2016 Chevrolet Corvette: shudder or vibration when accelerating

Filed Oct 4, 2023 · Transmission · TN

The transmission has a shudder issue at speeds between 60 and 80 mph. Gives the feeling of driving over rumble strips. Vehicle milage is 6200 miles. The dealership verified the issue associated with the transmission and indicated that a repair bulletin was issued by GM to correct the issue

Filed Sep 25, 2023 · Transmission · 12,000 miles · PA

The contact owns a 2016 Chevrolet Corvette. The contact stated that while driving from a stop, after engaging the clutch, the vehicle started to shudder and vibrate and nearly stalled. The contact pulled over into a parking lot. No warning lights were illuminated. The vehicle was towed to an independent mechanic, who determined that the valve spring had fractured in half within cylinder #5. Further diagnostic test determined that the failure had caused damage to the engine, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 12,000.

Filed Sep 24, 2022 · Transmission · FL

Since the vehicle was new, it has exhibited a transmission shake or shudder that is especially noticeable when the Active Fuel Management is active. The vehicle was serviced by Chevrolet under warranty on Dec. 5, 2017, for a transmission shake and/or shudder repair using the flush methods described in Bulletin No. 18-NA-355, but it has continued to exhibit a transmission shake or shudder. My local Chevrolet dealership has now diagnosed the vehicle as having a torque converter with excessive slippage and recommended a replacement torque converter at a cost of $3,450 including parts and labor, or a total transmission replacement at a cost of $8,100. My vehicle currently has 24,473 miles on the odometer. A major transmission component should not fail in less than 25,000 miles on a modern flagship vehicle used for light, non-everyday driving from a leading U.S. auto manufacturer.

Filed Jun 2, 2022 · Transmission · FL

Transmission shudder a low acceleration. Requires Triple Transmission flush. Vehicle is 2016 Model with 10500 miles GM refused any responsibility. GM was aware they had an issue with the transmission fluid. It has gone through two reformulations to correct the issue.

Filed Apr 9, 2021 · Transmission · 5,940 miles · NC

I have a '16 corvette z-51 w/8-speed auto trans. Ordered car brand new in april 2015 - took possession in sept. 2015. Car turned 6,000 miles in april 2021. On a drive recently, rear end began to experience a shudder/ vibration between 50-65 MPH like driving over small rumble strips. Internet research resulted in me finding the existence of service bulletin no. 18-na-355, dated february 2019 and an updated bulletin with same number dated april, 2020. Problem is a known problem for a host of gm vehicles from 2015-19 with the gm 8l45 and 8l90 8-speed automatic transmissions. Apparently the wrong fluid was installed in these transmissions. Reference attached bulletin 18-na-355. Took car to dealer the following monday and it was diagnosed as having the stated transmission shudder problem as outlined in service bulletin. Because my car is out of factory warranty by 6-months and gm extended warranty won't cover for this expense, I was left to pay the $650 to correct a known issue. Why must owners pay for gm's error? Attached bulletin explains the steps taken to correct the problem, involving 3 flushes and installing new/ different type of transmission fluid - new part number 19417577. Time will tell if this so-called fix works. Internet auto forums indicate some folks have had to return to the gm dealer more than once for this problem, after the flush procedure. Contacted gm and logged formal complaint -- with no response and basically nothing but a run around thus far. As a consumer who paid good money for a high end performance vehicle would it not have been good business practice to notify customers of a pending problem rather than remain silent about the problem, let vehicle warranty run out, then tell customers it's their problem? Poor customer satisfaction policy no doubt! Gm should be forced to own up to this problem and pay for the repair.

Filed Mar 26, 2021 · Engine · 2,319 miles · OH

At 627 miles took to dealer, transmission was slow shifting from 1st to 2nd gear. Dealer reprogrammed transmission. At 2319 miles took to dealer. Transmission shudders at steady speed on highway or going up slight incline. Dealer flushed and changed transmission fluid to remedy problem. Customer charged $576. Car was manufactured with incorrect transmission fluid for the 8 speed automatic transmission application. Temporary complaint #cln19-56809

Filed May 25, 2019 · Electrical, Transmission · 37,700 miles · NJ

Veh purchased 9/2015 and so far I have replace four rear rims and one front. All have hair line cracks on the inside of rim causing radical air loss, vibration and tire wear. Navigation screen flickers and goes on and off at least two times a week and I have to open and close to restart screen. Blower motor went out at 37k miles and the transmission is bucking, vibrating, shuddering and going into 5th gear at 31mph and feels like it is hanging up in 5th gear the clunks down to first at 10mph. Went to dealer, they claimed they did a software up date and things are fine. Left the dealership and came back 5 min later with same issue. Took service manager for a ride and he confirmed the horrible ride. Have to take back on tuesday 5/28 and it feels like the drive shaft or rear end will fall out. They said it was fine. I hope nothing happens to me or the car.

Filed Apr 26, 2019 · Transmission · 7,571 miles · FL

While attempting to accelerate or decelerate my car I feel a hesitation, followed by a significant shudder when the vehicle's automatic transmission changes gears. The shudder, shake and hesitation also occurs while my vehicle accelerates in a single gear, and not actively shifting gears. The problem does not merely result in an uncomfortable driving condition. The shuddering and hesitation seem to be related to internal issues within the transmission and/or torque converter causing friction surfaces, hydraulic systems, and gears to not function properly. There is possibly permanent damage that will occur to the transmission and/or torque converter over time. I face escalating repairs that can include flushing the transmission of metal shavings caused by the defective transmission operation, and which eventually necessitate the replacement of components such as the torque converter, valve body, or the entire transmission. As such, the transmission defect endangers the drivers and passengers of the vehicles, and diminishes the value of the vehicles. Gm's deliberate non-disclosure of these defects artificially inflated the purchase and lease price for these vehicles. Gm has known about the transmission defect for years, since right after introduction of the transmission. Since 2015, gm has issued thirteen versions of a 'technical service bulletin,' or 'tsb,' related to this shifting issue alone. The tsbs related to the transmission issue have advised dealerships to, among other things: complete the 'clutch drive learn procedure,' replace the valve body, replace the entire transmission, flush the cooler lines and cooler, remove debris from and clean the transmission pan, replace the transmission filter, replace the transmission fluid, and flush the transmission. To date, none of gm recommended solutions has resolved the problem.

Filed Nov 1, 2018 · Transmission · 21,000 miles · FL

Known issues with a sub standard torgue coverter causing a shudder and jerky motion the car starts demonstrating accompanied by fluctuating engine rpms. This corvette is equipped with a 8i90 8 speed automatic transmission. Its especially noticeable when cruising at highway speed with the cruise control engaged, however it displays this problem whether the cruise control is engaged or not. This issue seems to have affected about 20,000 corvettes until about the end of october 2016 production dates. Internet research shows tha this is a wide spread problem and there should be a recall on these vehicles that requires gm to replaces the transmission and torque converter