I've replaced battery, head gaskets, overflow tank, air system connectors, water pump, pcv valve, evap canister, spark plugs, spark plug wires, radiator, camshaft sensor, coolant temp sensor, but my car is still leaking coolant from underneath lower intake manifold and isn't trying to start. I've spent over $2000 and still haven't seen results or got it to fully function. Last time I drove it was on regular georgia roads going to and coming home from work when it over heated twice going both ways.
2000 Chevrolet Malibu fuel system problems
79 complaints (9% of all complaints for this car). Typical mileage when it fails: 60,000.
- owner complaints
- 79
- of this car's complaints
- 9%
- typical mileage
- 60,000
- crashes
- 0
- recalls
- 1
Which part fails
- Delivery: fuel pump27
- Storage: fuel gauge system7
- Delivery5
- Fuel injection system3
- Storage: tank assembly: filler pipe and cap2
- Fuel injection system: injectors2
- Delivery: hoses, lines/piping, and fittings2
- Storage: tank assembly1
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Chevrolet Malibu fuel system problems in other years
Specific symptoms reported on the 2000 Chevrolet Malibu fuel system
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
Fuel system, gasoline: storage: tank assembly: filler pipe and cap
- What is wrong
- Certain passenger vehicles fail to comply with requirements of fmvss no. 301, "fuel system integrity." the fuel fill fitting is not properly secured to the fuel tank. In that condition, fuel leakage would exceed the permissible amount in an fmvss test. Fuel leaks may occur, particularly after refueling or when the tank is more than half full.
- Risk
- If an ignition source were present, a fire could occur.
- Remedy
- Dealers will inspect the fuel tank and replace it if necessary.
Recall number 99V302000 · Recall details
Related investigations
Erratic fuel gauge
Odi opened ea 02-028 to review complaints of consumers reporting that their fuel gauge was incorrectly displaying the amount of fuel in the gas tank.the fuel gauge receives an electrical signal from a fuel tank sending sensor circuit card.a float arm in the tank moves electrical contacts that rub against the card as the level of fuel rises and falls.disruption of the electrical signal (such as caused by corrosion of the circuit card) will cause incorrect readings to register on the fuel gauge.gm reported in their response to odi dated january 13, 2003 that the primary cause of erratic fuel gauge operation is excess elemental sulfur in fuel.gm reported that abnormal levels of sulfur sporadically occurred in certain parts of canada and the u.s. Resulting in reports of fuel gauge malfunction.gm modified the sending sensor for vehicles built after october 2000.it made a second sensor modification for vehicles built after january 2003.gm also issued a customer satisfaction campaign (gm number 00101) in december 2000 for u.s. Customers in the state of maine and issued several service bulletins informing dealers of the availability of sensors with improved corrosion resistance.the complaint trend indicates that complaints peaked in late 2000 to early 2001.warranty claims declined since peaking in april 2002.based on the number of complaints and the indication of a declining trend, further use of agency resources does not appear to be warranted.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.
EA02028
Engine stall due to fuel starvation
Odi opened pe02-066 to evaluate the scope and consequence of engine power-loss due to fuel starvation induced by in-tank modular fuel pump strainer restriction.the subject pumps use an external ?sock? Strainer to filter fuel flowing to the pump inlet.this filter can sometimes become clogged, resulting in a reduced flow of fuel to the engine.gm has subsequently modified the strainers to reduce this restriction.analysis of the odi complaint database shows that despite these restrictions, the subject vehicles stall at a rate that is comparable to those of many peer vehicles.additionally, none of the relevant warranty repair rates exceed 1% at 36 months of exposure.one related crash involves a stalled vehicle that was rear-ended on the roadway, while the remainder involved minor collisions or scrapes.the sole injury consisted of bruising from a low speed frontal crash. Given these circumstances, further expenditure of agency resources is not justified in this matter.the preliminary evaluation is therefore closed.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency will take further action in the future if warranted.
PE02066
What 2000 Chevrolet Malibu owners say
Most recent owner complaints, unedited.
Tl* the contact owns a 2000 chevrolet malibu. The contact smelled fuel when the vehicle was parked in the garage. There was no warning indicator illuminated. The dealer and manufacturer were not notified. The vehicle was not diagnosed or repaired. The failure mileage was approximately 137,000.
Leaking fuel under car between driver side doors. Just not sure if part of fuel system recall that has been on other malibu
My car shuts off while I'm driving it, when I try to turn it on it won't turn on. I could smell gas but it won't turn on. It's a hazard when I'm on the highway and it just cut off on me and I'm stuck in the middle lane with incoming traffic. I took it to a mechanic and could not find any issues with any other parts of the vehicle my fuel pump is in great condition my tune ups are up to date I don't know if it is the anti-theft affiliated with my key ignition please advise.
Tl* the contact owns a 2000 chevrolet malibu. The contact stated that there was a fuel odor and discovered that fuel was leaking from under the vehicle. The vehicle was taken to an independent mechanic, who inspected the vehicle and indicated that there had been fuel leaking on the fuel lines. The vehicle was not repaired. The contact was not included in the federal safety agency campaign number: 99v302000 (fuel system, gasoline). The manufacturer was notified of the failure. The failure mileage was 152,000.
Tl* the contact owns a 2000 chevrolet malibu. The contact stated that there was excessive rust below the fuel tank. In addition, there were holes. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 94,625.
Tl* the contact owns a 2000 chevrolet malibu. While driving at approximately 30 MPH, the vehicle stalled and the anti theft device light illuminated. The failure recurred several times. The vehicle was taken to a dealer where it was diagnosed that the fuel pump and the fuel regulator needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was made aware of the failure. The failure mileage was 120,000. The VIN was not available.
Tl* the contact owns a 2000 chevrolet malibu. While the vehicle was parked, a strong odor of fuel emitted outside the vehicle. There was a recall regarding the federal safety agency campaign number: 99v302000 (fuel system, gasoline); however, the VIN was not included. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The approximate failure mileage was 70,000.
Bought vehicle on sept 3 2014 within a couple weeks while driving car literally just shuts off. Steering locks up, electrical shuts down. Let car sit for a few minutes and will restart. First attempt to fix was new fuel pump. Ran great for 2 weeks then suddenly started again. There is no consistency to the problem-- full tank, empty tank, different speeds, rain, dry. Side roads, main roads. The problem is not predictable. Second solution new ignition module. Great for 3 weeks. Died in the middle of driving 40mph at night. When it dies very hard to get safely off road. Could not get the car started for more than 40 min. Went fine for a few days then happened 4 times in one trip less than 20 miles. First couple times started with in a few minutes, next had to sit for 15+ minutes huge safety issue to have car literally shut down in the middle of driving. Possibility to get struck by another vehicle. This is a known issue and yet can find no one who has satisfactorily fixed it.
My car has expereinced trouble starting due to this ignition swirch, recall. I have been stranded multiple times. I have been to service stations and the mechanincs could not figure out what was going on, causing me to put out money for a new starter, a new electrical system, new fuel pump etc. The problems that I have faced were due to the ignition switch not being in the "run" position. How can I ever be compensated for all of the repairs that were not really needed on my car due to some major corporation being greedy and keeping it's customers in the dark about the reality of the situation. Gm has been putting me in danger for years now, and I have to continue to wait for the parts to be made to correct their error. I have been stranded on the road and in undesired places, this is unforgivable!
Questions about the 2000 Chevrolet Malibu fuel system
Does the 2000 Chevrolet Malibu have fuel system problems?
Owners have filed 79 complaints about the fuel system of the 2000 Chevrolet Malibu, 9% of all its complaints.
At what mileage do 2000 Chevrolet Malibu fuel system problems start?
The typical (median) mileage in owner complaints is 60,000 miles.
Was there a recall on the 2000 Chevrolet Malibu fuel system?
Yes, 1 recall: 99V302000. Check your VIN to see if your car still needs the free repair.
What year does the Chevrolet Malibu have the most fuel system problems?
The Chevrolet Malibu model years with the most fuel system complaints are 2018 (101 complaints), 2006 (96 complaints) and 2007 (87 complaints).
Other 2000 Chevrolet Malibu problems
Brakes 250Lights 241Electrical 199Engine 193Steering 45Suspension 33Airbags 31Tires 30Body 25Transmission 25Acceleration 21Visibility 11Locks 6Seat belts 2Seats 2Driver assistance 1Wheels 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2000 Chevrolet Malibu?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history