Radiator rust out, and the rust spread in the entire engine.
1996 Chevrolet S10 engine complaints
Page 3 of 4: complaints 41 to 70 of 72, newest first, as owners wrote them.
Vehicle rides great. Just stays in the shop more than on the road! No safety defect indicated in the summary.
Fuel injection failed.
The engine was leaking oil from the lines in front, near the radiator that is located over the steering lines. The rubber block used to hold the oil cooler lines in position slipped, allowing one line to contact the steering gear, causing a wear point. This allowed the oil to leak as engine ran. Vehicle set up for heavy duty hauling.
Coolant system turns colors and gets griddy. Manual states no maintenance for 5yrs or 50,000 miles. Manufacturer contacted, with case #990212859, nothing done to remedy problem. Problem still exists.
Timing chain noise conditions. Inspector from ge capital inspected the vehicle based on the extended warranty contract. Inspector indicated that oil change maintenance had not been maintained on vehicle and indicated oil was very black. Oil changes were done on this vehicle every 3,000 miles. Self-maintained vehicle for oil changes. Last oil change: 35,718. Oil used was western auto oil, 10w30 advan. Technical service bulletin 87-61-21a, april 1998, subj: timing chain noise condition (replace timing chain). Condition: vehicle may exhibit a clattering noise at idle speed originating from the timing chain and front cover area. Chain wear in excess of the maximum travel of the timing chain tensioner may create noise that may be objectional to some customers. Cause: lack of regular maintenance, as ref in owner's manual and the resultant lack of lubrication and buildup of deposits inside the engine may accelerate wear of the timing chain. In addition, there is a small lubrication hole in the front oil passage plug that could become blocked with debris if proper engine maintenance is not followed. Correction: if the owner of the vehicle indicates a noise concern, inspect the timing chain and tension. In addition, confirm oil flow from the front oil passage plug and replace the timing chain, timing chain tensioner, and both the camshaft and the crankshaft sprocket if necessary to correct the noise.
Intermittently while driving vehicle stalls unexpectedly which may cause an accident. Been to dlr numerous times. Dealer cannot determine the problem. Problem still exists. Please provide further information.
Vehicle expriencing intermittent stalling problem while driving. Dealer notified ,and informed consumer that the problem could not be duplicated. Seeking help from the federal safety agency in this mater.
When letting off the gas, vehicle will cut off and sometimes the vehicle will stall, which can result in an accident. Consumer lost power, vehicle kept slowing down. Dealer can't determine the problem.
The vehicle cuts off at high and low speeds, and takes a few minutes to get started again. Dealer has replaced the computer 3 times.
Countless calls to dealer and manufacture does not produce results.
Check engine light illuminating when no problems are found.
Oil cooling line failed.
Engine failed.
Engine problems.
Engine stalls, causing loss of control of steering/brakes.
Serpentine belt failed.
Engine valve guide seals failed.
Brake system fails intermittently.
Oxygen sensor malfunctioned, causing vehicle to stall.
Water pump failed.
Replaced noisy engine. Also, replaced leaking transmission/master cylinder/power steering pump. In adition, front strut failed and windshield wipers do not operate properly.
Engine: engine check light comes on and will not go off ,black smoke coming from tail pipe. Vehicel has been in shop so many times and they don't know what the problem is.
While driving, at approx. 60mph, experienced sudden engine shutdown, rendering inoperative power assist/brakes and steering. On 4 different occasions, dealer contacted tech. Asst. Network, was instructed to replace crankshaft position sensor.
Oxygen sensor failed.
Defective engine valve.
Lights flicker on/off.
Engine noise upon acceleration.
Transmission failed.
Vehicle caught on fire while driving in engine compartment.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Chevrolet S10?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history