Getting off the highway and brake pedal is just hard can barely push it. It stopped but barely.
2020 Chevrolet Equinox brakes complaints
Page 3 of 5: complaints 41 to 70 of 114, newest first, as owners wrote them.
I purchased this vehicle as a Certified Pre-Owned vehicle from George Moore Chevrolet in Jacksonville, Florida, in October 2023. At the time of purchase, the vehicle had approximately 35,000 miles, and it now has approximately 60,000 miles. I have maintained all recommended service intervals and oil changes as required. On June 14, 2025, while stopped at a traffic signal with my foot on the brake pedal, the pedal suddenly sank to the floor, causing the vehicle to roll forward into traffic unexpectedly. I was able to place the vehicle in neutral and then park to prevent a collision. After turning the vehicle off and restarting it when the light changed, the brakes continued to fail. I carefully maneuvered to a nearby area behind a warehouse and allowed the vehicle to come to a complete stop by shifting into neutral. I contacted a tow truck through my State Farm roadside assistance program and had the vehicle transported to my local mechanic. Upon inspection on June 16, 2025, the technician determined that the brake lines were corroded and leaking. Initially, he suspected the master brake cylinder, but it was confirmed not to be leaking. He noted that the metal-braided portion of the brake line had completely deteriorated on one side and was severely compromised on the other. Both brake lines were replaced to restore braking function. Fortunately, I was able to avoid an accident, but this was an alarming experience that I have never encountered in any vehicle I have owned. My mechanic expressed concern about the extent of corrosion on such a relatively new vehicle and indicated this could represent a broader safety issue. I respectfully request that this matter be documented and investigated to ensure that other drivers are not placed at similar risk.
•Initial incident: July 2, 2025 •Recurring occurrences: August 8, 2025 Vehicle Issue Description: Several months ago, the vehicle’s check engine light came on. A diagnostic scan was performed at O’Reilly Auto Parts, but no error codes were detected. The vehicle was taken to an independent repair shop for further inspection. The shop found no mechanical issues and confirmed the vehicle was operating normally at that time. On August 6, 2025, the “Service Brake Assist” warning appeared briefly on the dashboard but turned off shortly afterward. The parking brake warning light also came on that same day, then went off. These warning lights reappeared intermittently on August 8, 2025. No repairs have been made as there are no active recalls related to these issues. However, it is noted that there are consumer complaints reporting similar problems. This raises concerns about potential intermittent or undetected safety system faults, particularly involving the brake assist system and parking brake functionality. Checked brakes again no issues determined per Bridgestone and Mavis.
I was driving just got off the freeway and went to hit the brakes and the brake pedal was hard as a rock I had to use force to slow down to safely get over from the left lane to the right lane to get into a parking lot was a pretty scary experience, called AAA had it towed to the dealer they said the vacuum pump failed which I suspected because of the other complaints regarding the same thing, there was no recalls on my car dealer fixed it under warranty and they said there was no damage to the camshaft. The dealer was amazing and would reccamend them, I also had to pay 100 deductible. As others have stated theres a recall on the vacuum pumps but certain Vin #s are not included. Gm needs to included all Vin #s for the equinox in the recall whats it gonna take somebody to get killed!
My breaks stopped working while I was driving, they became hard to press and unable to function. The vacuum pump attached to the engine failed. The vacuum has broken pieces that are now inside of the engine. No warning indicator lights appeared before the incident. As far as I'm aware other similar models are having the same issue but my vin was not included in the recall.
While driving on the freeway at 75 mph my vacuum pump seized and shattered, causing me to loose all breaking power, damaging my engine beyond repair and endangering my life and numerous other drivers on the road. There is a current recall on the particular year, make and model for this issue but my VIN is not included so the dealership refuses to fix the issue.
The vacuum pump broke and caused the brake booster to lose vacuum and made the brakes hard and almost caused an accident.
Vehicle brakes became hard and failed to stop, check engine light came on and warning saying reduced engine power. Vacuum pump seized and broke off in the crankshaft. After vacuum pump replacement vehicle failed to start multiple times. Vehicle started and had rough idle and stalled multiple times. Currently awaiting dealer inspection.
I am filing a safety complaint regarding a failure of the vacuum pump in my 2020 Chevrolet Equinox. The failure occurred without warning and severely impacted the vehicle’s braking performance, posing a serious safety risk while driving. When the vacuum pump failed, I experienced a hard brake pedal and a significant loss of braking power, which made it difficult to stop the vehicle safely. Thankfully, I was not in heavy traffic or approaching a stoplight at high speed when it happened—otherwise, it could have resulted in a serious accident. After researching this issue, I discovered that vacuum pump failures appear to be a recurring problem in other GM vehicles of similar model years. It is extremely concerning that such a critical component could fail prematurely and without adequate warning. I believe this issue should be investigated for a potential defect and safety recall. I urge the federal safety agency to look into this matter to ensure the safety of other drivers who may be at risk due to this defect. Thank you for your time and attention.
This past weekend, while driving my 2020 Chevrolet Equinox, I experienced a sudden and complete brake failure. I was turning into a residential neighborhood at approximately 20-30mph when the brakes locked up without warning. Despite pressing the brake pedal, the car would not stop. I attempted to shift into park, but the vehicle continued to roll forward. I had to engage the emergency brake, which caused the car to come to an immediate stop. Thankfully, there were no cars in front of me, but I came dangerously close to hitting a cement wall head-on. This created a serious risk to my safety and potentially to others had the situation occurred in traffic or near pedestrians. There were no warning lights, noises, or prior symptoms indicating an issue with the braking system. The vehicle has since been towed to the dealership and is currently awaiting inspection. I've learned that there are existing recalls on other VINS for the 2020 Equinox related to an incorrect lubricant used in the manufacturing process of the rear brake calipers. This defect can cause the calipers to swell, leading to excessive brake drag. Over time, this drag may result in overheating and possible brake lockup, which aligns with what I experienced. The component appears to be the braking system, specifically involving the calipers or pads. At the time of writing, the failure has not yet been confirmed by the dealer. This issue is extremely dangerous and could have resulted in a severe crash. I am reporting this in hopes that it contributes to a broader investigation, especially if this problem extends beyond currently recalled VINs.
The vaccum pump seized which is connected to the camshaft which broke causing the timing chain to break. This caused the vehicle to lose breaking g power and almost wreck.
Service brake assist
Our car has just around 77,000 miles and the brakes stopped working while driving. To our luck my husband quickly thought to use the e brake to prevent a car crash. We took it into our mechanic who diagnosed a brake pump failure. It looks as though the 2020 equinox has recalls for brake issues but our vin number was not listed. This is very dangerous and could have caused a deadly or serious injury crash. We had no prior warning to this happening. The shop owner is fixing the issue and we are holding onto receipts if this becomes a recall available on our vehicle. Very unsafe and according to my research has happened to alot of GM owners.
ABS and breaks exploded at 67k miles and at 78k miles car shut off in middle of the street with no warning. Electric issues confirmed by mechanic.
Unknown, My wife was driving my 2020 Chevy equinox on the freeway when suddenly the vehicle shut down with no warning signs ..she tried to turn on the emergency lights and did not function slowly she yield to other lanes and cars honking she safely made it to the side of the freeway..she tried to turn the car and did not wanted to restart everything shutdown .she call roadside assistance..they came and try to give her a jumpstart and it fail.they tried to tow it and they couldn't cause the brakes were also locked..This.was a scary situation that would had cause major accident.
I put the vehicle into reverse to back in into my garage when it suddenly lurched forward and hit the garage door on the garage across the alley. There was damage to the garage and the car's front end. It has never done anything like this before.
The contact owns a 2020 Chevrolet Equinox. The contact stated while depressing the brake pedal, the brake pedal was hard while depressed, and the vehicle failed to immediately stop, causing the braking distance to become extended. During the failure the message "Brake Assist" was displayed. The vehicle was taken to the local mechanic who replaced the brake pads and brake rotors, but the failure persisted. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 71,000.
I was driving my car approaching a four way intersection, to realize my brake pedal was not pressing down to the floor. This was 9/28/24. I have a 2020 Chevy Equinox. I put my car in the shop to only find out that vacuum pump has exploded and left metal inside the engine. Done some research with the repair shop and to my surprise, GM has had a lot of recalls with vehicles having this issue. Who ever the CEO is, I pray that you understand how deadly and serious this issue is. This could have ended badly for me and could have been tragic for my family. I can not afford to get the metal out of my engine. And to replace the vacuum pump alone was $700. In order for them to clean the engine would cost me an extra $1000. That's ridiculous for a car that I have only had almost 4 years and with maybe 10,000 miles when I purchased it. My voice will be heard. And I will keep advocating for people who are going through this! Our lives matter. This is very common in vehicles with 1.5 liter engines. I'm going to keep researching and hopefully GM will compensate me for this and the engine work.
We were driving on the highway and just exited. My husband hit the brakes and the pedal was hard to push. He basically had to put all his weight on the pedal in order to slow down. Once we were able to stop completely, we got the 2020 Chevy Equinox looked at and we were told that the vacuum pump that is attached the the cam shift exploded and pieces were in the engine. This has caused approx. $3000 in damage that me and my husband can't afford. The vehicle is still at Classic Chevrolet in Grapevine. We are going to have to tow it back to my brothers until we can afford the payment to fix it.
The contact owns a 2020 Chevrolet Equinox. The contact stated that while exiting the highway at 50 MPH, the brake pedal had hardened and the contact could not depress the brake pedal. Several brake warning messages appeared on the instrument panel. The contact shifted the vehicle into neutral(N) and pulled into a parking lot to allow the vehicle to coast to a stop. Once the vehicle slowed to a complete stop, the contact shut off the vehicle. The vehicle failed to restart after multiple attempts. The contact called a relative to the scene who used a code reader to determine the cause of the failure. The code reader showed that there was a defect with the vehicle's vacuum pump, brake sensor, and intake camshaft position timing. The vehicle's codes were reset and the vehicle restarted; however, the brake failure persisted. Due to the failure, the vehicle was initially towed to the relative's home and eventually to the dealer. The dealer performed a diagnostic where they discovered metal shavings in the engine camshaft which damaged several parts of the engine. The vehicle had yet to be repaired and remained in the possession of the dealer. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to file a complaint. The failure mileage was approximately 100,000.
Was driving (in July) through a parking lot when brakes became hard to push. After stopping car, it would not start and went into battery save mode. Car was towed to Chevy dealership in Paducah, Ky. Vacuum pump was replaced and damage to cam shaft and timing chain. Problem was fixed after about $5800 of repairs. Now 2 months later, was driving and noticed “service brake assist” light came on, and brakes were hard to press. Luckily was at a low speed and able to pull over on the side of the road. Car was towed to the local Chevy dealership in Hopkinsville, ky. It is currently waiting for diagnosis of probably the same issue. first incident happened in July, 2nd was at the end of august.
I have 149,000 miles in this car. In my lifetime of being the one owner and purchasing this car brand new the vacuum pump has failed five times. Twice now resulting in blown engines. And still no recalls.
The contact owns a 2020 Chevrolet Equinox. The contact stated while driving approximately 45 MPH and approaching a red traffic light, the brake pedal was depressed but the vehicle failed to respond. There was no warning light illuminated. The contact swerved to the left and overtook the vehicle in front of her vehicle, drove off the road, and drove in circles on the grass until the vehicle stopped. The contact then parked the vehicle. The contact stated then resumed driving to the residence at slower speeds. The contact stated that the failure had been recurring while driving. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not notified of the failure. The failure mileage was approximately 106,070.
Power Train: I purchased a 2020 Chevrolet Equinox LS in January 2023. For the past 4 to 7 months the vehicle has completely lost power in traffic several times and I'm not talking about AutoStop and Start, the battery life was great, with no dead cells at all. The vehicle went dead, absolutely no power source inside or outside the Equinox, the SUV could not be placed in neutral to move it out of traffic, nor would the remote key work. The Equinox remained in this mode for approximately 20 minutes. During each incident, the vehicle displayed no warning signs or check engine symbol on the dashboard display before or after each episode. Fuel/Propulsion System: Upon placing unleaded fuel in the vehicle and starting up the ignition, the SUV would start vibrating, sputtering, jerking, and popping sounds. Also, while driving the vehicle upon acceleration at times it seems as if fuel isn't reaching the engine. Brakes: Service Brake Assist may illuminate randomly on the dashboard while on the interstate. These issues has placed and caused my family and I to be in great danger. This is my primary vehicle and I purchased this vehicle because I believed in the reliability of the GM Chevrolet Brand. Not an accident waiting to happen. Yes, the vehicle has been inspected, but please remember if NO CHECK ENGINE LIGHT is illuminating on the dashboard the issues can not be assessed properly!
When first breaking on the exit ramp after a 2 hour ride on highway the rear breaks made a loud grinding sound & took longer to stop with 2 cars in front of mine. I put flashers on & pulled as far to side of road incase I was unable to stop at the bottom of the exit (down hill) to avoid collision with the 2 cars in front of me. Previously my vehicle shown no signs of any issues. There were no sounds coming from breaks, no issues slowing down or stopping, & no lights on dashboard to indicate an issue of any kind. I looked my Chevy Equinox up and saw that there was an isdue with the rear calipers and many had been reported and recalled. My VIN doesn't show my calipers have been recalled. However, the GM site states if there is an issue with the rear breaks/ calipers to report it and Chevy will repair the issue. Many Chevy Equinox owners have taken to the internet to report the same issue, there are also reports that only 166 were recalled. This is clearly a manufacturing error and not normal wear & tear. I bought my 2020 Equinox brand new in 2021, it was unsold in 2020. Please help myself & the other Chevy Equinox owners make Chevy take responsibility & fix this error before people are injured or killed because our breaks give out unexpectedly.
I received a service brake module warning and then the vehicle became difficult to stop. I was not traveling at typical highway speeds at the time, but I was on the highway. After applying extensive pressure on the brake pedal to stop, the engine lost power and stalled. It was towed to a dealership and determined that vacuum booster pump experienced a catastrophic failure.
I was driving and the “service brake assist” light came on and I then the brake pedal became stiff and so hard to push! I was driving on the expressway and almost couldn’t stop my car. No warning at all. It happened as soon as the light came on.
Brake assist fail
I was operating the vehicle when it suddenly shut off in traffic. I attempted to restart the vehicle and received a "reduced engine power" and "Service brake assist" message. The vehicle had a clunky noise and failed to restart. Upon inspection at the dealership, I was told that the vacuum pump inside the engine had exploded and sent metal components throughout the engine system. No previous issues or warnings were present prior to this failure. This is a safety issue as the vehicle gave no warning signs of issue and shut off in the flow of traffic with very little ability to brake or steer out of the way.
The Vacuum pump has exploded 3 times, twice under warranty and now outside warranty. This time it has taken out the camshaft.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2020 Chevrolet Equinox?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history