The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the message "Oil Level Low - Turn off Vehicle Immediately" was displayed. Upon further inspection, the contact noticed a burning odor coming from under the hood, with an abnormal engine oil leak. The vehicle was towed to a local dealer, where it was diagnosed, and determined that the engine oil cooler line had detached. The vehicle was repaired out of pocket. Upon further investigation, the contact related the failure to the Chevrolet Customer Satisfaction Program: N212326940 and Chevrolet Customer Satisfaction Program: N192220080; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 160,000.
2019 Chevrolet Silverado 1500 engine complaints
Page 4 of 15: complaints 71 to 100 of 424, newest first, as owners wrote them.
Oil leaking from the oil cooling lines where the rubber hoses connect to the metal lines. Thankfully caught before the rubber hoses completely blew out of the crimp. GM issued two Customer Satisfaction Programs (N212326940 & N192220080) for this issue, neither of which covered my vehicle. Clearly this was a much bigger issue. This is a safety issue as it can lead to a sudden oil loss, which could lead to a loss of propulsion, possibly leading to a crash. The oil is spread across the under side of the vehicle and could lead to a fire if it comes in contact with the exhaust.
I own a 2019 Chevrolet Silverado with approximately 84,000 miles. Prior to the engine failure, I noticed abnormal engine ticking noise, especially during cold starts. I reported this concern to the dealership during a service visit. The technician verified the engine noise but stated that the noise was normal and no repairs were performed. Over time the condition worsened and the vehicle began experiencing engine misfires and internal engine damage. Diagnostic inspection later revealed oil contamination and cylinder wall scoring requiring full engine replacement. Additionally, while driving on a public street, the serpentine belt suddenly came off the engine without warning. This created an immediate safety concern because the belt powers critical systems such as power steering and engine cooling. Losing these systems while driving could cause loss of vehicle control. At the time of the incident, my children were in the vehicle and there were pedestrians and other drivers on the road. The sudden mechanical failure created a dangerous situation that could have resulted in a crash or injury. No warning lights or messages appeared on the dashboard prior to the engine failure, and the check engine light never illuminated. Because the engine concern had previously been reported and dismissed as normal, the problem continued to worsen until catastrophic engine damage occurred. I am submitting this complaint because I am concerned that this may not be an isolated issue and that similar engine failures could pose a safety risk to other drivers.
Bearing and Engine failure, Had to pay out of pocket for a new engine at 78,000 miles. The problem was diagnosed by my local dealer Denoyer Chevrolet in holland Mi. There was no warning lamps, messages, nor symptoms. Dealer had all the info on date, inspection and repair. Engine failures like this are very dangerous as they can cause catastrophic injury or damage. General Motors should be held accountable and made to pay back customers for there damaged products.
Driving down road Truck quit, no warning. Left granddaughter stranded on road. Towed to gm dealership. Diagnosis was complete engine failure. Vehicle is there now waiting for decision to repair.
motor only has 41000 miles and uses 1 quart of oil every 700 miles
Oil cooler line leak.
I’d like to report a serious, ongoing safety concern with my 2019 Chevrolet Silverado (5.3 V8 53,028 mi) since Dec 2025. Over the last 4 months, I have experienced at least 20 engine failures/loss of power, with no engine light illuminated after restarting truck. These failures result in a complete loss of power, including steering and braking, posing a significant risk of a crash. Chevy said it would be hard to diagnose with no engine warning light on. Feb 24th, engine failure, warning light stayed on and towed truck to Chevy. Truck on standby, repaired Mar 10th, replacing 2 oxygen sensors per Diagnostics. Picked it up on March 11th, but engine shutdown again the same day and 4 additional failures while driving in my neighborhood, making the truck undrivable. I reached out to Chevy service supervisor, Juliana, but have received no response for the last 10 days. I urge the federal safety agency to investigate this defect as it poses a severe safety risk. Thank you for your urgent attention.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated on three occasions while driving at various speeds, there was a clunking or clicking sound coming from the engine compartment, before the vehicle lost power. The vehicle was taken to a dealer where it was diagnosed with engine rod bearing failure. The contact was informed that the rod bearings and engine block needed to be replaced. The vehicle was not repaired and was taken to the residence and parked. Less than a week later, the vehicle was taken back to the same dealer for the repairs. The vehicle was repaired, but the failure reoccurred approximately five months later. The vehicle was taken back to the same dealer where it was diagnosed with an exhaust manifold leak. The contact was informed that the exhaust manifold needed to be replaced. The vehicle was repaired, but the failure reoccurred approximately two months later. The manufacturer was notified of the failure, and a complaint was filed. The failure mileage was approximately 103,000.
Vechile continues to fail oil consumption test, test began 09/2023, and continues to be the issue present day. Engine was replaced 2025, 3-4 months later tranmission went out. Transmission replaced 2025. Oil consumption continues to fail. Dealership chuck hutton 2471 mt. Moriah road, memphis, tn 38115 performed all these services. Safety concern is that the leaking oil pollution is causing harm to me and my family as well as leaving oil residue in the driveway. No warning messages except for when it says add oil, that's when I'm put on notice that the vechile is losing oil. Due to the leaking oil, oil is now mixing with gasoline, indicating there to be an issue with the fuel pump. Now beind directed to replace the fuel pump. This has become very costly for me and my family and continues to be an on-going problem
I am reporting a catastrophic internal engine failure in a 2019 Chevrolet Silverado 1500 at 87,600 miles. Prior to this event, there were NO warning lights or symptoms. While traveling alone during the holiday on a remote, one-lane road with no shoulder, the vehicle suddenly suffered a loss of power. Every warning light on the dashboard illuminated at once, followed by shaking, misfiring, and loud knocking from the engine. Because I was on a one-lane road with no place to pull over, this created an immediate safety hazard for me and oncoming traffic. I had the car towed to the dealership ( where I bought the truck) confirmed the failure was a collapsed lifter and scored camshaft (which i found out to be a known design flaw in the 5.3L DFM engine). The dealer said it was not under warranty. I felt held over a barrel by the dealership; they initially provided an inflated quote and told me it would cost approximately $1,200, not including tax and shop fees, just to put the engine back together if I wanted to tow it elsewhere for a second opinion. I was forced to pay over $8,395 under protest just to regain use of my primary vehicle after 42 days of downtime. Upon completion, the dealer provided a "Lifetime Warranty" on the replacement parts. This is a tacit admission that these components were never intended to fail during the life of the vehicle. GM refuses to include this vehicle in its coverage list, treating a dangerous engine stall as a simple "out of warranty" repair. This is a systemic safety defect that requires a mandatory recall expansion before it results in a terrible accident. My understanding is that a Class Action lawsuit, Harrison vs. General Motors, for this same thing, but they say my car is not in it, i should have been put on notice for this so I could protect myself.
My husband, [XXX] son, my [XXX] mother-in-law, and I were traveling on the expressway at approximately 70 miles per hour in our 2019 Chevrolet Silverado 1500 with the 5.3L engine when the dashboard suddenly lit up with warning lights and alarms. My husband looked in the rear-view mirror and saw a large amount of smoke coming from the truck. We immediately had to cross two lanes of heavy traffic to reach the shoulder and get off the roadway safely. When I opened my door, I could see that engine oil was pouring from the truck and running down the expressway. We were stranded on the side of the expressway for over an hour before my brother was able to come pick us up. The tow truck company advised that it would take several hours before they could arrive. During that time, vehicles continued traveling at highway speeds and did not slow down despite our disabled truck being on the shoulder. The truck was shaking from the wind and force of cars and trucks passing by at high speeds. This created an extremely dangerous situation, particularly with our [XXX] child and my elderly mother-in-law in the vehicle. The truck was eventually towed to a local repair shop, where the mechanic determined that the engine oil cooler line had broken at the crimp, causing a significant oil leak. The repair required replacement of the oil cooler lines and related components at a cost of $2,109.92. Had we continued driving even briefly, the engine likely could have been severely damaged or destroyed due to the rapid loss of oil. This appears to match the known issue described in GM Customer Satisfaction Program N212326940 regarding oil cooler lines detaching from the crimp on 2019 Chevrolet Silverado trucks. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Incident Description: While driving at highway speeds, the oil cooling lines on my vehicle suffered a catastrophic failure, resulting in a total loss of engine oil within seconds. To ensure my safety and avoid being stranded in high-speed traffic, I proceeded less than a quarter-mile to reach the nearest exit. During the cooling process after the vehicle was stopped, the engine seized due to extreme thermal damage caused by the sudden lack of lubrication. Safety Risk: The sudden and total loss of engine oil at highway speeds presents a significant safety hazard. It creates an immediate risk of sudden engine stall or seizure while in traffic, which could lead to a high-speed collision. Furthermore, a high-volume oil leak onto hot engine components represents a severe fire risk. Technical Evidence & Manufacturer Response: There are existing Technical Service Bulletins (TSBs) for this specific vehicle model that explicitly identify these oil cooling lines as a known failure point. These TSBs state that failure to replace these lines can lead to the engine becoming non-functional. Despite this documented manufacturing defect and the clear safety implications of a sudden engine failure on a highway, Chevrolet has refused to provide a remedy, insisting that the engine replacement be paid for out-of-pocket. Requested Action: I am requesting that the federal safety agency investigate this known defect for a potential safety recall, as the failure of these lines constitutes a predictable and dangerous loss of vehicle power and potential fire hazard.
Engine oil cooler line leaking at the crimps.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving approximately 30-35 MPH and exiting the interstate with a speed limit of 55 MPH, the instrument panel, check engine, stability control, and several other warning lights illuminated. The vehicle felt like there was a misfire coming from the engine. The contact pulled into the nearest parking lot and turned off the vehicle. The vehicle was driven to the dealer, while not exceeding 25 - 30 MPH. The dealer diagnosed the vehicle and determined that the camshaft was damaged, and the valve lifters had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer opened a case regarding the failure. The failure mileage was approximately 97,000.
Vehicle info: 2019 Silverado 1500 6.2L engine with 66,xxx miles. On 3/1/26 While towing my small snowmobile trailer I was driving on I-90 with cruise control set at 65 mph. Very suddenly and shockingly I heard an extremely loud knocking noise from the engine. I then witnessed several driver info messages stating things like "low oil pressure" "engine power reduced" among others and a check engine light. Amongst freeway traffic and now under no engine power and coasting I made an emergency lane change out of the passing lane and into the right lane and subsequently on to the shoulder of the interstate. Oil pressure was also noted to be very low during these events. I called a friend to pick me up off the side of the freeway and also had a local towing company get my truck and trailer off the side of the highway asap. This was a dangerous scenario and could've ended much worse. The vehicle is now at my residence and I am not sure what steps to take right now. As I am very aware of the current recall on similar models with the same engine. I have followed the issues and complaints of these trucks and suvs with the L87 6.2L engine closely. I was under the impression that my vehicle was not included in the recall and I have always been very diligent about vehicle maintenance. I've been watching my truck closely for abnormal noises, power or oil pressure loss or any other strange symptoms I have not noticed any warning signs. I even recently switched to the new dexos approved 0w-40 engine oil that GM is recommending and/or mandating. This was very sudden and scary scenario. I do have video of the engine noises if theyre. Theyre not currently formatted for this report
Engine oil cooler line leaks and crimping does not hold hose tight enough and slipped off crimp fitting. line came completely off of crimp fitting and leaked all engine oil. Forced engine to be turned off and low engine oil marked on dash.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 15 MPH and turning left, the low oil pressure and several unknown warning lights illuminated. The vehicle was pulled over into a parking lot. The contact stated that there was no oil in the engine. The vehicle was towed to an independent mechanic to be diagnosed. The mechanic associated the failure with the federal safety agency ID Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 30,000.
My 2019 Chevrolet Silverado has experienced repeated engine issues, including a confirmed timing chain failure. The vehicle has been taken in for repairs approximately 6–7 times for the same or related engine problems. Most concerning, the vehicle has stalled while driving, creating a serious safety hazard. Loss of power while in motion puts me and others at risk of an accident. Despite multiple repair attempts, the issue has not been permanently resolved. The timing chain failure is a major engine defect and not expected for a vehicle of this age and mileage. I am filing this complaint due to the safety risk associated with engine stalling and failure.
as i was driving down the highway the engine warning light came on and engine quit running immediately so i began to pull off of the road but couldn't get all the way off so it was sticking out on the highway i did put in park and checked oil level which was good, so i was going to try to push vehicle off the road more because there was semi-trucks and other vehicles going by at a high rate of speed but the shifter would not shift unless vehicle was running. so for the safety of my wife and myself we had to stand off into the ditch for about an hour waiting for help hoping no one slammed into our vehicle and there was some close calls. after getting the truck back to my home i then trailered it to a repair shop called Eagle Chevrolet in Chadron Nebraska where i was told the bearing in the engine had spun and it is very common on the engine in my truck which is an 6.2 L87 ENGINE and there is recalls on the same engine but only for the year 2022 and up and mine is a 2019 and was given a quote for Repair which is over $10,000.00
Engine Oil cooler line
Afm lifters has failed in my vehicle 3 times as of date. Being that its a costly repair this should be recalled. Information provided is the latest mileage.
The oil cooler lines cracked due to cold weather and oil spouted out of the engine. Truck was immediately pulled over when the chime went off, however the engine still seized up and needs to be replaced. No warning lights before, just the chime at 0 oil pressure. I see that Canada and Alaska has this part recalled and I want to know why it’s not recalled everywhere. No oil was leaking prior to this incident. This left us stranded on the side of the highway and we now have to purchase a new engine with only 65,000 miles on it.
Engine was running at the mechanic shop after getting serviced for spark plugs ,wires, new radiator was installed,and transmission service. The engine was running on the lift for the mechanic to top off transmission fluid. The engine stop by itself. Went to restart the engine no start just extending cranking. The mechanic shop has the truck trying find the issue why did engine stop while running.
"Approximately four months ago, I noticed an oil leak coming from the midsection of the engine/transmission of my 2019 Chevy Silverado LTZ with the 6.2-liter engine. At the same time, I noticed a slight knocking or rattling noise coming from, I believe, the front of the engine. Upon taking it to the dealership, they replaced the engine oil coolant lines, only to find out that the engine was still leaking oil and still making the knocking and rattling noise. They then discovering that it was the rear main seal, they have since replaced it about one week ago. Yesterday, February 6th, about 12:15 pm in the afternoon, while I was getting off the I-405 in Renton Washington and merging onto the southbound lanes of 167. I was in the left lane and I made it about a quarter mile down 167 doing about 60 to 65 miles per hour and I lost power suddenly. As I started to merge into the right lane, I noticed the engine light came on, and then the truck seemed to kick down into first gear while I was doing 50 miles per hour, which instantly slowed it down. This forced me to cross over an on-ramp lane to get to the shoulder and come to a complete stop. After that, the truck would not start at all. I then had to sit on the side of the road for three and a half hours waiting for a tow truck to take me and my truck back to the dealership, which is also the same dealership where I bought the truck back in 2019. They have not diagnosed it yet as I just dropped it off at 4 pm on 2/5/2026. My truck has approximately 155,000 miles on it.
The contact owns a 2019 Chevrolet Silverado 1500. The vehicle was taken to the dealer for an oil change and the contact was informed that the engine oil coolant line had detached from the crimp joints, causing an oil leak. Prior to the maintenance service, oil stains were found on the ground of the garage floor. The vehicle was not repaired. The contact stated that a week prior to the failure, there was an abnormal coolant odor coming from the vehicle and was entering the cabin from the A/C vents. The vehicle was taken to the dealer, where a pressure test was performed, and the contact was informed that the radiator was cracked. The vehicle was not repaired. The vehicle was taken to Firestone for a second opinion, and it was confirmed that the radiator was cracked. The vehicle was repaired. The manufacturer was made aware of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 40,000.
Cylinder 7 lost compression due to Cylinder 7 Exhaust AFM cylinder not moving. this is the second time I have had this issue in a little over a year. at the time of failure while driving the vehicle lost all power and would only run 25 - 30 mph causing me to have to veer off on the shoulder. yes it has been reproduced Register Chevrolet has it in the shop now and have found the same issue as before there were no warnings other than a slight backfire and then a severe engine misfire.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was parked in the driveway, and the contact became aware of a puddle on the ground underneath the vehicle. The contact thought that the puddle was coolant, but discovered that the vehicle was leaking oil. The vehicle was taken to the dealer, who determined that the oil cooler line had failed and needed to be replaced. The vehicle was not yet repaired. The contact related the failure to the Customer Satisfaction Program: N192220080 (Engine Oil Cooler Lines Detaching from Crimp – Canada and State of Alaska Only); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 118,000.
COMPLETE ENGINE FAILURE AND LOSS OF POWER. While driving, I lost complete power of all systems and truck shut down with no warning lights or alarms at all. Truck is regularly serviced but has always used oil between servicing. Truck had only been driven for 500 miles since last oil service. Upon towing to the repair shop, we were told that the engine was destroyed and we have to have a new engine.
I have experienced a catastrophic engine failure due to the faulty GM DFM lifters and oil pump. I was advised that my vehicle will need a new engine. I know there is Bulletin No.: 24-NA-173 for my vehicle. I have contacted GM, and they advised that there is nothing they can do since the truck is out of warranty. I know they are under investigation for the 6.2 L engine failure issues, and I feel as if this needs to include the 5.3L engines as well. This is very disappointing since I purchased this vehicle new, and have meticulously maintained it. Perhaps the CPA needs to get involved as well.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Chevrolet Silverado 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history