2000 Chevrolet Malibu recalls

What is wrong

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Risk

If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy

GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

Recall number 14V400000 · Recall details

What is wrong

Certain passenger vehicles have hazard warning switches that may experience solder joint cracking caused by rapid temperature transitions and the soldering process. If solder joint cracking occurs and results in an open circuit, the turn signals/hazard lamps become intermittent or inoperative.

Risk

When the turn signals are inoperative, the driver cannot use them to signal intent to turn that could result in a crash.

Remedy

Dealers will replace the hazard warning switch. Owner notification began on february 5, 2004. Owners should contact chevrolet at 1‑800‑630‑2438, pontiac at 1‑800‑620‑7668, or oldsmobile at 1‑800‑630‑6537.

Recall number 03V327000 · Recall details

What is wrong

Certain passenger vehicles fail to comply with requirements of fmvss no. 301, "fuel system integrity." the fuel fill fitting is not properly secured to the fuel tank. In that condition, fuel leakage would exceed the permissible amount in an fmvss test. Fuel leaks may occur, particularly after refueling or when the tank is more than half full.

Risk

If an ignition source were present, a fire could occur.

Remedy

Dealers will inspect the fuel tank and replace it if necessary.

Recall number 99V302000 · Recall details