Gasoline leaking from drivers rear tire area. Caused by rusted fuel lines. The fuel lines are located next to the muffler. Very dangerous situation. I took it to chevrolet dealership and was told over $1000 to repair this fuel line. Spoke with the service technician and he said that gm specifically states no warranty on fuel lines in areas of the country that use salt and sand to treat the roadways. I live in massachusetts and we use sand and salt on the roads. Gm is aware of this rusted fuel line problem and will not recall and replace.
2008 Chevrolet HHR fuel system complaints
Page 4 of 4: complaints 71 to 85 of 85, newest first, as owners wrote them.
Fuel leak on car. Noticed problem starting car and then a small puddle of gas under car after car was parked.
On july 31, 2017 I noticed a gas ordor coming from the car , when inspected I notice a gas leak on the back drivers side. Looking forder into the matter the car was jack up to see we're the leak was, the fuel lines were in a terrible shape, rusted out, which then created a crack and fuel was leaking. I believe this should be a safety recall, it is absolutely dangerous big fire hazard . We did get the car repair and the fuel lines were replaced.
Tl* the contact owns a 2008 chevrolet hhr. The contact stated that while driving at 70 MPH, the accelerator pedal was applied but it went to the floorboard. Additionally, the contact stated that there was an abnormal odor of fuel outside the vehicle and noticed fuel was leaking from underneath the vehicle. The vehicle was taken to an independent mechanic. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 101,000.
Starting smelling fuel about 2 months ago and now it's really strong. Looks like the line is rusting out near rear tire. I would think that is very unusual for a vehicle that is only 9 years old. After researching online I am finding a lot of hhr owners having the same issue. This should be a recall in my opinion and is dangerous I would think.
Started getting a gas smell in the garage when comming back home. Today I noticed that it was dripping gas from under the driver side passenger seat. Fire hazard. This car is only 8 years old, have never had another car that had a fuel line leak. Leaking raw fuel to the ground when running luckily I saw it and will not drive the car till I get it fixed.
I noticed strong gas smell while car is running, exhaust making funny sound. Fuel line leaking on drivers side rear, right next to exhaust pipe. This could have been very serious injury if car had exploded or caught fire!
I bought this vehicle new...it is now 8 years old...170,000 miles ...it is driven in the northern il area mchenry county ...I put about 80 miles per day on the unit...for the past 4 months my fuel mileage has dropped from 26 mpg to 22mpg...so I tuned up the unit and the mpg remained the same...on 11-16-2016, I was driving down route 12 headed home ,my right rear tire sensor came on so I pulled into a best buy parking lot to check the tire, it might be going flat. As I was down on the ground looking for a nail in the tire , I saw a wet spot on the pavement in front of the left rear tire... I went there to check out what that might be and it was fresh gasoline...then looking under the vehicle I saw a pulsating flow of gas coming from the steel fuel line mounted to the bottom of the floor at a plastic retainer holding 2 fuel lines coming from the fuel tank headed to the engine along with 2 brake lines...I drove the hhr home and inspected the fuel line carefully... It was rusted completely thru inside the plastic line retainer...the retainer seems to be the problem...it catches and holds road salt inside the retainer...it took 8 years to rust completely thru the fuel line...a great fire hazard...I'm very lucky that my tire sensor made me look under the hhr and see gasoline leaking... I called gm customer service and they will not except responsibly for rusted fuel lines... Its not under warranty...I told them that it took 8 years to rust...they said that it has 170,000... It past its life span...it's 8 years old...what do I expect...I told them that I expect fuel lines to last for ever... It's the 21 century...interesting the 2 metal brake lines in the same retainer are in perfect condition...they seem to be powder coated, so why not the fuel lines. 2 things that we need, is to stop the vehicle, and no gasoline leaking on the pavement ...I have pictures of the fuel line.
Fuel lines in front of drivers side rear wheel completely corroded thru. Partially due to heat shroud, rubber covered with foil, installed due to lose proximity to exhaust pipe. Return line started leaking,pressure line broke in half during removal. Chevy disavows all responsibility although the rest of the lines are not rusted. Heat shroud contained road salt, sand and gravel when removed. Corrosion was exfoliate in nature. On line research shows at least one instance of a hhr catching fire due to this. Problem was discovered after smelling fuel and discovering fuel leaking under vehicle. Author of report has been working on cars for 45 years and has held an a&p certificate for over 40 yrs. Have never seen 8 year old fuel lines in this condition. Black coated brake lines running next to fuel lines were completely unaffected. As previously stated there are many texts online concerning this issue, all received the same lack of concern from gm, including their customer service line.
I started smelling gas inside/outside of vehicle after shutting it off. When starting the vehicle the exhaust sounds rough. I took my vehicle to an independent mechanic and a chevrolet dealership and found that the gas lines near the rear driver side tire are rusted and have also damaged my exhaust manifold which is also causing the vehicle to sputter when accelerating. Because the problems are due to gm's poor job of designing this unsafe vehicle this issue should not be the vehicle owners responsibility, it should be recalled.
Started smelling gas smell when walking up to vehicle after sitting...including smell within the cabin. Did a little research and found many complaints about rusted gas lines near the rear driver side tire and sure enough when looking there I could now see on the ground where gas was dripping. The lines are partially covered with what seems like a heat shield...yup...my guess would be because the hot exhaust pipe runs near it. The heat shield I believe seems to hold moisture against the lines and condensation and I'm guessing it defeats the purpose when the line is now rusted through and is dripping gas near the exhaust pipe. Very poor and dangerous design.
Since2006 fuel lines continue to rot out spraying fuel on exhaust
Tl* the contact owns a 2008 chevrolet hhr. While in park, the vehicle failed to start intermittently. In addition, the contact noticed fuel fumes emitting from the vehicle fuel was leaking from underneath the vehicle. The failure recurred on numerous occasions. The vehicle was taken to an independent mechanic who diagnosed that the fuel lines were corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 83,000.
My chevy hhr developed a leak in the fuel line - just behind the rear driver's side tire. When looking this up on line, I was shocked at how many others had reported the same complaint. The leak was only visible to me when the car was parked on an incline (spotted 3-25-15). However, it had trouble starting for about 2 weeks prior - the dealer confirmed this was due to gas leaking out the line. The fuel line and the canister purge line both needed replaced.
I took the car into the shop on 11/15/14 because of a loud exhaust sound. The mechanic advised the flex pipe was leaking and the flex pipe and catalytic converters (2) would need to be replaced. The cost is estimated at about $900. If the car is in idol, the exhaust seeps into the car and could cause carbon monoxide poisoning and death, if the windows are not cracked to allow for ventilation. Unfortunately, we cannot afford this repair at this time. The car is 6 years old and should not be falling apart piece by piece as it has been over the last couple of years. This part should be recalled, or should I say the entire car, b/c it has had so many recalls in the last couple of years.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2008 Chevrolet HHR?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history