was taken to the local chevy dealer for gas fumes in the garage. The technician reported "The smell is coming from the sending unit on the driver side. There was fuel dripping down the side of the tank and the tank was wet. So the sending unit needs to be replaced" The car has only 16,427 miles on it and has been garage kept. I believe that leaking fuel is a very serious safety issue and that the now expired special service bulletin 150682 should have been a mandatory recall.

Filed Dec 11, 2025 · Fuel system · NC

Fuel sending unit in gas tank behind the drivers side is leaking gas making it impossible to park the car in the garage. There is a great possibility of fire due to this issue. No, I have not taken it to the dealer as of today but I am going to schedule it. No. No.

Filed Nov 21, 2025 · Fuel system · DE

cracked fuel pump housing causing vapors to vent out possibly causing a fire if stored extended periods of time indoors, and if crack is big enough fuel will drip down the back of the fuel tank onto the exhaust and possibly starting a vehicle fire

Filed Nov 15, 2025 · Fuel system · OR

Transmission gets stuck in park position and I am unable to shift it into any other gear. Unable to move the car if it's in a dangerous location.

Filed Oct 21, 2025 · Fuel system · SC

Bought this vehicle recently and filled it up with fuel and fumes overtook the cabin area and some leaked out the top of the tank down through the tank support. From the research I have done, this is a common problem that Chevy has ignored. The parts are too expensive to just replace everything with new.

Filed Oct 3, 2025 · Fuel system · MA

There is a strong smell of gas in the passenger compartment and a very strong smell of gas gas on the drivers side near the rear tire. The Chevy dealer has confirmed the the gas smell is due to a know defect where the fuel pump develops cracks in the housing because of the poor quality plastic used. The dealer estimates that it will cost between $3,000 to $4,000 to repair. This is a very dangerous problem. I'm afraid with the very strong smell of gas that an electric spark might cause the car to explode or when it's stored inside cause a vehicle and structure fire. Why has the federal safety agency not made GM do a recall for this defect. It is a very serious problem. Owners of any C6 corvette are sitting on a time bomb and their life is in danger. GM has already admitted that it is a design defect but has only issued a service bulletin. Do something before people die.

Filed Sep 4, 2025 · Fuel system · GA

This car has suffered a known defect that causes fuel to leak out of the tank when the tank is more than 1/2 full. Unfortunately, the leak in my vehicle occurred outside the window that GM arbitrarily set up. (10 years after vehicle put in service or 120,000 miles whichever comes first. My vehicle is a 2008 with 94,000 miles and the problem occurred recently and after GM's window. Therefore, GM will not fix this leaking fuel tank and correct a potentially life-threatening issue. The problem is that this is a serious safety issue with strong fumes inside the cars cabin and strong fumes outside the vehicle with leaking fuel on the tank. The fumes and the leaking fuel are both extreme fire issues. This is a known issue and a known condition that could cause fire and loss of life. the federal safety agency needs to issue an immediate safety recall to have GM fix all of these leaking fuel tanks.