ABS Valve Body / Pump Harness chafed through brake hydraulic line near transmission crossmember. This resulted in a hydraulic leak and loss of brake pedal feel / partial loss of brakes. Fortunately failure occurred in the driveway--I had 4500 Lbs of sailboat trailer hitched to the van and was about to go on a long trip. Design issue. Wiring harness should not be located so as to chafe on hydraulic lines. This is not the first chafe related failure on this vehicle.
Chevrolet Express abs comes on
39 of the 651 owner complaints about the Chevrolet Express describe aBS light or ABS activating, most of them for the 2017 model year.
- owner complaints
- 39
- worst model year
- 2017
- typical mileage
- 34,000
Is there a fix? There are 3 recalls for this area of the car. See below
By model year
- 20231
- 20211
- 201711
- 20163
- 20121
- 20103
- 20081
- 20073
- 20061
- 20051
- 20041
- 20032
- 20021
- 20011
- 20003
- 19992
- 19973
Often reported together
Pulling 5Fire or smoke 3Brake failure 3Stalling 2Spongy pedal 2Check engine light 2Ball joint 2Adaptive cruise 2
Trouble codes mentioned
C0110 1
What owners say
The car always turns on the slippery road warning light when I drive over 60 miles per hour and the wheels lock up. Sometimes, the ABS warning light also comes on, along with error messages saying 'Service Traction Control' and 'Service StabiliTrak'.
This is a Forest River Sunseeker Motorhome on a 2021 Chevrolet Express chasis. On Friday, [XXX], after being in stop and go traffic for 10-15 minutes on [XXX] driving at 65 mph, a smell of burning brakes started filling up the motorhome. Then the vehicle started to wobble and the ABS light came on. Pulled over to the side and while applying brakes the vehicle shook/wobbled. Drove to a NTB tire store and the manager indicated it was not the tires but smelled like the brakes burning and advised not to drive it. Had it towed to Monument Chevrolet and they reported they could not replicate the problem. No repair. On [XXX] after numerous trips in RV, the exact same thing occurred. This time drove it to Monument Chevrolet with dash lights on: ABS, brakes, etc. and demanded a repair. They replaced left front speed sensor for $406.00. On [XXX], coming off of a mountain, the exact problem happened again: wobble, ABS light, and this time the Stabilitrak sensor on. The dealer in Arkansas ran a history report and said the right front speed sensor had failed. No repair available because of the size of the vehicle. Now scheduled to return to Monument Chevrolet 01/09/2025 to hopefully be repaired. Chevrolet has recalled 638,000 of the vehicles with identical issues but mine not on recall list. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The ABS/Traction control system has malfunctioned 3 separate times since purchase of the vehicle in 2017. The indicated fault is code C0110-04, Pump Motor Circuit Open. This fault has required the replacement of the Brake Control Computer (GM part# 19435407) and the Hydraulic Control Module (GM part# 25879231). The first malfunction occurred in October 2020 at 48,594 miles, the second was November 2022 at 91,621 miles with the most recent fault in August 2024 at 147,411 miles. The fault has not affected the ability to stop the vehicle, but it does render the ABS/Traction Control System inoperative. The vehicle is a travel van with the majority miles being highway miles (very little city driving)
The contact owns a 2017 Chevrolet Express. The contact stated that while driving at approximately 35 MPH, the ABS inadvertently engaged, and the vehicle pulled to the left side. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the electronic brake control module assembly needed to be repaired. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 136,000.
ABS Module Broken. Needs repair. No part available. Part Number 84055065 needed. Vehicle was on highway slowed on to onramp when ABS went off for no reason. Van Pulled to right drastically.
Part Number 84055065 The ABS Module is defective and can not replace.
ABS Module Blown. Van's ABS goes off when not needed. Pulls to the right. Part Number 84055065 needed. no replacement available.
Vehicles ABS went off while slowing to stop sign. Repair needed ABS Module part number 84055065. No part available through GM. Pulled vehicle from road as its super unsafe.
Vehicle nearly went off road from ABS prematurely activating. ABS module needed. part number 84055065 unavailable through GM. Parked Van as it is too dangerous to drive.
Related recalls
Service brakes, hydraulic
- What is wrong
- Certain trucks, sport utility vehicles, and vans equipped with bosch hydro-boost brake assemblies, the hydraulic brake booster pressure accumulator may crack and separate from the hydro-boost assembly during normal operating conditions.
- Risk
- If a separation occurred and the hood of the vehicle were open, fragments from the accumulator could cause injury to people in the immediate area. The presence of this crack or fractured surface could allow the hydraulic fluid to leak from the accumulator circuit of the booster assembly. The loss of fluid would cause increased steering and braking effort and a crash may occur without prior warning.
- Remedy
- Dealers will test the hydro-boost assembly for functional operation of the two-function valve. If the hydro-boost assembly fails the test, dealers will replace the assembly free of charge. The recall began on march 23, 2005. Owners may contact chevrolet at 1‑800‑630‑2438, gmc trucks at 1‑866‑996‑9463 and hummer at 1‑800‑732‑5493.
Recall number 05V043000 · Recall details
Service brakes, hydraulic
- What is wrong
- Certain sport utility vehicles, pickup trucks, and passenger vans fail to comply with the requirements of federal motor vehicle safety standard no. 135, ?passenger car brake systems.? Some of these vehicles were produced with an out-of-specification brake hydro-boost housing relief valve bore.
- Risk
- Consequently, the valve o-ring seal may fracture. Steering efforts may be slightly increased while braking or parking. Under certain driving conditions, a fractured seal may require a slight increase in the applied brake pedal effort to achieve the same vehicle deceleration rate as prior to the seat fracture.
- Remedy
- Dealers are to replace the hydro-boost relief valve. The recall began on june 18, 2004. Owners should contact cadillac at 1‑866‑982‑2339; chevrolet at 1‑800‑630‑2438; gmc at 1‑866‑996‑9463; or hummer at 1‑866‑486‑6376.
Recall number 04V045000 · Recall details
Service brakes, hydraulic: foundation components: disc: rotor
- What is wrong
- Vehicle description: light duty pickup trucks and multi-purpose passenger vehicles. One or both front brake rotor/hubs were built with an out-of-specification gray iron that can fail during the life of the vehicle.
- Risk
- If a driver continues to drive with a cracked rotor, the cracks could continue around the wheel mounting bolt circle and ultimately result in a wheel separation.
- Remedy
- Dealers will inspect the rotors for a core date of "287" and, if found, replace the rotor.
Recall number 98V033000 · Recall details
Questions about the Chevrolet Express abs
Why does the abs come on in the Chevrolet Express?
Owners who report it most often also describe pulls to one side, fire, smoke or burning smell and brake failure, and the codes they mention most are C0110.
Which Chevrolet Express years have aBS light or ABS activating problems?
The model years with the most reports are 2017 (11 complaints), 1997 (3 complaints) and 2000 (3 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used Chevrolet Express?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history