2006 Chevrolet Silverado 1500 suspension problems

Filed Aug 24, 2026 · Suspension · ID

Purchased these aftermarket nylon rear axle lift blocks (level kit) online . They failed while the vehicle was in motion in the live lane on the highway. I was barely able to pull off the road . These blocks are not safe for regular road or highway use. They failed under normal driving on a otherwise stock 1/2 ton 1500 truck . I could have been on a freeway and or other highway with more traffic and this part could have caused a accident as both of these plastic nylon rear axle blocks collapsed under the weight of the truck.

Filed Sep 15, 2020 · Fuel system, Suspension · 125,603 miles · NY

Due to faulty undercoating from factory the back crossmembers rot and cause shocks to become displaced and gas tank to unsecured along with rear shakels to go threw the bottom of truck bed.... Will cost over $2500 for repairs

Filed Oct 25, 2018 · Brakes, Suspension · PA

Replaced brake lines on a regular basis - undercarriage rotting out

Filed Jul 19, 2017 · Suspension · 52,231 miles · KY

Tl* the contact owns a 2006 chevrolet silverado 1500. The contact stated that while performing regular maintenance that he observed corrosion and a hole on the cross members and chassis without warning. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and stated that the vehicle was not included in a recall, nor covered under warranty. The manufacturer stated that they could arrange to have the vehicle on a rollback to be taken to the dealer and then they patched the contact over to the dealer. The dealer ( walter gm automall 505 n mayo trail, pikeville, ky, 41501) confirmed the vehicle was not under warranty that they could have the vehicle rolled back, however there would be a diagnostic fee. The failure mileage was 52,231.

Filed May 4, 2015 · Suspension · 45,000 miles · MO

Tl* the contact owns a 2006 chevrolet silverado 1500. While the vehicle was parked, the contact noticed that the vehicle was leaking fluid from the bottom. The vehicle was taken to the an independent mechanic where it was diagnosed that the strut system needed to be replaced. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was 45,000.

Filed Aug 5, 2014 · Body, Brakes · 68,000 miles · PA

While looking over my truck prior to inspection I discovered three cross members totally rusted thru. The are also the main supports for the gas tank and the shocks. I have been trying to find replacement parts and the more I look the more I hear how common the rusted cross members are. I went to the local dealers parts dept. And when I asked for cross members he told me which ones I needed and pointed them out on an illustrated brake down. After the truck bed was removed I noticed the emergency brake cable is rubbing against the plastic gas tank and is just about wore thru the tank to about the thickness of a plastic sandwich bag. The cable has also rubbed against it's support bracket almost all the way thru as well as into the cable.

Filed Apr 21, 2013 · Airbags, Brakes · 47,000 miles · NY

Rotten brake lines. I looked at the brake lines while changing my oil. My truck has 47k on it. I called gm. They told me that I had to bring it to a dealer. I did. They confirmed that the brake lines are bad and need to be replaced. $1500 also the transmission cooling lines are leaking. I have been through almost all of the brake problems listed on this web cite. Abs light comes on, twice, 2nd time I replaced the left hub bearing assembly. The 1st time the dealer replaced the front ABS sensors. Air bag light comes on, I replaced a bad front air bag sensor, right side. This truck is turning into a money pit!!!!! This new (rotten lines) issue is a safety issue as was the ABS issue. Gm needs to do a full recall and replace the brake lines before someone gets killed.

Filed Apr 6, 2012 · Steering, Suspension · 23,800 miles · CA

Tl* the contact owns a 2006 chevrolet silverado 1500. The contact stated that when starting the vehicle, the steering catch fractured and caused the wheel to fracture. The vehicle was taken to an independent mechanic where they advised him that the power steering pump failed and needed to be replaced. The vehicle was repaired for the power steering pump. In addition, the contact mentioned that the front suspension was causing wear to the front tires. The vehicle was taken to an independent mechanic where they advised him that the front springs needed to be replaced. The vehicle was repaired for the front springs. The vehicle manufacturer was later contacted and they offered no assistance. The failure mileage was approximately 23,800. Updated 5/11/12 *cn the consumer stated the right front frame cushion is riding on the right front lower a arm. The front suspension is not supporting the weight of the vehicle. Also, the steering gear box has a defected bearing in it which causes is it to catch when moving the vehicle. The extended warranty company and atascadero ford outlet filed chapter 11 bankruptcy. The consumer paid $5,050.00 for the extended warranty. Updated 6/15/2012

Filed Jun 30, 2011 · Suspension · 36,000 miles · PA

2006 silveraldo after 36000 miles both front wheel bearing failed then at 105000 left front wheel bearing failed again I drive mainly on hiways very little side roads.

Filed Apr 4, 2011 · Suspension · 41,780 miles · NV

Tl*the contact owns a 2006 chevrolet silverado 1500. While driving approximately 2 MPH entering a driveway, the contact heard a loud grinding and squeaking noise outside of the vehicle. The vehicle was towed to an independent mechanic for diagnostic testing. The technician stated that the front driver side wheel bearing had fractured severely. The vehicle was repaired. The failure mileage was 41,780.