1994 Chevrolet G Series technical service bulletins
28 technical service bulletins and manufacturer communications cover the 1994 Chevrolet G Series.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Special coverage (revised part information)
- Expanded Availability for Remanufacture and Return (R&R) Electronic Control Modules
- A failure of the electronic diesel fuel injection pump, leaking to complaints of poor performance or fuel...
- Special policy adjustment for vehicles experiencing a failure of the electronic diesel fuel injection...
- Some customers may experience a failure of the electronic diesel fuel injection pump
- Information used when diagnosing noise conditions such as engine rattle noise, spark knock at 2000 - 2500...
- Special policy adjustment for vehicles experiencing a failure of the electronic diesel fuel injection pump...
- Some vehicles may experience a failure of the electronic diesel fuel injection pump, leading to complaints...
- Deductible reimbursement clarification and VIN breakpoint correction to 00064 - special policy adjustment...
- Failure of the electronic diesel fuel injection pump, leading to complaints of poor performance or fuel...
- Subject regarding a hard, no start or excessive gray or white smoke condition on start up after recent...
- Fuel solenoid driver located on the side of the fuel injection pump failed, causing vehicle to no start or...
- Comments of a no start, stall condition
- No upshift/2ND gear only after cold start-intermittent DTC 87 - high ratio error (replace eprom)
- Engine hard to start (replace fuel pump pulsator)
- Insufficient a/c performance and/or noisy compressor clutch due to premature wear of the compressor shaft...
- Starter motor continues to run or crank after the engine is running or turned off (solenoid ground wire)
- Transmission leak at rear extention housing and prop shaft
- Cold engine knock
- Announcement of manufacturer's product campaign 94-C-57
- New cast iron exhaust manifold and stainless steel gasket to correct engine noise condition
- Rear and side cargo door latch rattles
- Transmission extention seal leaks
- Oil pressure gauge reading concerns
- Revision to product emission campaign 94-C-28 - emission label error
- Message to dealers announcing second phase mailing of manufacturer recall 94C57
- Letter to dealers explaining general motors position with campaign 94C57
- Insufficient heater performance
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Chevrolet G Series?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history