The front passenger's door latch broke under normal wear and tear because it is made of plastic. You cannot open the door from the inside once it is broken, it has to be open from the outside or you have to be tall enough to reach over to the outside door handle and open the door. Lot of complaints because the only way to repair broken handle is to replace the entire door panel a cost of over $250.
2007 Chevrolet HHR locks complaints
Page 2 of 2: complaints 11 to 25 of 25, newest first, as owners wrote them.
Tl* the contact owns a 2007 chevrolet hhr. The contact stated that the driver side door handle fractured from the vehicle while attempting to exit. The contact was unable to open the driver side window and had to climb to the passenger side door to exit the vehicle. The contact spoke with a dealer and was told that the entire door panel would have to be replaced and even although the vehicle was under warranty, the door handle was not and would be the liability of the contact. The failure and current mileage was 72,000.
Driver door interior door handle snapped off. Dealer will not help. Entire door panel must be replaced. Cannot guarantee recurrence.
Tl*the contact owns a 2007 chevrolet hhr. While the vehicle was parked, the front passenger attempted to get out and the door handle broke off. A few months later, the driver side handle broke off as well. The contact had to roll the windows down to use the outside latch to get out. The vehicle had not been inspected or repaired. The contact called the manufacturer who offered no assistance. The failure mileage was unknown and the current mileage was 56,947.
I am an owner of 2007 hhr with 51,000 miles. I locked my car went into the store came out and the driver side door would not open. The remote button would work the lock up and down button but still the door would not open from the outside handle. I then put the key in the door and still it would not open. The lock flips up and down with the key and the remote but the door handle will not open the door. The handle is not broken. So I entered the car by the passenger side door, crawled over the seat and shift level to get behind the wheel to drive home. After arriving home I could not get out of my drivers side door. It would not open from the inside, so I had to crawl over the shift and seat to the passenger side to exit the vehicle. I have a torn muscle in my arm so it hurt to do all this. I took the car to the dealer and they replaced the latch inside the door for $397. That's outrageous. That was 7 days ago. Today, I went to town with my husband and the passenger side door would not open. Now I could not exit on the passenger side. This is crazy. Same thing on the passenger door. Will not open from the inside or outside and I had to crawl over to get out. This is a severe safety issue and for people who have disabilities it is definitely a safety issue. Also, if we were to have any accident or emergency we would not be able to get out. What if a child were in that seat. The dealership said they did not have anyone with this issue but after looking on the internet it is a very big issue and needs to be recalled to fix it before someone is killed or seriously hurt by not being able to open the door to get out in any situation. The door will not open from inside handle or outside handle so you are stuck inside or locked outside.
Tl*the contact owns a 2007 chevrolet hhr. While the vehicle was parked the contact attempted to open the drivers side door and the latch broke off. The front passengers side door latch broke on another occasion. The contact stated that in order to get out of the vehicle the doors must be opened from the outside. The vehicle was not taken to the dealer to be repaired. The vehicle will be taken into the dealer at a later time. The manufacturer was not contacted. The approximate failure mileage was 40,000.
Key will not remove from lock in ignition when car is placed in park.
2007 chevrolet hhr the shifter will not lock into gear and key is stuck in ignition. This is a major safety hazard as seeing while you are driving you can go into any gear at anytime if it is accidentally bumped which can cause a major accident. I had to unhook the battery to turn everything off since the key will not come out of ignition.
Tl* the contact owns a 2007 chevrolet hhr. The contact stated that when opening the front passenger side door, the latch fractured and the contact was unable to exit the vehicle due to a disability of her left arm. The vehicle was inspected by the dealer and informed the contact that they would not replace just the handle but would need to replace the entire door. The vehicle was not repaired. The failure mileage was approximately 71,000. Updated 02/08/11*lj the consumer stated she was involved in an accident and became stuck in the vehicle due to the failed latch. Updated 04/21/11
Chevrolet hhr-2007 with 57,000 miles - the inside door latch on the driver's side broke. I found out that the hinge on the latch is plastic and to repair it I have to replace the entire door panel . I am partially disabled and recovering from knee replacement. This is a severe design problem. Many people who buy this car purchase it because it is easy to get in if you have ambulatory problems. Please help me and other consumers.
Tl*the contact owns a 2007 chevrolet hhr. The contact stated that the inside door handles were made of plastic; the driver side door handle broke suddenly when he opened it. The contact believed that the door handles were a safety hazard. The vehicle was taken to an authorized dealership who informed him that the entire door panel had to be replaced to fix the door handle. The vehicle was not repaired. The contact called the manufacturer who offered no assistance. The VIN was unavailable. The current mileage was approximately 60,000. The failure mileage was approximately 58,000.
2007 chevy hhr interior door handle broke when trying to open the door. No longer can I exit the vehicle without rolling down the window and opening the door from the exterior handle. Unable to replace just the handle, the only way to fix the piece of plastic that is holding the door handle together is to replace the entire door panel. It is unacceptable that a cheap piece of plastic is controlling the opening of the door. With this piece broken, I am unable to exit in the event of an accident if the windows can't be rolled down.
When putting the car in park, the key would not remove from the ignition. Also, the car could be shifted through the gears without pressing the button on the shifter. There is a safety issue in that the gear shift can be bumped into and out of various gears. After opening the center console, I discovered that the plastic plunger that goes down through the shifter had broken, and in the process allowed the metal pin that closes the contact with the ignition to come loose. This has occurred approximately 6 - 10 times in the past 2 weeks, with increasing frequency. I called the local dealership, terry labonte chevy in greensboro, nc only to be told that I had probably spilled some liquid.
2007 hhr ls - when trying to exit the vehicle the front driver side door handle broke. Thus making the only way to exit the vehicle is to roll down the window and access the exterior door handle. In the event of a serious crash or accident the driver would be trapped in the vehicle. Gm's fix for the broken door handle is to replace the entire interior door panel at a cost of $450. The dealership does not stock this item and it has to be ordered which could take up to 2 weeks. Gm's poor design of the door handle mechanism could lead to an tragic event and is also a rip off to the consumers who purchased this vehicle. This door handle mechanism needs to be redesigned and recalled by gm before someone does become trapped and killed.
2007 chevrolet hhr ls while attempting to exit vehicle, with interior door handle in open position and foot on brake, I shifted into park and the automatic door locking/opening mechanism feature broke the handle rendering exit from interior impossible without lowering power window and reaching from through open window to access exterior door handle. In the event of a serious crash this will in effect trap the driver in the vehicle. Gm refused to acknowledge this serious defect in design which has occurred many times according to public reports. The door handle is available only through gm dealers at a quoted price of 450.00 dollars . For a plastic door handle that broke due to poor design.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2007 Chevrolet HHR?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history